Escolar Documentos
Profissional Documentos
Cultura Documentos
szz+,ry ,
Record Of Amendments
10
NAVALENGINEERING STANDARD 3
ISSUE 1
GUIDE TO
© CROWN
NES 3
Issue 1
CONDITIONS OF RELEASE
General
1. This Naval Engineering Standard (NES) has been prepared for the use of
the Crown and of its contractors in the execution of contracts for the
Crown and, subject to the Unfair Contract Terms Act 1977, the Crown will
not be liable in anyway whatever where the Standard is used for any
other purpose .
2. This document is Crown Copyright and the information therein may be sub-
ject to Crown or third party rights . It is not to be released, repro-
duced or published without written permission of the MOD .
3. The Crown reserves the right to amend or modify the contents of this NES
without consulting or informing any holder .
4. This NES may call for the use of processes, substances and procedures
that may be injurious to health if adequate precautions are not taken .
It refers only to technical suitability and in no way absolves either
the supplier or the user from statutory obligations relating to health
and safety at any stage of manufacture or use .
6. This NES is the property of the Crown and unless otherwise authorized in
writing by the MOD must be returned on completion of the contract, or
submission of the tender, in connection with which it is issued .
7. When this NES is used in connection with a tender or contract, the user
is to ensure that he is in possession of the appropriate version of each
document, including related documents, relevant to each particular
tender or contract .
NES 3
Issue 1
CONTENTS
Page Clauses
AUTHORIZN (i)
CONTENTS (iii)
INTRODUCTION (iv)
SECTION 1 SCOPE 1
SECTION 3 ABBREVIATIONS 1
Table 1 Abbreviations 2
NES 3
Issue 1
INTRODUCTION
3. The extant aspects of NES1000 Part 2 Issue 4 dated October 1987 have
been included in this standard .
4. Any user of this NES either within MOD or in industry may propose an
amendment to it . Proposals for amendments that are not directly appli-
cable to a particular contract are to be made to the Sponsor of the NES
and those directly applicable to a particular contract are to be dealt
with using existing procedures or as specified in the contract .
7. Any significant amendments that may be made to this NES at a later date
will be indicated by a vertical sideline . Deletions will be indicated
by 000 appearing at the end of the line interval .
NES 3
Issue 1
1. SCOPE
Application
0102 . The list is for guidance only . The acceptability of any standard
listed for use in any aspect of procurement or maintenance of Naval
equipment is at the discretion of MOD' Project Manager .
2. RELATED DOCUMENTS
0301 . For the purpose of this NES the abbreviations shown in Table 1 apply .
67(CPT114/RC)324 .5(8) 1,
NES 3
Issue 1
ABBREVIATION TERM
TABLE 1 - ABBREVIATIONS
67(CPT114/RC)324 .6(5) 2.
NES 3
Issue 1
cont
ABBREVIATION TERM
HCTM HomeCandTpryMemoandu
HMSO HerMajsty'SionerOfc
*HQPO HeadqurtsPckginOrazto(nwCPU,
HR DQA/TS)
TABLE 1 - ABBREVIATIONS
67(CPT114/RC)324 .7(5) 3.
NES 3
Issue 1
cont
ABBREVIATION TERM
MIL-HBK MiltaryHndbok
MIL-SPEC Military Specification
MIL-STD Military Standard
MI MS Mineral Insulated Metal Sheathed
SI Safety Instructions
SLOP Software Issuing Organization Processes
SMA Ship Maintenance Authority
*SRDE Signals Research Development Establishment
SSCP Sea Systems Controllerate Publication
SSC Sea Systems Controllerate
STANAG Standardization Agreement (NATO)
STAT INST(SI) Statutory Instruments
67(CPT114/RC)324 .8(4) 4.
NES 3
Issue 1
4 .ALPHBETIC SOFUBJECT
STANDARD/
SUBJECT
SPECIFICATION
ABBREVIATIONS AND SYMBOLS NES 707
ABRSIVE,P ANDCLOTHS
ACCESSIBILITY
ACIDS
Acetic BS 576
Nitric, commercial DEF 52
Nitric, technical DEF STAN 68-17
Sulphuric, technical DEF STAN 68-14
ACOUSTICS
ADHESIV
cont
67(CPT114/RC)324 .9(4) 5.
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
ADHESIV, (cont)
cont
67(CPT114/RC)324 .10(5) 6.
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
ADHESIV (cont)
AERIALS
AGREEMENTS
AIR
cont
67(CPT114/RC)324 .11(5) 7.
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
AIR (cont)
Compressed
Compressors
Distribution Systems
Filters
Purification
con
67(CPT114/RC)324 .12(3) 8.
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
AIRCRAFT
Compressed air non breathing supply pressure and (see AIR COMPRESSED)
hoses for aircraft systems
Fuel system, aviation NES 319
General requirements for equipment BS 3G100 Pts 1 & 2
OperatingHdbok BR 766B
Wheels, Tyres and Brake Systems AP 2337 Pt 2
Airworthiness
67(CPT114/RC)324 .13(6) 9.
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
ANTI-CODES HATR
ASBESTOS
Note : To be used in special circumstances only
67(CPT114/RC)324 .14(4) 10 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT SPECIFICATION
BALANCING
BALLISTICS
BATTERIES
67(CPT114/RC)324 .15(5) 11 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
BATTERIES (cont)
BEARINGS
BELLOWS RUBBER
67(CPT114/RC)324 .16(4) 12 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
BLANKETS
BLAST CURVES,
Book of BR 1031
BOARDS
67(CPT114/RC)324 .17(4) 13 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
BOILERS
BOLTING
BRAZING
BREATHINGP US
67(CPT114/RC)324 .18(4) 14 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
Carbon type for use with metric dimension brush DEF STAN 59-22,
holders BS 4999 Pt 147
BULKHEADS (AlsoeSHIP
CONSTRUCTION)
BURNERS
BUSBARS
CABINET ELECTRONIC
AUWE standard cabinet for electronic equipment AUWE Pub 14653, A/S 7914,
BR 2762
General
67(CPT114/RC)324 .19(4) 15 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
General (cont)
JointgHMshpandubmries BR 4539
67(CPT114/RC)324 .20(3) 16 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
General (cont)
Silicon rubber insulated for general purposes NES 527, NES 512 Pt 2
Small multi-core cables DEF STAN 61-12 Pt 5
Spark testing BS 5099
Sub-miniature electric cables NES 512 Pt 6,
DEF STAN 61-12 Pt 4
Assemblies
cont
67(CPT114/PF)324 .21(5) 17 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
Bandin
Compression Joints
Glands
Sheathin .
cont
67(CPT114/RC)324 .22(4) 18 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
Testing
Trunkin .
CALIBRATION
Electrolytic :
Non-solid electrolyte, aluminium DEF STAN 59-44 Pt 9
Non-solid electrolyte, tantalum DEF STAN 59-44 Pt 3,
DEF 5134-A-5, BS 9073
Solid electrolyte, aluminium DEF STAN 59-44 Pt 8,
DEF-5134-A-1
67(CPT114/RC)324 .23(4) 19 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
CAPACITORS (cont)
Fixed (cont)
Variable
CAPS PROTECTIVE
Dust and moisture seal for beaded pipe ends (inch DEF STAN 53-73
series) for aircraft purposes
CARBON FIBRE
cont
67(CPT114/RC)324 .24(3) 20 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
CARBURIZING COMPOUND
CASES
Packin .
Equipment
Rack mounting and associated lids, panels and DEF STAN 59-46, RAE/RSP
shelves, suitable for use with 19-inch racks 1966
'Creeth' cases, equipment construction practice SRDE Report No 1123
CATALOGUE
CATERING
Haighdspomtcunerikwastdpoluni BR 6575(800)
HobartmixngdcmahineModlN50 BR 6575(008)
HobartmixngcheModlAE20 BR 6575(016)
Hobartp elModE610 BR 6575(015)
CATHODIPREN
67(CPT114/RC)324 .25(5) 21 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
CHAIRS
CINEMA
CIRCUIT BREAKERS
cont
67(CPT114/RC)324 .26(4) 22 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
CISTERNS
CLADDING
CLAMPS
Hose,wrmdiv
General purpose use DEF STAN 47-11, BS 5315
Loop (rigid) DEF STAN 53-15
CLASSIFICATION
CLEANING
Acetone BS 509
Air-systems, compressed NES 373
Bilge cleaning material DG Ships 6992
Butan-l-ol BS 508
Cleaning of items for fluid systems NES 341
Compound, cold-bath type, for metal DEF STAN 80-20
Compound, hot-bath type, for metal DEF STAN 80-19
Detergent (build) liquid DG Ships 305
Emulsifier for solvent cleaner TS 354
Emulsion polyvinyl acetate (PVA) TS 10205
Ethanol for industrial use BS 507
Filling and stuffing for bedding BS 1425
Isopropyl alchol (IPA) (propan-2-ol) BS 1595
Mineral, for paints and other purposes BS 245
Perchloroethylene BS 1593
.Ships during build NES 726
Soap BS 1912, BS 1913
Solvent for grease, emulsifiable TS 414
Solvent for painting equipment DEF STAN 80-67
Trichloroethylene BS 580
Trichloroethylene, technical (inhibited) DEF STAN 68-26
67(CPT114/RC)324 .27(3) 23 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT SPECIFICATION
CLIPS
CLIPS, ELECTRICAL
COATINGS
Electro-deposition
of cadmium DEF STAN 03-19
of nickel and chromium DEF STAN 03-10
of tin DEF STAN 03-8
of zinc DEF STAN 03-20
Electrolysis nickel of metals DEF STAN 03-5
Electroplated coatings of cadmium and zinc on BS 1706
iron and steel
Hot-dipgalvnzecotigs BS 729
con
67(CPT114/RC)324 .28(4) 24 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT SPECIFICATION
CODIFICATION NATO
COMMUNICATIONS
Helicoptrmunaiosytem BR 4512
67(CPT114/RC)324 .29(4) 25 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
COMMUNICATIONS (cont)
CONDENSERS
CONDUCTORS (ELECTRICAL)
cont
67(CPT114/RC)324 .30(4) 26 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
Non-metallic
Electrical installations BS 4607
Polymeric, general requirement DEF STAN 59-77
Steel
Electrical installation (metric) BS 4568
Flexible, electric cable protection BS 731 Pt 1, BS 31
CONFIGURATION MANAGEMENT
CONNECTORS, ELECTRICAL
67(CPT114/RC)324 .31(4) 27 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
cost
67(CPT114/RC)324 .32(4) 28 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
CONTACT UNITS
CONTACTORS
CONTROL
Knobs
Plus Cocks
CONVERSION EQUIPMENT
67(CPT114/RC)324 .33(4) 29 .
NES 3
Issue 1
cant
SUBJECT STANDARD/
SPECIFICATION
COOLERS
CORES, MAGNETIC
CORK
CORROSION
cant
67(CPT114/RC)324 .34(4) 30 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
CORROSION (cont)
Bi-metallic
Electrochemical
Prevention
COUPLINGS
CRAFT, MARINE
Guide/manual DL 1005
67(CPT114/RC)324 .35(5) 31 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
CRYSTAL UNITS
CURTAINS
cont
67(CPT114/RC)324 .36(4) 32 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
DATA
DATA CODE
DATA PROCESSING
cont
67(CPT114/RC)324 .38(4) 33 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
DATA TRANSMISSION
DECKING
DEGAUSSING
67(CPT114/RC)324 .39(3) 34 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
DE-RUSTING OF STEEL
DESALINATION
DESCALING OF STEEL
DESICCATION
Activated silica gel for dynamic air drying DEF STAN 80-22
Alumina, activated BS 2541
Containers filled with silica gel UK/ISC/S/3272
Desiccant containers, dehumidifier and indicators, DEF STAN 44-2 Pt 1
humidity plug, general requirements
Desiccant containers, dehumidifier (breather-tube DEF STAN 44-2 Pt 3
type)
Desiccant containers, dehumidifier (tubular type) DEF STAN 44-2 Pt 2
Dessicant containers, dehumidifier DEF STAN 44-2 Pt 4
(sachet-type without sight window)
(sachet-type with window)
Desiccant container dehumidifier indicator DEF STAN 66-14
humidity plug
Glass vacuum desiccators, design of BS 3423
Silica gel, BS 2540
Silica gel, cobalt chloride, impregnated BS 3523
Silica gel, acid-activated, for aircraft purposes BS M 22
Tapped holes for desiccating unions, metric DEF STAN 53-63
Use of, in packaging BS 1133 Sect 19
Used in dynamic dehumidification equipment, tests BS 3482
DESIGNAUTHOR (see NEW CONSTRUCTION)
cont
67(CPT114/RC)324 .40(4) 35 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
DESIGN
DETECTION EQUIPMENT
DIODES, SEMI-CONDUCTOR
DOCKING
67(CPT114/RC)324 .41(4) 36 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
DOCUMENTATION
DRAINAGE
DRAWINGS
cont
67(CPT114/RC)324 .42(6) 37 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
DRAWINGS (cont)
DRILLS
DRIVES
Belt
Endless, V-belt BS 3790
Endless, wedge BS 3790
Synchronous BS 4548
V, endless-light and heavy drives DEF STAN 30-2
DRUMS
67(CPT114/RC)324 .43(4) 38 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
EARTHING,OUDABNIG
ELECTRICAL
Power
cont
67(CPT114/RC)324 .46(5) 39 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
ELECTRICAL (cont)
Shock
Terminal Markings
Terminals, Electrical
Tools
ELECTROLYTE
67(CPT114/RC)324 .47(4) 40 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
Com •o nents
67(CPT114/RC)324 .48(4) 41 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
ELECTRONICS, (contd)
Qualification approval and quality assurance, DEF STAN 00-9, DEF CON 17
general requirements
Sampling procedures and tables for inspection by BS 6001, BS E 9007
attributes
Selection guide (BS 9000) BS PD 9002
Subsitution guide BR 1923
Requirements for the selection and approval of NES 581
electrical and electronic components
Accessories
Display Devices
ELECTRO-OPTIC DEVICES
67(CPT114/RC)324 .49(4) 42 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
Handligof
Conductive foam sheet (for the protection BS 5783, TS 10218
of SSD's)
Of equipment NES 501
ELCTROHNIAQUPMET
EMBARKATION
Materials
ENCLOSURE DESIGN
ENGINES
67(CPT114/RC)324 .50(4) 43 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
ENVIRONMENT
Airborne
Land-based
Seaborne
EQUIPMENT
67(CPT114/RC)324 .51(5) 44 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
ERGONOMICS
EXPLOSIVES
CategorisfcmpateniHMshp BR 862
accordance with BR 862 (Naval magazine and
explosive regulations)
Demolition stores and equipment DEF STAN 13-31
Design safety principles for demolition and DEF STAN 13-37 Pt 3
engineering explosive stores
Detonators, general fuzes, general gaines OB PROC Q 8168
Electrical apparatus for explosive atmospheres BS 4683, BS 6941
Electrical apparatus for potentially explosive . BS 5501
atmospheres
Manufacture, inspection and proof of ordnance DEF STAN 13-92
of monobloc construction
Principles of safety in electrical circuits OB PROC 41273
containing explosive components
RF environment and acceptance criteria NES 1006
Requirement for electrical equipment and NES 519, BS 5345
installations fitted in magazines, adjacent
compartments and designated danger areas in
surface ships
Safety requirements for the design of naval NES 1008
weapon equipment
Unexploded ordnance, sign warning DEF STAN 99-1
EYELETS
cont
67(CPT114/RC)324 .52(4) 45 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
FABRICATION
cont
67(CPT114/RC)324 .54(4) 46 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
FANS
FASTENERS, GENERAL
67(CPT114/RC)324 .55(4) 47 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
FASTENERS, (cont)
Hexagonhd(ct)
Machine brass, nuts DEF STAN 53-37,
DEF STAN 53-66
Machine corrosion resistant steel :
Bolts DEF STAN 53-39
Nuts DEF STAN 53-60
Screws DEF STAN 53-40
Machine steel, bolts DEF STAN 53-18,
DEF STAN 53-62,
DEF STAN 53-51
Machine steel, nuts DEF STAN 53-27,
DEF STAN 53-45,
DEF STAN 53-48
Machine steel, screws DEF STAN 53-21,
DEF STAN 53-41,
DEF STAN 53-57
Prevailing torque type, steel nuts BS 4929
Steel cadmium plated bolts (unified) for BS 3A 111
aerospace use
Steel, slotted and castellated DEF STAN 53-26,
DEF STAN -53-49,
DEF STAN 53-50
Hexagonscktrew
Dimensions and tolerances BS 4168, BS 2470
Cap, steel DEF STAN 53-25,
DEF STAN 53-67,
DEF STAN 53-79
Highstrenfciogrpbltsandufor BS 4395, BS 4604
structural engineering
Plain cap (domed) nuts DEF STAN 53-58
Screws for aerospace applications BS A 260-265
Self locking nuts (unified) for aerospace use DEF STAN 00-970
Clinch nuts BS 2A 122-2A-124
Stiffnuts BS 3A 125-132, 136-143,
147-168
Substitutability DEF STAN 53-89
Self-tapping screws DEF STAN 53-76, BS 4174
Slotted head screws
Dimensions and tolerances BS 4183, BS 1981
Machine brass DEF STAN 53-38,
DEF STAN 53-65
Machine corrosion resistant steel DEF STAN 53-35
Machine steel DEF STAN 53-23,
DEF STAN 53-43,
DEF STAN 53-46
Wingnuts DEF STAN 53-61, BS 856
Woodscrews DEF STAN 53-33, BS 1210
Unified screw threads BS 1580
cont
67(CPT114/RC)324 .56(4) 48 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
FASTENERS, (cant)
Locking Devices
Rivets
Slide BS 3084
67(CPT114/RC)324 .57(4) 49 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
FASTENERS (cont)
Threads
Washers
FERRULES
cont
67(CPT114/RC)324 .58(3) 50 . .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
FIBRE OPTICS
FIBRESHT
FILTERS
Electrical
Mechanical
FINANCE SSCP 63
67(CPT114/RC)324 .59(4) 51 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
FINSHE (cont)
De-rusting of Steel
Colour Specific
Metallic Material
Aluminium spray
Coating of aluminium DEF STAN 03-3, TS 10194
Anodizing
Anodizing of titanium and titanium alloys DTD 942
Chromic acid anodizing aluminium DEF STAN 03-24
Hardnoicxeatngsolumi DEF STAN 03-26, BS 5599
Sulphuric acid anodizing aluminium DEF STAN 03-25
Cadmium
Note : The use of cadmium plating is restricted
see NES 1005
Cadmium coating of very strong steel parts DTD 940
Coating on steel threaded components BS 3382 Pt 1
Electro-deposition DEF STAN 03-19, BS 1706
Chromate
Conversion coatings for aluminium DEF STAN 03-18
Passivation of brass articles DEF STAN 03-12
Passivation of cadmium and zinc surfaces DEF-130
Protection of magnesium rich alloys against DTD 911, DTD 935
corrosion surface sealing of magnesium
rich alloys DTD 935
Chromium
Electro-deposition of nickel and chromium DEF STAN 03-10, BS 1224
Electro-deposition for engineering purposes DEF STAN 03-14
cont
NES 3
Issue 1
cont
STANDARD/
SUBJECT SPECIFICATION
FINSHE (contd)
Paints
cont
67(CPT114/RC)324 .61(4) 53 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
FINSHE (contd)
Paint (contd)
Plastics
67/CPT114/RC)324 .62(4) 54 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
FINSHE (cont)
Surfaces
Textiles
Wood
Handmeshlc BS 3280
Varnish ammunition stoving, Type QX TS 10162
Varnish marine type, brushing DEF STAN 80-63
Varnish, oil-bitumen RD 1219, RD 1322, RD 1229 DEF STAN 80-104
Type QX
67(CPT114/RC)324 .63(4) 55 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
FIRE
Detection
Extinguishers
FIRMWARE
FITTINGS
Pi-ework
FLANGES
67(CPT114/RC)324 .64(4) 56 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
FLASKS
FLUIDS
FLUXES
FOAMS
FORK ENDS
FORMS
cont
67(CPT114/RC)324 .65(4) 57 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
FREQUENCY
FRICTONLUHES
FUEL
Systems
Fuels
FURNACES
67(CPT114/RC)324 .66(4) 58 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
Holders )
Bases electrical fuse ) DEF STAN 59-100 Pt 2,
BS 88
Block type (for lug-type cartridge) )
Links :
Cartridge, lug type, centred axial lug ) DEF STAN 59-96 Pt 2,
BS 88
)
Cartridge, lug type, offset axial lug
cont
67(CPT114/RC)324 .67(3) 59 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
GALLEYS
GAS
GASKETS
GAS TURBINE
Olympus TM3B and Tyne RM1A marine gas turbine BR 6560(001)(1) and
propulsion model (002)(1)
Requirements NES 309
GAUGES
cont
67(CPT114/RC)324 .69(3) 60 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
GAUGES (cont)
GENERATING SETS
GENERATORS
67(CPT114/RC)324 .70(3) 61 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
GENERATORS (cont)
GLASS
Glass Fibre
Glass fabric for thermal insulation NES 801, BS 6374 Pts 1-5
Woven for plastic reinforcement BS 3396
Woven tapes, electrical purposes BS 3779
GLOSSARY OF TERMS
67(CPT114/RC)324 .71(4) 62 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
67(CPT114/RC)324 .72(4) 63 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
GLUE (seADHESIV)
Special TS 648
Technical BS 2623
Triacetate TS 10124, BS 1997
Glycerine/water mixture for use in the heat TS 50145
testing of explosives
GRAPHICLSYMBO
GROMMETS
Tension DGSHIPR60549-
GROUNDING (seEARTHING,OUD
AND BONDING)
67(CPT114/RC)324 .73(4) 64 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
GUARDNWISTACHONDRILS
Aluminium DGSHIP106
Requirements NES 162 Pt 1
67(CPT114/RC)324 .74(4) 65 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
HANDBOKS, (seTECHNIAL
PUBLICATIONS)
HARDNES
HEALT
HealthndSfyworketc,A1974 HMSOIBN105437
Healthpysicboratfnuclersbmai NES 795
Reducing noise exposure of employees to noise (See NOISE)
HEATING
HEATRMN
cont
67(CPT114/RC)324 .75(5) 66 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
HELICOPTR ANS
HIGVOLTAEBUSN BS 223
HINGES
HOLES
HORNS
HOSE
67(CPT114/RC)324 .76(4) 67 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
HOSE (cont)
HUMIDTYNCAOR
HYDRAULICS
Cleanliness
Comparison slide method for assessing the parti- DEF STAN 05-44
culate contamination class of hydraulic system
fluid
con
67(CPT114/RC)324 .77(3) 68 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
HYDRAULICS (cont)
Cleanliness (cont)
Fits
Oil Tanks
Systems
HYDROCLIA,MERCL BS 3993
67(CPT114/RC)324 .78(3) 69 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
HYDROMETS (METAL-TYPE)
HYDROPNES
Calibration BS 5652
con
67(CPT114IRC)324 .79(2) 70 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
Marking requirements for weapon equipment and DEF STAN 81-41, SSCP 38
packages
Marking of service materiel DEF STAN 05-34
Marking of service vehicles DEF STAN 23-4
Method of application of fluorescent and luminous RAE Instrument
markings Design Note No 2
Modification record labels
12 MOD - self-adhesive See Guide to Codified
20 MOD - self-adhesive Components
20 MOD - self adhesive RAE DRG WTB 111527
25 MOD - self-adhesive RAE DRG WTG 111527
21-32 MOD - self-adhesive ASWE A 299516
12 MOD resin-bonded flock asbestos RAE DRG WTB 111527
20 MOD aluminium RAE DRG WTB 111527
25 MOD aluminium RAE DRG WTB 111527
33-44 MOD - self-adhesive ASWE A299944
cont
6 7 (CPT114/RC)324 .81(5) 71 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
Colour coding and marking for polarity and phase DEF STAN 61-7 Pt 1
distinction
Marking code DEF STAN 61-7 Pt 2
Resistors and capacitors, marking codes BS 1852
Materials
INDEX
Material
67(CPT114/RC)324 .82(4) 72 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
INDEX (cont)
Material (cont)
INDCATGLHS
INDICATOR PLATES
Hydrant BS 3251
Machine tool, symbols for BS 3641 Pt 2
cont
67(CPT114/RC)324 .83(4) 73 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
INSTALLATION
Machinery
Re uirements
INSTRUMENTS
67(CPT114/RC)324 .84(4) 74 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
INSTRUMENTS (cont)
Evaluation
INSULATING-MATERIALS
Electrical
con
67(CPT114/RC)324 .85(5) 75 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
INSULATORS
Electrical
67(CPT114/RC)324 .86(5) 76 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
INTERCHAGBLY
cont
67(CPT114/RC)324 .87(4) 77 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
Bushes BS 1098
Requirements BS 5078
JOINTING
Compound
Material
cont
67(CPT114/RC)324 .89(4) 78 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
Electric cables
InHMShipsadubmrne BR 4539
Technique (electrical)
JUNCTION BOXES
67(CPT114/RC)324 .90(4) 79 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
con
67(CPT114/RC)324 .91(4) 80 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
LACQUERS (seFINSHE)
LAMINATIONS, MAGNETIC
cont
67(CPT114/RC)324 .93(4) 81 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
LAMPHODERS
Electric
Fluorescent
LANOI,HYDRUSTECNIAL BS 3488
LEADSHIPBUR
67(CPT114/RC)324 .94(4) 82 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
LEATHR
LIFESAVING EQUIPMENT
LIFTING ARRANGEMENTS
General
Blocks tackle (metal) general purpose for use DEF STAN 39-1
with steel wire rope and natural fibre rope
Chain pulley blocks alloy steel grade 80 BS 3114
Chain pulley blocks hand-operated BS 3243
Chain pulley blocks higher tensile steel, grade 40 BS 1663
cont
67(CPT114/RC)324 .95(5) 83 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
Chain
Cranes
Eyebolts
Eyebolts and bolts, ring for lifting purposes DEF STAN 53-24
Eyebolts for lifting purposes BS 4278
Items of smithwork DGSHIP135
Hoist
67(CPT114/RC)324 .96(4) 84 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
Hoks
Jacks
Shackles
Straps
Sockets
Tackle
cont
67(CPT114/RC)324 .97(4) 85 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
Thimbles
Webbing
Webbing, textile, cotton and webbing, cottons : DEF STAN 83-58, BS 1664-8
for load carrying purposes
Straps DEF STAN 53-54
LIFTS
LIGHTN
cont
67A(CPT114/RC)324 .98(5) 86 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT SPECIFICATION
LIGHTN (cont)
Protection
LOCKING WIRE
LOUDNESS LEVEL
cont
67A(CPT114/RC)324 .99(4) 87 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
LUBRICANTS
cont
67A(CPT114/RC)324 .100(3) 88 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
LUGS
cont
67A(CPT114/RC)324 .101(3) 89 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
MACHINERY, GUARDING OF
MAGAZINES
MAGNETIC
Loo •s
Recording
MAGNIFIERS
MAGSLIPS
cont
67A(CPT114/RC)324 .103(4) 90 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
MAINTENANCE
MARINE ENGINEERING
MASTIC
MASTS
cost
67A(CPT114/RC)324 .104(4) 91 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
MATS RUBBER
MATTRESSES
MECHANIL
Finishes (seFINSHE)
MEDICAL AREAS
cont
cont
SUBJECT STANDARD/
SPECIFICATION
METALLIC MATERIALS
General
Special Uses
Ferrous
cont
67A(CPT114/RC)324 .106(4) 93 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
Ferrous
Ferrous Castings
cont
67A(CPT114/RC)324 .107(4) 94 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT SPECIFICATION
Ferous,StlHighped
cont
67A(CPT114/RC)324 .108(5) 95 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
cont
67A(CPT114/RC)324 .109(4) 96 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT SPECIFICATION
Non-ferrous, Brass
Non-ferrous, Bronze
cont
67A(CPT114/RC)324 .110(5) 97 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
Non-ferrous, Gunmetal
cont
67A(CPT114/RC)324 .111(5) 98 .
NES 3
Issue 1
1st Draft-for-Comment
cont
SUBJECT STANDARD/
SPECIFICATION
Non-ferrous Lead
Non-ferrous, Tin
Ingot BS 3252
Sampling and analysis BS 3338
White metal bearing alloy ingots BS 3332, NES 839
cont
67A(CPT114/RC)324 .112(4) 99 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
METHYLADSPIR,NUTAL
METRIC STANDARDS
MICA
MICROCOPY
MICROFHE
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
MICROFILM
MICROFORM
MICROPHNELTS
MODIFICATION PROCEDURE
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
MOTORS
Electric
MOULDING
MOUNTS
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
NAAFI COMPARTMENTS
NAVIGATION
NBCD REQUIREMENTS
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
NITROGEN
Oil Free
cont
cont
STANDARD/
SUBJECT SPECIFICATION
NUCLEAR
Acceptance Standards
Hardeni .
Lubricants
Plating
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
Submarines
NUCLEONICS
OFFICE FURNITURE
OFFICES
Insulatin'
Pollution
Tanks
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
OSCILLATORS
OXYGEN
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
cant
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
PACKAGING (cont)
Materials
cont
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
cont
cont
STANDARD/
SUBJECT SPECIFICATION
Fouling
PAINT REMOVER
A glossary of paper, board and pulp and related (see GLOSSARY OF TERMS)
terms
Board corrugated, double faced DEF STAN 81-46
Humidtyncaor,blthide DEF-1296
Paper corrugated, single faced DEF-1253
Paper creped, kraft union, reinforced DEF-1239-A
Paper, kraft DEF STAN 81-48, TS 10077
Specification BS 4000
Technical publication binders JSP 181 Pt 1
BS 5097 Pt 1
PETROLEUM PRODUCTS
PHOTGRAIC
Equipment
Policy
Front
67A(CPT114/RC)324 .125(4)
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
cont
STANDARD/
SUBJECT SPECIFICATION
General
Repair
THERMOPLASIC
Note : Not to be used where fire risk and/or tendency to mould growth
exists
Acrylic
cont
67A(CPT114/RC)324 .127(5) 1 13 .
NES 3
Issue 1
cont
SUBJECT STANDARD/
SPECIFICATION
PLASTICS (cont)
Thermoplastics
Polyamides (nylon)
Polycarbonate
Polyethylene (polythene)
Polypropylene
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
Polystyrene
Polytetrafluoroethylene (PTFE)
Polyvinylchloride (PVC)
Styrene-acrylonitrile (SAN)
Thermo-setting
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
PLASTICS (cont)
Thermo-setting
Mechanical -
PNEUMATICS
con
cont
STANDARD/
SUBJECT
SPECIFICATION
POWDERS
POWER
PRESSURE VESSELS
Air reservoirs
Aloystecindr,HPstoage NES 317
Fusion welded steel receivers BS 5169
Storage steel (non transportable) NES 317
Details of dimensions BS 5276
Gas cylinders NES 318
Compressed BS 5045
Compressed and valves DEF STAN 81-13
CompresdHPMk6 DEF 176
CompresdHPMk12A DEF 168
Steel, liquefied gas (suitable for butane DEF 132
or propane)
Gas containers transportable BS 5045
Gauge glasses for pressure vessels BS 3463
Inspection, access and entry openings BS 470
Molybdenum alloy steel, chromed AUWE 930 .7
Nozzles and openings, design methods BS PD 6437
Review of bolted flanges BS PD 6438
cont
cont
SUBJECT STANDARD/
SPECIFICATION
PROCEDURES
cont
STANDARD/
SUBJECT SPECIFICATION
PROCESS CONTROL
PROCUREMENT
PROGRAMMING
PROGRESS REPORTING
PROJECT MANAGEMENT
PROJECTNWK,HIQUEGLOSARY BS 4335
PROJECTORS
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
PROPELLERS
PROPULSION
PROPULSORS
PROVISIONING
PUBLICATIONS (seTECHNIAL
PUBLICATIONS)
PUNCHEDARS BS 4636
con
cont
STANDARD/
SUBJECT
SPECIFICATION
QUALIFICATION APPROVAL
QUALITY
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
QUALITY (cont)
con
cont
STANDARD/
SUBJECT
SPECIFICATION
RACKS
RADIO ENVIRONMENT
RADIO INTERFERENCE
REACTOR CONTROL
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
REACTOR PLANT
RECORDS
RECTIFIERS, METALLIC
REFRIGERATION
Refrigerated Spaces
Systems
REGULATIONS
REGULATORS
Electrical
cont
STANDARD/
SUBJECT SPECIFICATION
RELAYS, ELECTRICAL
REPLNISHMTA (R)
cont
STANDARD/
SUBJECT
SPECIFICATION
RESISTORS (cont)
Fixed
Variable
RESUSCITATION
RIGGING (seSHIP'RGN)
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
General
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
RUBBER (cont)
General (cont)
HRCompatible
Cellular Vulcanized
cont
NES 3
Issue 1
cont
STANDARD/
SUBJECT SPECIFICATION
RUBBER (cont)
Vulcanized Compounds
cont
cont
SUBJECT STANDARD/
SPECIFICATION
SAFETY
General
cont
STANDARD/
SUBJECT SPECIFICATION
SAFETY (cont)
cont
67A(CPT114/RC)324 .148(5) 131 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
SAFETY (cont)
Requirements
SAMPLING
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
Screw Threads
SCUTTLES BS MA 24
SEA-WTRYMINHSP
SEALS
cont
*Not yet published
cont
STANDARD/
SUBJECT
SPECIFICATION
SEALS (cont)
SEATINGS
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
SENSORS
SERVO COMPONENTS
SHAFTINGD
Ends BS 4506
Propeller, tapered and other outboard details BS MA 74 (obsolescent)
Repairs, propellers and shafting NES 304, Pts 4 & 5*
Systems NES 304, Pts 1, 2 & 3
Rotary lip seals BS 1399
SHAVER
SHEATING
cont
*Not yet issued
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
SHIELDNG
Acceptance standards for surface ship structure NES 154, Lloyds Rules
Bollards (BS MA 12 (obsolescent)
BS MA 19 (obsolescent)
BR 2790
Breakage NES 145
Building accuracy, surface ships NES 147
Bulkheads, composite NES 130, Pt 2
Bulkhead pieces and tank pads BS MA 75, Pts 1 & 2
(obsolescent)
Classification, weight groups for ships NES 163
Damage control NES 119
Davits NES 113, BS MA 41
Deck coverings NES 157
Defence NBC materiel NES 118
Design of surface ship structure SSCP 23
Docking, MOD vessels NES 850
Draft marks NES 723
Fabrication, ship structure NES 706
Fairing and filling materials NES 789
Fairleads BS MA - 19, 21, 22 & 23
(obsolescent)
GRP, Ship Structure design NES 140
GRP Maintenance, survey and repair NES 752
Guard stanchions and rails NES 162
Hatchwys BS 4263 (obsolescent),
BS 4268, NES 501
Hydronamicesg NES 108
Laying off NES 146
Lineouts, mockups and models NES 709, Pts 1, 2 & 3
Maintenance envelopes and removal routes NES 302, Pts 1 & 2
Mast and deck fittings BSMA 28
Planning and programming the build of surface
ships NES 21
Pressure hulls, visual survey and thickness
gauging NES 842
Replenishment at sea NES 114
Scuttles : shipside BSMA 24
Ships windows BSMA 25
Stability manual NES 109
Structural practices in steel surface ships NES 155, Pts 1 & 2
Structures manual NES 110, NES 154, SSCP 23
Weatherdecks and side arrangements NES 115
Weight and stability control NES 109
Welding and fabrication QIN type steel NES 770, Pts 1, 2 & 3*
d a U
of ship structure NES 706
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
SHIPCONTRU (cont)
SHIPRGN
Equipment,lcradmehnicl,HMsp BR 3021
Shock strength and testing requirements for DGSHIP349
equipment
cont
*Not yet issued
cont
SUBJECT STANDARD/
SPECIFICATION
SHUNTEXRAL
SIGNALLING EQUIPMENT
cost
cont
STANDARD/
SUBJECT
SPECIFICATION
SLEEVES
SOUND
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
SPARE GEAR
SPECIFICATION INDEXES
SPINDLES
cont
cont
STANDARD/
SUBJECT SPECIFICATION
SPRINGS
STABILITY
STABILIZERS
STANDARDIZATION
STARTERS
cont
cont
SUBJECT STANDARD/
SPECIFICATION
STEAM
STORES
Accounting instructions BR 96
Armament, safety requirements BR 8541
Data for the introduction and provision SSC Form 55
Hazrdouste BR(F) 320J
Joint Stores - catalogue BR 1246
Naval stores, catalogue BR(F) 320D
Storehouse manual BR 1692
Storerooms NES 126
Victualling stores, catalogue BR 1246
STRAINERS
(seSHIPCONTRU )
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
SUPPORT
SURVEY
SUSPENSION EQUIPMENT
SWITCHE
Switch Boards
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
SWITCHE . (cont)
SYMBOLS (seGRAPHICLSYMBO)
SYNCHRO
cont
cont
STANDARD/
SUBJECT SPECIFICATION
SYSTEMS
cont
*Not yet issued
cont
STANDARD/
SUBJECT
SPECIFICATION
TAPES
Adhesive
Magnetic
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
TAPES (cont)
TECHNIALPUB OS
Publications
Requirements
Terms
cont
*Not yet issued
cont
SUBJECT STANDARD/
SPECIFICATION
TELEVISION
Equipment : Test
Procedures
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
Testing
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
Testing (cont)
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
Testing (cont)
Machines
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
THREAD,SWING
Note : For ammunition use Type QX sewing thread, DEF STAN 83-60
polyester
TIMBER
TOOLS
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
TOWING (seANCHORIG)
TRAINING EQUIPMENT
TRANSDUCERS
cont
cont
SUBJECT STANDARD/
SPECIFICATION
TRANSISTORS
Pressure
TREATMENT
TRICHLOEAN
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
TUBES
TURBINES
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
UNDERCTSA OUCREWTHADS
UNDERWATBHIGPARTUS (seBREATHING
APPARATUS)
UNITS
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
VALVES
Electronic
Mechanical
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
VALVES (cont)
Mechanical
VARNISH (seFINSHE,VAR
AND . LACQUERS)
VESSELS BS 4994
cont
*Not yet issued
cont
STANDARD/
SUBJECT
SPECIFICATION
VOLTAGE MEASUREMENT
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
WASTE
WATER
Feed
WAXES
WEAPONS
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
WEAPONS (cont)
Equipment
Systems
WEATHRDCK NGMETS
WEIGHTROUPS
WELDING
cont
*Not yet issued
cont
SUBJECT STANDARD/
SPECIFICATION
WELDING (cont)
cont
67A(CPT114/RC)324 .183(4) 162 .
NES 3
Issue 1
cont
STANDARD/
SUBJECT
SPECIFICATION
WELDING (cont)
cont
*Not yet issued
cont
SUBJECT STANDARD/
SPECIFICATION
WINDOWS
WIPERS
WIRE
cont
cont
STANDARD/
SUBJECT
SPECIFICATION
WORKSHP
Conditions
Equipment
WRENCHKYS
Inch BS 2470
Metric BS 4168
WRENCHIGFATUS
cont
cont
SUBJECT STANDARD/
SPECIFICATION
cont
NES 3
Issue 1
ANNEX A
SUPPLIER
DOCUMENT REF
ANSI/IEEE Documents 9
*ASWE Drawing 3
*AUWE Drawings 5
*AUWE Publications 6
NES 3
Issue 1
cont
SUPPLIER
DOCUMENT REF
CPU/DR Series 11
CPU/PIP Series 11
DefncCodiatAuhryHndbok 13
D Mat Specifications 22
EPIC Databank 32
'G' Specs 39
NES 3
Issue 1
cont
SUPPLIER
DOCUMENT REF
HQPO/Seris 11
HumanFctorsfDeignoNavlEquipment 16
MIL Documents 18
cont
SUPPLIER
DOCUMENT REF
NationlAerucandSpeAmistraonHdbk 30
(NHB)
NAVSTARCODE 27
ReliabtyAnsCerRpot(AC/DH) 30
Safety Instructions 14
cont
SUPPLIER
DOCUMENT REF
cont
SUPPLIER
ADDRESS
REF
1 Directorate of Standardization
STAN1/3KentigrHous
65 Brown Street
Glasgow G2 8EX
2 REME Publications
Repository Road
Woolwich SE18 4QA
4 DDEWS/ST62D
Room 95 Block B
Ensleigh
Bath, BA1 5AB
6 The Library
ARE Southwell
Portland, DT5 2JS
cont
SUPPLIER ADDRESS
REF
14 HerMajsty'SionerOfc
Publications Centre
PO Box 276
London SW8 5DT
cont
SUPPLIER
ADDRESS
REF
16 The Secretary
Royal Naval Personnel Research
Committee, Room 839, MOD
Empress State Building
London SW6 1TR
17 Micro-Info Limited
PO Box 3
Newmans Lane
Alton GU34 2PG
20 DDEWS/CINO
Branch 63B Block B
Ensleigh
Bath BA1 5AB
cont
SUPPLIER
REF ADDRESS
27 DOR(Sea)/RPI
Room 5326
MOD Main Building
Whitehall
LondSW1A2HB
28 The Secretary,
JLMC
Rom207,PrspectHou
100 New Oxford Street
LondWC1HE
cont
SUPPLIER
ADDRESS
REF
30 DefncRsarhIfomtinCer,KgnHouse
65, Brown St
Glasgow G2 8EX
34 System Co-ordinator
Thermal Imaging Common Modules
Electro-optical Division
Marconi Avionics Ltd
Basildon SS14 3EL
36 DDEWS/CINO
Branch 6381
Room 129, Block B
MOD Ensleigh
Bath BA1 5AB
cont
SUPPLIER
ADDRESS
REF
37 Superintending Scientist
ARE Dockyard Laboratory
HM Naval Base
Portsmouth P01 3NB
39 ED/Issues
DQA/PS
Building 9
Royal Arsenal West
London SE18 6ST
41 APFS(Pub 4)
Building 10
Royal Arsenal West
London SE18 6TD
43 COD Donnington
PO Box 202
Telford TE2 8QW
DStanHelpdsk
File Reference
Contract Requirements
When Defence Standards are incorporated into contracts users are responsible for their correct
application and for complying with contractual and statutory requirements . Compliance with a
Defence Standard does not in itself confer immunity from legal obligations .