Escolar Documentos
Profissional Documentos
Cultura Documentos
1. What is the National Aviation governing body for the State of Qatar?
a) Qatar Civil Aviation Authority (QCAA)
b) European Aviation Safety Agency (EASA)
c) Aviation Safety Agency (ASA)
4. Which is the governing body of the ICAO with a working term of three-years
a) The Assembly
b) The Secretariat
c) The Council
5. Where are the Standards and Recommended Practices (SARPS) issued by the ICAO could be
found?
a) In the annexes of the JAR
b) In the annexes of the convention
c) In the airworthiness notices
11.Personnel holding a valid type rated QCAR Part-66 aircraft maintenance license can be
granted with certifying authorization. This CRS authorization is granted by the,
a) QCAR Part-145 approved organization
b) QCAR Part-147 approved organization
c) QCAA
14.Category C certifying staff authorization permits the holder to issue certificates of release to
service,
a) Following Base Maintenance, & it is valid only for the mentioned maintenance task
b) Following Line Maintenance & it is valid for the aircraft in its entirety
c) Following Base Maintenance & it is valid for the aircraft in its entirety
16.What is the minimum age to apply for the QCAR – 145 authorisation?
a) 18 years
b) 21 years*
c) 25 years
18.What is the practical experience requirement to obtain QCAR Part-66 basic license for a
person without a QCAR Part-147 approved course for categories A or B?
a) 1 year or 2 years; respectively
b) 2 year or 3 years; respectively
c) 3 year or 5 years; respectively
19.The minimum civil aircraft maintenance experience required for category C is three years
provided,
a) He/She was working as category A, B1 or B2 certifying staff for that period
b) He/She was working as category B1 or B2 certifying staff for that period
c) He/she holds an academic degree
21.When applying for QCAR Part-145 authorization the application must be completed and
signed by the,
a) The Accountable Manager only*
b) The Accountable Manager or his nominee only
c) The Accountable Manager or the General Manager of the organization only
22.Which of the following statement is true regarding the quality compliance monitoring staff
under QCAR Part-145?
a) They should remain independent of “production” at all times
b) They can be a part of production but should be independent when performing quality assurance
functions
c) They can remain a part of production in case of shortage of staff
27.In a QCAR Ops1 organisation there can be two quality managers one for maintenance and
one for operations. Which of the following statement is true?
8th Jan 2007
Qatar Airways Technical Training
4
QCAR Part – 66 MODULE -10
a) Accountable manager could hold one of the positions. Other one should be independent
b) Operations quality manager should report to the accountable manage through the maintenance
quality manager
c) Management should ensure that the Quality System is applied uniformly throughout the entire
operation
28.Authorisation for an aircraft to operate under reduced vertical separation rules is granted
by,
a) The QCAA
b) By EASA
c) By the manufacturer
29.What is the interval for weighing the aircraft for mass & balance recording when individual
aircraft mass is used?
a) Every 3 years
b) Every 4 years
c) Every 5 years
35.If a mistake was made in the airworthiness records, how can it be corrected?
a) It cannot be corrected. A new page must be used.
b) With use of correction fluid
c) In a manner so that the initial entry is visible*
36.Identified condition of an aircraft or a component that hazards seriously the flight safety, the
Part-M organisation must report it to the,
a) National Authority*
b) Organization responsible for the type design or supplemental type design
c) All of the above
37.When a Part-145 organisation is contracted by the Part-M organisation to carry out it’s
continued airworthiness tasks, the responsibility for these tasks is with the,
a) Part-M organisation*
b) Part-145 organisation
c) The type certificate holder
38.For an Airworthiness review staff which of the following is not considered as a requirement?
a) Authority to issue Certificate of release to service*
b) An appropriate Part-66 license or an aeronautical degree or equivalent
c) Position within the approved organization with responsibilities
Explain the purpose of QCAR Part-145 and how an applying to be approved under
this part should comply with it.