Escolar Documentos
Profissional Documentos
Cultura Documentos
Generator Set
with PowerCommand 3200 Controller
English
Original Instructions 6-2017 0960−0284 (Issue 17)
To avoid errors or delay in filling your parts order, al- The following symbols are used in Cummins Inc.
ways give the MODEL, SPEC NO. and SERIAL NO. manuals to alert users to the potentially dangerous
from the Cummins Inc. nameplate. conditions relating to maintenance of equipment and
replacement of parts. Please read and observe.
For handy reference, insert your nameplate in-
formation in the spaces below. This symbol warns of immediate
hazards which will result in severe
personal injury or death.
MODEL AND SPEC NO.
This symbol refers to a hazard or
unsafe practice which can result
SERIAL NO. in severe personal injury or death.
Service and repair of Cummins Inc. equipment must be performed by trained, experienced personnel
only. Improper service or repair may result in property damage, severe personal injury or death. Do not
use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY
INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on.
Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA
state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine
oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil.
Contact with ASBESTOS has been identified by a United States federal agency and some USA state agen-
cies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all neces-
sary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation
and wear protective gloves, masks and clothing!
Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by
a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE
TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all nec-
essary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and
wear protective gloves, masks and protective clothing!
PSP-1
This catalog applies to Cummins Inc. Generator Models DQKB and DQKC as listed in the Generator Set Data Table.
Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding
to the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned in the descrip-
tion or page heading, parts are interchangeable between models. Throughout this catalog left and right sides are deter-
mined by facing the engine end (front) of the set unless noted in the description column.
Engine parts that have been modified or added by Cummins Inc. are identified in this catalog. All other engine replace-
ment parts must be ordered from the engine manufacturer by referring to the engine manufacturer’s nameplate and sup-
plying all available information. Contact your nearest engine parts distributor for assistance in ordering replacement
parts.
Replacement Engine
* − The diagonal line (/) in the model and specification number separates generator set characteristics from the
specification number and letter. The specification number denotes customer requested options or deviations from
the standard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes.
Block, Terminal − Resistive Temperature Detec- Cap, Expansion Tank − Radiator − Spec A, 33
tors, 72 Cap, Radiator, 37 , 38 , 39 , 40
Board, Printed Circuit − Backplane, 69 Cap, Radiator − Heat Exchanger, 21
Board, Printed Circuit − Base, 69 Cap, Radiator − Spec A, 33
Board, Printed Circuit − Control, 67 Cartridge, Heater − Generator Heater, 55
Board, Printed Circuit − Fuel, 69 Clamp, Hose − Jacket Water, 36 , 40
Board, Printed Circuit − Generator Interface, 69 Clamp, Hose − Radiator, 39 , 47 , 49
Board, Printed Circuit − Lonworks, 69 Cleaner, Air − Begin Spec F, 11
Board, Printed Circuit − Parallel, 69 Cleaner, Air − Spec A−E, 9
Boot, Battery, 7 Clip, Socket Mounting − Relay, 73
Box, Control − Engine Coolant Heater − Spec Cock, Drain − Heat Exchanger, 21
A−D, 15
Control, Engine Coolant Heater, 19
Box, Control − Generator Set, 67
Control, Engine Coolant Heater − Spec A−D, 15
Box, Entrance − 100% UL Rated, 56
Control, PowerCommand, 67
Box, Terminal − Generator Heater, 55
Cooler, Fuel, 41 , 47 , 49
Brace, Skid − Radiator − Spec A, 29
Cooler, Fuel − Sets With Heat Exchanger Cool-
Bracket, LTA, 37 , 38 ing, 52
Bracket, Belt Guard − 40 C, 50 Cooler, Fuel − Sets With Radiator Cooling − Spec
Bracket, Control Mounting − Frame 7 Generators, A, 33
59 Core, Aftercooler − Spec A, 31
Bracket, Guard − 50 C, 51 Core, Jacketwater − Spec A, 30
Bracket, Isolator − Control, 67 Core, Radiator, 39
Bracket, Mounting − Coolant Heater − Spec A−D, Core, Radiator − Jacket Water, 50 Hz & 60 Hz
13 Begin Spec E, 40
Bracket, Mounting − Resistive Temperature De- Core, Radiator − Jacket Water, Begin Spec D, 36
tectors, 72
Core, Radiator − Jacket Water, Spec B−C, 36
Bracket, PT Bus Mounting − Control, 67
S T
Seal, Radiator − Silicone, 37 Tank, Aftercooler − Spec A, 31
Sealant, Thread, 6 Tank, Bottom − Jacket Water, 40
Sender, Low Coolant Level − Radiator Cooling − Tank, Expansion − Heat Exchanger, 21
Spec A, 35
Tank, Expansion − Radiator − Spec A, 33
Sender, Low Coolant Level − Remote Radiator −
Tank, Jacketwater − Spec A, 30
Begin Spec D, 27
Thermostat − Engine Coolant Heater, 17
Sender, Low Coolant Level − Remote Radiator −
Spec A, B, 23 Thermostat, Engine Coolant − Spec A−D, 13
Sender, Low Coolant Level − Remote Radiator − Transformer, Current, 81
Spec C, 25 Transformer, Current − Differential, 83
Sender, Low Coolant Level − Sets Without Re-
Trip, Shunt − Circuit Breaker, 85 , 87 , 89
mote Radiator, 53
Tube Assembly, Engine Coolant Heater, 17
Shaft, Fan, 49
Tube, Engine Coolant Heater − Spec A−D, 13
Shaft, Fan − 40 C − Spec B−C; 50 C − Begin
Spec D, 47 Tube, Engine Coolant Heater, 17
Shaft, Fan Drive − Radiator − Spec A, 33 Tube, Radiator − Lower − Spec A, 35
Shim, Generator Mounting, 54 Tube, Radiator − Upper and Lower − Spec A, 29
Shroud, Fan − Radiator − Spec A, 33 Tube, Water − Heat Exchanger, 21
Sight Glass − Radiator, 37 , 38 , 40 Tube, Water Inlet and Outlet − Remote Radiator −
Begin Spec D, 27
Sight Glass, Radiator, 39
Tube, Water Inlet and Outlet − Remote Radiator −
Skid, Generator Set, 54
Spec A, B, 23
Skid, Heat Exchanger, 21
Tube, Water Inlet and Outlet − Remote Radiator −
Skid, Radiator − Spec A, 33 Spec C, 25
Slab, Jacket Water − 50 C Begin Spec D, 47
Slab, Jacket Water− 40 C − Begin Spec D, 49 V
Slab, LTA − 40 C − Begin Spec D, 49
Valve, Ball − Engine Heater, 17
Slab, LTA − 50 C − Begin Spec D, 47
Valve, Check − Heat Exchanger, 21
Socket, Relay, 73
Valve, Check − JW Vent Line, 43 , 47 , 49
Spacer, Engine Mounting, 54
Valve, Check − Radiator Vent Line − Radiator −
Spacer, Generator Mounting, 54 Spec A, 29
Strap, Ground − Circuit Breaker Box, 74 Valve, Shutoff − Oil Drain, 7
Strap, Ground − Control Housing to Generator Valve, Shutoff − Radiator − Spec A, 35
and Generator Control to Generator − Frame
7 Generators, 59 Valve, Shutoff − Remote Radiator − Begin Spec
D, 27
Strap, Ground − Engine to Skid, 7
Valve, Shutoff − Remote Radiator − Spec A, B, 23
Strap, Tank − Jacket Water, 36 , 40
Strap, Tank − LTA, 37 , 38 Valve, Shutoff − Remote Radiator − Spec C, 25
Strap, Tank − Radiator, 39 Valve, Solenoid − Heat Exchanger, 21
Strip, Sealing − Radiator Tank, 39 Vent Line, Jacket Water − 40 C − Spec B−C; 50 C
Switch, Trip Alarm or Auxiliary Contact − Circuit − Begin Spec D, 47
Breaker, 85 , 87 , 89
W
Wrapper, Fan Shroud − Radiator − Spec A, 33
Some of the following abbreviations may be used throughout this Parts Catalog:
AC Alternating Current mm Millimeter
Amp Ampere MOH Mobile Off Highway
A/R As Required NFS Not For Sale
AVR Automatic Voltage Regulator NPT National Pipe Thread
AWG American Wire Gauge OD Outside Diameter
DC Direct Current oz. Ounce
Deg Degree PC Printed Circuit
EFC Electronic Fuel Control Ph Phase
EIT External/Internal Tooth PMG Permanent Magnet Generator
EPROM Erasable Programmable Read PT/CT Potential Transformer/Current
Only Memory Transformer
ET External Tooth RFI Radio Frequency Interference
GFI Ground Fault Interrupter RT Right
ID Inside Diameter Spec Specification
IEC International Electrotechnical Thk Thick
Commission UL Underwriters Laboratories Inc.
IT Internal Tooth UNC Union National Coarse
kW Kilowatt UNF Union National Fine
LPG Liquid Petroleum Gas VAC Volts Alternating Current
LT Left VDC Volts Direct Current
M(meter number) Meter W/(ET, IT, EIT) With
15
16
10
10
17
7
8
6 7
14
6
10 11
5
13 11
9 12
4
12
3 18
2
1
REF PART QTY PART REF PART QTY PART
NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
13 14
22
12
1
4
5
3
11 11
7
10
6
8 9
2
6
9
17
21
20
19
16
18
16
25
11
3
11
26 4
11
11
2 13
11 17
2 9
11 10
14
15
11 11
1
1 12
22
24
18
23
5
6
20
21
37 36 20
28 20
28
12 28
42
12 43 42
30 44 43
2
44
33 10
8
23 24
11 18
16
18 11
22
8 23 21
17
8
5 21
34 6
22
8 24
13
29 11
8 11
11
11 7
8
7 1 31
6
14
8
11
4
25 1 32
3 40 11
35
12
19 8 12
15 40
38
9
26
12 41
28 14
39
12
27 28
39
7 12
11
8
13
16
10
15
14 21
9
19
6 21
23
24
1 22
4 5 21
4
24
3 20
1
4
4 18
17
39
40
17 22
18 21
11 23 20
16
34
34 29
31
28 33 24 13
2 26 6
27 28
27
28 5
33 25
33 28 33 4
7 3
32 1 2 33
12 2 28
19 28 33 33
8 36 30
14
13
14 13
14
13
38
9 37
10 8
28
35
14
15
30
9 6
5
28
4 2
3
27
26
7 1
25
29
12
29
7
31
24
10
2
3
19 11
14
18 13
15
20
23
17
22
21 16
24
15
24 54
66 46 54
15 14
25
65
49 47 55
48
55 51
25
23 54 25
54
46 50 25
45 54 55
54 46 14 23
55
41 45
22 44 41
12 44
20 41
54
40
54 13 36
40 36 22 45
41 41 45
22
40 36 23
19 68
41 11
21 40
42 18 34
40 34
40 16 59
41 34
59 59 59
41 35
63 35 35
26 3 67
37
69 37
27
5
10
6
7
9
43 64 37
60 61
35 62
52
61 3
53 37 62 39
2 4
58
5
8 38
29 57
39
56 17
31
28 38
32
32
33 30 70
31
35
27
38 41 39
8
40
10 36
34
37
23 11
15
25 6
20
24 18 3
4
13
21
26 2
19
7
22
6 5 6
6
21
33
28 1 9
29
30 14 16
31
32 5
12
14
17
1 130−5069−02 1 Guard, Damper (Left Side) 27 503−2129−05 1 Line, Vent − Flexible − With
2 130−5071−02 1 Guard, Damper (Right Side) One Male Pipe Swivel and
3 130−5145−02 1 Bracket, Guard One Female Pipe Swivel With
4 130−5070−02 1 Cover, Damper O−Ring Face Seal (1/4” ID x
5 821−6003−03 5 Screw, Self−Locking − Hex 94−1/2”) Right Side
Washer Head (M8 x 25mm) 28 502−1326 1 Adapter, Pipe (M33 x 3/4”)
6 821−6003−02 19 Screw, Self−Locking − Hex 29 505−0051 1 Elbow, Pipe − Street − 90 Deg
Washer Head (M8 x 20mm) (3/4”)
7 502−1318 1 Adapter, Pipe − Brass (M14 x 30 505−0057 1 Nipple, Pipe (3/4” x 1−3/8”)
1/4” Pipe) 31 504−0171 1 Valve, Shutoff (3/4”)
8 503−2129−04 1 Line, Vent − Flexible − With 32 505−0324 1 Nipple, Pipe − Half (3/4”)
Two Male Pipe Swivel Fittings 33 370−4081 8 Spacer (1/2” x 1/2”) Used With
(1/4” ID x 94−1/2”) Left Side Crankshaft Pulley Mounting
9 130−4517 1 Tube, Water Inlet (26” Long) Bolts
10 130−3687 3 Tube, Water Outlet 34 193−0486 1 Sender, Low Coolant Level
11 130−5081−02 1 Tube, Water Inlet (5” Long) 35 338−3832 1 Harness, Wiring − Low Coolant
12 503−1726 1 Hose (5” ID x 6”) Level Sender (4 Wire, 169”)
13 503−1728 1 Hose (3” ID x 5−1/2”) (Includes Parts Marked *)
14 503−1872−09 2 Clamp, Hose (5” ID) 36 323−1765 1 * Connector, Housing − 4 Place
15 503−1872−05 2 Clamp, Hose (3” ID) (Station 20)
16 155−3290 1 Clamp, Tube (5” ID) 37 323−1708 4 * Seal, Cable (Used With Station
17 130−5168−02 1 Bracket, Tube 20)
18 155−3289 1 Clamp, Tube (3” ID) 38 323−1549 1 * Connector, Receptacle − 4
19 130−5082−02 1 Bracket, Mounting Place (Inline G)
20 870−2065−03 2 Nut, Hex (M8) 39 323−1547 1 * Wedge, Receptacle (Used With
21 304936400 6 Gasket Inline G)
22 130−5084−02 3 Tube, Water Outlet 40 323−1491 4 * Pin, Contact (Used With Inline
23 800−3017−41 9 Screw, Cap − Hex Head (M10 x G)
45mm) 41 323−1709 4 * Socket, Contact (Used With
24 526−0399−62 9 Washer, Flat (M10) Station 20)
25 850−0114−55 9 Washer, Lock − Spring (M10)
26 862−0026−56 9 Nut, Hex (M10)
* − Parts Included In 338−3832 Wiring Harness
17
23 21
20
22
18
19
9 3 16
6
4
28
8
6 15
26 27
28
30
43
45
2
44
6 6
46
5
41 35
24 31
25
38 40
7
42
33 1 26 28
37
29
41 39
34
36
10 33
11 34
12 5
13
14
1 130−5279−02 1 Guard, Damper (Left Side) 23 323−1709 4 * Socket, Contact (Used With
2 130−5280−02 1 Guard, Damper (Right Side) Station 20)
3 130−5281−02 1 Bracket, Guard 24 309−0635−02 1 Valve, Check
4 130−5282−02 1 Cover, Damper 25 505−0153 1 Coupling, Reducer (3/8 x 1/4)
5 Screw, Hex Head (M8 x 1.25 x 26 130−5390−02 2 Plate, Cover
25) 27 130−5393−02 1 Plate, Cover (Top)
821−6003−03 3 Without Flanges 28 821−6003−01 13 Screw, Hex Head (M8 x 1.25 x
821−6003−03 5 With Flanges 16)
821−6003−03 5 With Heat Exchanger 29 130−4517 1 Tube, Water Inlet
6 821−6003−02 18 Screw, Hex Head (M8 x 1.25 x 30 130−3687 3 Tube, Water Outlet
20) 31 130−5081−02 1 Tube, Water Inlet
7 502−1318 1 Adapter, Pipe (M14 x 1/4) 32 503−1726 1 Hose, Radiator (5.00 x 6.00)
8 503−2129−05 1 Line, Radiator Vent 33 503−1728 1 Hose, Radiator (3.00 x 5.50)
9 503−2129−04 1 Line, Radiator Vent 34 503−1872−09 2 Clamp, Hose
10 502−1326 1 Adapter, Pipe (M33 x 3/4) 35 503−1872−05 2 Clamp, Hose
11 505−0051 1 Elbow, Street − 90 (3/4) 36 130−5168−02 1 Bracket, Tube
12 505−0102 1 Nipple, Pipe (3/4 x 1.38) 37 155−3290 1 Clamp, Muffler (5”)
13 504−0171 1 Valve 38 155−3289 1 Clamp, Muffler (3”)
14 505−0324 1 Nipple, Half (3/4) 39 130−5082−02 1 Bracket, Water Inlet
15 370−4081 8 Spacer 40 870−2065−03 2 Nut, Hex − Flange (M8)
16 193−0486 1 Sender, Low Coolant Level 41 304936400 6 Gasket
17 338−3832 1 Harness, Wiring − Low Coolant 42 130−5084−02 3 Tube, Water Outlet
Level Sender (4 Wire, 169”) 43 800−3017−41 9 Screw, Cap − Hex Head (M10 x
(Includes Parts Marked *) 1.5 x 45)
18 323−1765 1 * Connector, Housing − 4 Place 44 526−0399−62 9 Washer, Flat (M10)
(Station 20) 45 850−0114−55 9 Washer, Lock − Split (M10)
19 323−1708 4 * Seal, Cable (Used With Station 46 862−0026−56 9 Nut, Hex (M10 x 1.5)
20)
20 323−1549 1 * Connector, Receptacle − 4
Place (Inline G) * − Parts Included In 338−3832 Wiring Harness
21 323−1547 1 * Wedge, Receptacle (Used With
Inline G)
22 323−1491 4 * Pin, Contact (Used With Inline
G)
17
23 21
20
22
47 18
48
19
44
9 3
16
6
4
46
8
45 6 15
27
40
42
2
41
6 6
43
5
38 32
24 28
25
35 37
7
39
30 1
50
34
26
38 36
31
33
10 30
49 11 31
12 5
13
14
35
23
19
33
32 33
31 18
16 35 23
2 24
39 13
17 4
15 14
1
1
5 24
11
24 24
33
32 8
35
20
31 24 9
34
21
35
35 12
33 7
25 10
35 27 26 6
28
3
24
36
38
37
28 26
27 40
30 25
3
22
29
4
2
73 30 31
20 75 73 9
60 73 51 76
18 17 74 14 47
49 34 52
96 48 73
50 85
85 72
89 73 7 30
89 71
15
21 85 46 35 76
19 88
62 89
82 45
63 86 31
5
6 32
80 81 64
61 87
89
62
1
86 57
84
85
63
73 59
64
58
83
E094
73 30 31
20 75 73 9
60 73 51 76
18 17 74 14 47
49 34 52
96 48 73
50 85
85 72
89 73 7 30
89 71
15
21 85 46 35 76
19 88
62 89
82 45
63 86 31
5
6 32
80 81 64
61 87
89
62
1
86 57
84
85
63
73 59
64
58
83
E094
1
2
3 6 5 9
20
9
5
8 6
7
16 14
17 7
8
15 16
3
17
4
15
16 13
15 12
17
13
16
4
17
3
17
16
11 13
10
12
11
11 10 13
11
11 2
3 1
13 9
5 12 11
13
13 8
12 11 4
13 3
6 13
13 10
12
5 13
13
11
5
7 7 13
10
13
12
8 11 12
13
3 12
13
17
6 13
18
9
4
14
17
16
17 14
15
11
11
11 2
3 1
12
13 4 11
9
13 9
13 8
12 11
13 3
4 13
13 10
12
4 13
13
11
4
4 7 13
10
13
12
8 11 12
13
3 12
13
17 4
7 9 4
14
17
16 13
17 13
15
11
11
REF PART QTY PART REF PART QTY PART
NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
14 1
2
11 10
16
10
3
6
9
5 4 8
11
13 9
11 8
9
12 13
7
4
4
3
5
6
4 4 13
12
6
4
13
12
13 4
11
4
5
4
4
6
4
7 13
11 6
15
5
9
8
9 4
8
9
11
11
REF PART QTY PART REF PART QTY PART
NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
2 1
3 8 7 11
25
11
7
10 8
9
17
9
10
18
3
20
4
18
19 15
18 14
17
15
19
4
20
3
24 20
16
21 19
13 15
23 5 12
14
22 13
13 12 15
13
6
17
REF PART QTY PART REF PART QTY PART
NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
4 17
19 5
6
8
3 22
2
20 9
11
10
2
23 7
11
26
15 14
21 2
7
11
16 10
2
9
11
18
12
13
22
19
13
10
23 13
24
25
20 18
21
13
13 11
10
10
13 9
10 13 13
13 12
13
13 6 8
10 7 14
13
13
5 7
3
1
4 15
13
2
4
16
13
17
13
10
13
1 130−6734 1 Bracket, Pipe Support 14 130−5357 1 Hose, LTA Top Pipe − Elbow
2 503−2691 1 Clamp, U-Bolt (5”) (Radiator)
3 130−5356 1 Hose, J/W − 127 ID (5”) 15 A030S269 1 Pipe, LTA (76.2 OD)
4 503−2692 3 Clip (133−155) 16 130−5358 1 Hose, LTA Top Pipe (Engine)
5 130−6770 1 Pipe, J/W − 127 OD 17 A030S266 1 Pipe, LTA (76.2 OD)
6 503−2454 1 Hose, J/W Reducing 18 A030S239 2 Pipe, J/W Top − Assy
(127−101.6) 19 130−5323 1 Line, J/W Vent
7 503−2661 3 Clip (95−117) 20 309−0635−02 1 Valve, Check
8 A030S268 1 Tube, J/W Radiator (101.6 OD) 21 502−1318 1 Adapter − M14 x 1/4” NPT M/F
9 130−5354 1 Hose, J/W (101.6 ID) 22 130−5323 1 Line, LTA Vent
10 503−2658 7 Tube, Radiator (76.2 ID x 23 130−5355 1 Adapter − 1/4 BSPT x 1/4
122mm) BSPP M/M
11 503−2271 1 Hose, LTA Bottom Pipe 24 130−5414 1 Socket, Hex (1/4”)
12 A030S262 1 Pipe, LTA (76.2 OD) 25 130−5415 1 Adapter − 11/16” ORFS − 1/4”
13 503−2641 20 Clip (70−92) BSP F/M
4
10
5
10
1
2
3
10
7 1
8 6
9
10
32
33 34
40
31 41
5 39
9
6 12 4
9 9 43 2
38
31 43
46 30 1
47
6
12 9 32
12
6 37
15 63
16
17
6
9 13 14 26
9
9 6
23 6
9 29
22 24
25
27 20
28 64
6
19
18 68
58 67
9 6
45 7
24 9 9 49 35
59
60 22 36
65
8
21 3
8 10
42
50 11
66
31 51
52 62
61 21 11
5 33
34 35
41
32 42
6 40
10
7 13 4
10 10 2
39
74
44 32
74 31 1
13 10 33
7 13 38
16
17 59
18
7
10 14
15 27
10
10 7
24 7
10 30
23 25
26
28 21
29
7
48
47 20
19 77
76
10 7
10 10 8 45
25 36
23 37
51 73
9
22 75
3
9 11
43
52 12
32
46
49 22 12
50
4
7
2
9
5
10
11
9
8
10
6 4
1
11
5 2
3
5
5 8 6
3
4
1 193−0486 1 Sender, Low Coolant Level 6 323−1547 1 * Wedge, Receptacle (Used With
2 338−3832 1 Harness, Wiring − Low Coolant Inline G)
Level Sender (4 Wire, 169”) 7 323−1491 4 * Pin, Contact (Used With Inline
(Includes Parts Marked *) G)
3 323−1765 1 * Connector, Housing − 4 Place 8 323−1709 4 * Socket, Contact (Used With
(Station 20) Station 20)
4 323−1708 4 * Seal, Cable (Used With Station
20)
5 323−1549 1 * Connector, Receptacle − 4 * − Parts Included In 338−3832 Wiring Harness
Place (Inline G)
6
7
16 5
18
5 14 3 19
17 7
4 3
13
2
15
9
17
4
5
2 7
15 11
1
5
7
8 11
10
12
15 12
4
2
10 13
18 11
17
9
8
7
16
14
1
3
18 19
14 15 16
5
13
4
17
12
9
10
11
24 23
29 29
23
29 28 27 18 29
29 39
41
34 40
16 17
33
ÂÂ
29
14 17 29
ÂÂ
ÂÂÂÂ
21
12
13 17 29
16
11
29
29
22 27
17 33
29 4
19
31 17 25
2
32 29
29 38 33 28
29 29
26 35
29 13
ÂÂÂ Â
30 20 14
13
29
9 2
10
11
14ÂÂ
36 15
2 14
35
7 3
8 5
29
29
6
17
29 36
37
29
29
1
9 9 5
14
14
4
23
3 14
13
24 11
14
19
10
14
14
11
21
12
20 14
22 14
10
29 17
8 27 30
15
16
18
2 26 18
16
15
28 25 17
3 1
2
4
19
15
32 12
7
13
29 21
28
8 11
33
9
21 2
10
13
33 11
30 5 7
6
21
15
4 31
6
16
20
27
18
26
3
TB5
9
13
31
14 TB4
TB8
2
11
6 5 4
10 7 8
30
12
19
28
15 27
21
20
18
23
29
22
16 17
24
26 25
6
6
5
1 4
2
1
1
2
4 2
1 Harness, Wiring − AC (15 Wire) 43, 48, 49, 54, 55, 65, 66,
(Includes Parts Listed Below) 67, 68) High Voltage (176”)
Standard − Frame 7 2 323−1643−01 1 Plug, Connector (6 Place) (P10)
Generators (Without 3 323−1644−03 1 Housing, Connector (12 Place)
Remote Control) (09, 10 to (P9)
PMG, X, XX, 5, 6, 7, 8, CT21, 4 323−1648 15 Socket, Contract (10 Each Used
22, 23) (82”) In P9, 5 Each Used In P10)
338−3805 1 Low Voltage
338−3873 1 Medium Voltage
Remote Control
Frame 7 Generators (09,
10 to PMG, X, XX, 5, 6, 7,
8, CT21, 22, 23)
338−3834 1 Low Voltage (188”)
338−3874 1 Medium Voltage (188”)
338−3806 1 Frame 8 Generators (P9,
P10 to 8, 9, 10, 13, 14, 42,
2
4
6 3
5
13 7
8
19 20 11
23 21
14
12
10 15
22 17
24 16
27 18
25
26
1 338−3808 1 Harness, Control (Includes 12 307−2817−02 2 Relay (24 Volt) (K14, K15)
Parts Listed Below) 13 357−0030 1 Rectifier, Silicon
2 Plug, Connector (23 Place) 14 332−3125−04 10 Block, Terminal (Single)
323−1605−01 1 Colored Black (Station 23) 15 332−3125−02 1 Block, Terminal (10 Terms)
323−1605−03 1 Colored Grey (Station 8) 16 332−3126−02 3 Spacer
3 323−1493 1 Plug, Connector (3 Place) 17 332−2843−07 2 Jumper, Terminal (4 Pole)
(Station 22) 18 332−2843−05 1 Jumper, Terminal (2 Pole)
4 323−1503 1 Wedge (3 Place) (Used With 19 332−2878 2 Bracket, Terminal End
Station 22) 20 332−3637 1 Rail, Terminal (18.46”)
5 323−1582 1 Plug, Connector (12 Place) 21 323−1835−01 53 Socket, Contact (10 Used With
(Station 21) Station 6, 43 Used With
6 323−1583 1 Wedge (12 Place) (Used With Station 1)
Station 21) 22 323−1847−01 4 Pin, Contact (Used With Station
7 323−1623 2 Plug, Connector (6 Place) 12)
(Station 7, Station Inline D) 23 Grommet
8 323−1624 2 Wedge (6 Place) (Used With 323−1843 1 50 Place
Stations 7 and Inline D) 323−1845 1 25 Place
9 Contact, Connector 24 323−1844 4 Jackscrew
323−1841 1 9 Place (Station RS232) 25 323−1505 1 Plug, Connector (2 Place)
323−1836 1 25 Place (Station 6) (Inline H)
323−1837 1 50 Place (Station 1) 26 323−1501 1 Wedge (2 Place) (Used With
10 323−1614−01 29 Pin, Contact (17 Used With Inline H)
Station 23, 12 Used With 27 323−1491 2 Pin, Contact (Used With Inline
Station 8) H)
11 323−1492 26 Socket, Contact (11 Used With
Station 21, 2 Used Station 22,
6 Used With Station 7, 5
Used With Station Inline D, 2
Used With Station 6)
3
2
6 8
9
11
14
7
23 12
15
22 5 13
16
17 21
10
19 18
20
1
12
14
13 7
9
10
11 6
8
21 3 5
19
17
21
2
17
4 6
19 17
17 7
20 18
16
15
3
12
11
6
10
8
5
4
2
7 1
10
13
8 9
11
4 30 28
10
37
13 19
20 21 29
36 1 9 21
27 3
22
22
5
5
22
43
7
44
2
35
15 16
17 5
38
14
11
4 30 28
10
13 19
20 21 29
1 9
21
27 3
22
5
5
22
44
7
45
2
14
37 15
38 16
39 17 5
35
36
14
15
1 Breaker, Circuit − 3 Pole (UL & 27 800−0049 2 Screw, Cap − Hex Head
IEC) (Includes Mounting (3/8−16 x .88)
Hardware) 28 862−0003 2 Nut, Hex (3/8)
320−2182 1 800 Amp 29 800−0053 2 Screw, Cap − Hex Head
320−2183 1 1200 Amp (3/8−16 x 1.75)
2 405−7709−02 1 Cover, Access 30 815−0261 2 Screw, Hex Washer Head −
3 Cover, Circuit Breaker Thread Forming (1/4−20 x
319−5176−04 1 Left Side Installation .50)
319−5176−05 1 Right Side Installation 31 332−3039 5 Lug, Solderless
4 319−5062−02 1 Box, Circuit Breaker 32 851−0048−01 5 Washer, Belleville (5/16)
5 821−6002−04 33 Screw, Hex Head (M6 x 1 x 20) 33 862−0015 5 Nut, Hex (5/16)
6 319−5087−02 1 Cover, Circuit Breaker 34 800−0028 3 Screw, Cap − Hex Head
7 319−5088−02 1 Cover, Circuit Breaker (5/16−18 x 1”)
8 319−5102−04 1 Stiffener, Cover 35 Lead (Quantity Used As
9 319−5078−05 1 Cup, Switch Required)
10 319−5123−02 1 Bracket, Circuit Breaker 226−4894−03 1 36”
11 337−3623 1 Bus, Bar − Neutral 226−4894−02 1 18”
12 337−3632 1 Bus, Bar − Ground 36 800−2114 24 Screw, Cap − Hex Head (M12 x
13 337−3631 1 Bus, Bar − Neutral 1.75 x 40)
14 337−3629−01 2 Bus, Bar − Breaker 37 860−2010 24 Nut, Hex (M12)
15 337−3629−02 2 Bus, Bar − Breaker 38 850−2012 24 Washer, Lock − Split (M12)
16 337−3628−01 1 Bus, Bar − Breaker 39 526−2140 A/R Washer, Flat (M12)
17 337−3628−02 1 Bus, Bar − Breaker 40 319−5155−02 4 Spacer, Circuit Breaker Box
18 337−3625 1 Bus, Bar − Jumper 41 526−0399−58 9 Washer, Flat (M6) (Used With
19 332−2512 8 Standoff, Insulator Spacer)
20 332−1557 1 Lug 42 337−3736 1 Bus, Bar − Ground
21 851−0048−02 10 Washer, Belleville (3/8) 43 800−0030 2 Screw, Cap − Hex Head
22 821−6003−02 38 Screw, Hex Head (M8 x 1.25 x (5/18−18 x 1-1/4)
20) Accessories, Circuit Breaker:
23 850−0050 8 Washer, Lock − Split (3/8) 44 320−2196−01 2 Switch − Used as a Trip
24 800−0048 8 Screw, Cap − Hex Head Alarm or Auxiliary Contact
(3/8−16 x .75) 45 320−2196−02 1 24 Volt Shunt Trip
25 526−0077 2 Washer, Flat
26 800−0050 6 Screw, Cap − Hex Head
(3/8−16 x 1”)
23 28
1
22
15 31 9
32
33 7 27
34 12
17
2 14 18
3
21 8
1
43
19
20 36
4
44
5
5
4
59
30
60
45
48
49
50 27 5
46 34
47 38 35
29 58
41 57
25 42
53
26
39
55 40
54
56
6 7 8
7 8 9 10 11 12
13
Part No. Page Part No. Page Part No. Page Part No. Page
Part No. Page Part No. Page Part No. Page Part No. Page
Part No. Page Part No. Page Part No. Page Part No. Page
Part No. Page Part No. Page Part No. Page Part No. Page
Part No. Page Part No. Page Part No. Page Part No. Page
Part No. Page Part No. Page Part No. Page Part No. Page
Part No. Page Part No. Page Part No. Page Part No. Page
856−0013, 7 A030S257, 44 , 49
860−0008, 80 A030S258, 44 , 47 , 49
860−2005, 55 , 70 A030S260, 44 , 49
860−2006, 55 A030S262, 43 , 47 , 49
A030S266, 43 , 47 , 49
860−2010, 59 , 85 , 87 , 89
A030S268, 43 , 47 , 49
860−2012, 33 A030S269, 43 , 47 , 49
860−2013, 21 , 29 , 33 A030S270, 47
860−2023−01, 21 , 54 A030S271, 47
860−2024−01, 54 A030S273, 47
860−2033, 47 , 49 A030S281, 47
860−2034, 47 , 49 A030S282, 47
860−2035, 41 , 47 , 49 A030S286, 49
862−0003, 85 , 87 , 89 A030S307, 49
862−0005, 89 A030S308, 49
862−0007, 21 A030S309, 49
862−0008, 21 A030S310, 49
862−0015, 83 , 85 , 87 , 89 A030S311, 49
A030S314, 49
862−0026−56, 23 , 25 , 27
A030S315, 49
862−0026−57, 59 , 61
A030S316, 49
862−0026−58, 21
A030S317, 49
870−0131, 13 , 17 , 19
A030S318, 49
870−0212, 80
A030S319, 49
870−0221, 80
A030S775, 49