Escolar Documentos
Profissional Documentos
Cultura Documentos
[2] [1]
[2]
F-7-54
7.10.6 Drum Cleaner Unit
2)Insert the drum rotating tool [1] that
7.10.6.1 Construction 0009-5638 comes with the unit into the slit [3] in the
drum shaft [2]. While keeping the drum
in place so that it will not rotate
counterclockwise, insert a screwdriver
Cleaning blade into the center opening [4] in the drum
rotating tool to remove the drum fixing
screw.
Separation claw
F-7-53
7-50
Chapter 7
[1] [2]
[1]
[4]
F-7-55
F-7-56
If the drum is let to rotate coun- 4) Slide out the process unit [1] until it
terclockwise, the cleaning blade will not stops.
come into contact with the drum correctly,
leading to cleaning faults. Be sure to fix the [1]
drum in place first before removing the
drum fixing screw to avoid the problem.
MEMO:
If the hopper assembly is re-leased but not
removed, be sure to open the right upper
cover and the right lower cover so that
there will be space.
F-7-57
7-51
Chapter 7
F-7-58
F-7-62
7-52
Chapter 7
2) Tighten the five mounting screws [3] inner end of the side seal is within the
lightly, stopping to turn them when re- area [3] of the washer.
sistance is felt. - When replacing the side seal [1] at the
3) Turn the screws tightened lightly in step rear, push the magnet roller [2] toward
2) about 20 deg to 30 deg in the order the front and then make sure that the
indicated, tightening them fully. inner end of the side seal is within the
area [3] of the washer.
[3] 2) The bottom end of each side seal [1]
must be 0 to 0.5 mm from the corner of
the cleaner hosing; i.e., point of
5 3 1 2 4 reference [4].
3) Attach the side seal [1] at the front and
order of tightening the rear to the cleaner housing while
F-7-63 making sure its position is as indicated.
[3] [2]
7-53
Chapter 7
30 to 40mm
Remove waste toner
(rear)
4 to 8mm A
30 to 40mm
4 to 8mm
(front)
A Remove waste toner
F-7-66
0009-3956
7-54