Escolar Documentos
Profissional Documentos
Cultura Documentos
AGC01039140302EE02
Page 1 of 43
RF Test Report
Report No.: AGC01039140302EE02
TEST NAME : 1999/5/EC R&TTE Directive Art.3.2
PRODUCT
: Mobile radio
DESIGNATION
BRAND NAME : TYT
MODEL NAME : TH‐9800, TH‐9800D, TH‐7800,TH‐7900
CLIENT : TYT ELECTRONICS CO., LTD
DATE OF ISSUE : Apr. 18, 2014
ETSI EN 301 783‐1 V1.2.1 2010‐07
STANDARD(S) :
ETSI EN 301 783‐2 V1.2.1 2010‐07
Attestation of Global Compliance (Shenzhen) Co., Ltd.
CAUTION: This report shall not be reproduced except in full without the written permission
of the test laboratory and shall not be quoted out of context.
Report No. AGC01039140302EE02
Page 2 of 43
APPLICABLE STANDARD
The above equipment was tested by Attestation of Global Compliance Co., Ltd. for compliance with the requirements
set forth in the European Standard ETSI EN 301 783-1/-2 The results of testing in this report apply to the
product/system which was tested only. Other similar equipment will not necessarily produce the same results due to
production tolerance and measurement uncertainties.
Tested by
Checked By
Authorized By
2 EUT DESCRIPTION
28.000MHz- 29.700MHz,50MHz-52MHz,
Operation frequency:
144MHz-146MHz,430MHz-440MHz
Modulation: FM
28-29.7MHz/50-52MHz/144-146MHz:50W
Rated Output Power
430-440MHz:40W
Test mode:
1, transmitting in FM modulation.
Test channel:
Low channel: 28.000MHz
Middle channel: 28.900MHz
High channel: 29.700MHz
Low channel: 50.000MHz
Middle channel: 51.000MHz
High channel: 52.000MHz
Low channel: 144.000MHz
Middle channel: 145.000MHz
High channel: 146.000MHz
Low channel: 430.000MHz
Middle channel: 435.000MHz
High channel: 440.000MHz
Report No. AGC01039140302EE02
Page 6 of 43
3 TEST METHODOLOGY
ETSI EN 301 783-2 2010-07: Electromagnetic compatibility and Radio spectrum Matters (ERM);Land Mobile
Service; Commercially available amateur radio equipment;
Part 2: Harmonized EN covering the essential requirements of article 3.2 of the R&TTE Directive
Notes:
1. All the equipment/cables were placed in the worst-case configuration to maximize the emission during the test.
2. Grounding was established in accordance with the manufacturer’s requirements and conditions for the intended
use.
6. CONFORMANCE REQUIREMENT
Report No. AGC01039140302EE02
Page 7 of 43
6.1 MAXIMUM POWER (PX) (CONDUCTED)
TEST CONFIGURATION
SG
TEST PROCEDURE
1. Please refer to ETSI EN 301 783-1 (V.1.4.1) Sub-clause 4.2 for the test conditions.
2. Please refer to ETSI EN 301 783-1 (V1.2.1) Sub-clause 5.1.2 for the measurement method.
Test result:
12.5 KHz Channel Separation
LIMIT
The rated output power is 50W, -(43+10*log(PEP))= -60 dBc, refer to table 4, the limit for VHF should be:
The rated output power is 40W, -(43+10*log(PEP))= -59 dBc, refer to table 4, the limit for UHF should be:
SG
TEST PROCEDURE
1. Please refer to ETSI EN 301 783-1(V1.2.1), clause 4.2 for test condition.
2. Please refer to ETSI EN 301 783-1 (V1.2.1) Sub-clause 5.2.2.1 for the measurement method.
TEST RESULTS
Note:
1.the EUT have been tested under DC 13.2V AND DC 13.8V, only result the worst case(DC 13.8V) in this part
2.only result the worst channel for each moudulation
Report No. AGC01039140302EE02
Page 11 of 43
TEST RESULT OF12.5KHZ CHANNEL SEPARATION
(28-29.7MHz)
Low channel, 150KHz-30MHz
LIMIT
EN 301 783-1 [1], clause 5.2.3,table 5:
TEST CONFIGURATION
SG
Report No. AGC01039140302EE02
Page 18 of 43
TEST PROCEDURE
1. Please refer to ETSI EN 301 783-1(V1.2.1), clause 4.2 for test condition.
2. Please refer to ETSI EN 301 783-1 (V1.2.1) Sub-clause 5.2.2.1 for the measurement method.
TEST RESULTS
TEST RESULT OF 12.5KHZ CHANNEL SEPARATION
FM Modulation (430MHz-440MHz)
150KHz-30MHz
Report No. AGC01039140302EE02
Page 19 of 43
30MHZ-1GHz
1GHz-12.75GHz
Note: 1.the EUT have been tested under DC 13.2V AND DC 13.8V,
only result the worst case(DC 13.8V) in this part
2.only result the worst case(FM moudulation 430MHz-440MHz) in this part.
Report No. AGC01039140302EE02
Page 20 of 43
LIMIT
EN 301 783-1 [1], clause 5.2.3, table6:
For VHF the rated output power is 50W, -(43+10*log(PEP))= -60 dBc, refer to table 4, the limit for VHF should be:
For UHF the rated output power is 40W, -(43+10*log(PEP))= -59 dBc, refer to table 4, the limit for UHF should be:
SERIAL
Equipment Name Manufacture Model No. Dul.Date
NUMBER
Spectrum Analyzer Agilent E4440A N/A 2014-07-17
Amplifier EM EM30180 0607030 2014-07-17
Horn Antenna EM EM-AH-10180 N/A 2014-07-17
Horn Antenna A.H. Systems Inc. SAS-574 -- 2014-07-17
EMI Test Receiver Rohde & Schwarz ESCI N/A 2014-07-17
Amplifier EM EM30180 N/A 2014-07-17
Bilogical Antenna A.H. Systems Inc. SAS-521-4 N/A 2014-07-17
Loop Antenna A.H. SAS-562B SEL0097 2014-07-17
Isolation Transformer LETEAC LTBK -- 2014-07-17
Report No. AGC01039140302EE02
Page 21 of 43
TEST CONFIGURATION
Below 1GHz
Report No. AGC01039140302EE02
Page 22 of 43
Above 1GHz
TEST PROCEDURE
1. Please refer to ETSI EN 301 783-1(V1.2.1), clause 4.2 for test condition.
2. Please refer to ETSI EN 301 783-1 (V 1.2.1) Sub-clause 5.2.2.2 for the measurement method.
Test result
Note: 1. the fundamental wave has been filtered by trap filter.
2. the EUT have been tested under DC 13.2V AND DC 13.8V,
only result the worst case(DC 13.8V) in this part
3. No emission found below 30MHz, only result the worst case (FM modulation 144-146MHz) in this part.
Report No. AGC01039140302EE02
Page 23 of 43
TEST RESULT OF 12.5 KHZ CHANNEL SEPARATION
LIMIT
EN 301 783-1 [1], clause 5.2.3,table7:
TEST CONFIGURATION
The same with test configuration of section 6.3
TEST PROCEDURE
1. Please refer to ETSI EN 301 783-1(V1.2.1), clause 4.2 for test condition.
2. Please refer to ETSI EN 301 783-1 (V 1.2.1) Sub-clause 5.2.2.2 for the measurement method.
TEST RESULTS
Note: 1. the EUT have been tested under DC 13.2V AND DC 13.8V,
only result the worst case(DC 13.8V) in this part.
2. only result the worst case(FM moudulation 144-146MHz) in the part.
Report No. AGC01039140302EE02
Page 28 of 43
TEST RESULT OF 12.5KHZ CHANNEL SEPARATION
Below 1G
LIMIT
REFER TO 301 783-1 SUBPART 5.3.3
Application of the test signal shall not cause the demodulated receiver output to:
• be reduced to less than 12 dB SINAD for analogue speech equipment; or
• be reduced to less than 80 % of the original data throughput for non-speech equipment; or
• be degraded to a level declared by the manufacturer as appropriate for the type of signal conveyed.
TEST CONFIGURATION
Combination (EUT)
Network
TEST PROCEDURE
1. Please refer to ETSI EN 301 783-1(V1.2.1), clause 4.2 for test condition.
2. Please refer to ETSI EN 301 783-1 (V 1.2.1) Sub-clause 5.3.2.1 for the measurement method.
TEST RESULTS
RESULT OF DC 13.2V POWER
Frequency Operation frequency Channel SINAD
Low 18.75
28MHz-29.7MHz
Middle 17.97
High 16.48
Low 14.07
50MHz-52MHz Middle 14.45
High 14.96
Below 30MHz
Low 14.38
144MHz-146MHz Middle 15.86
High 15.64
Low 14.75
430MHz-440MHz Middle 14.48
High 14.56
Low 17.28
28MHz-29.7MHz
Middle 18.97
High 18.55
Low 14.37
50MHz-52MHz Middle 14.45
High 14.51
30MHz to 1GHz
Low 14.37
144MHz-146MHz Middle 15.86
High 15.36
Low 14.77
430MHz-440MHz Middle 14.44
High 14.76
Low 18.46
28MHz-29.7MHz
Middle 17.86
High 17.26
Low 14.86
50MHz-52MHz Middle 14.45
High 14.78
Below 30MHz
Low 14.63
144MHz-146MHz Middle 15.35
High 15.75
Low 14.56
430MHz-440MHz Middle 14.75
High 13.46
Low 16.75
28MHz-29.7MHz
Middle 16.75
High 16.46
Low 16.85
50MHz-52MHz Middle 14.36
High 13.77
30MHz to 1GHz
Low 14.65
144MHz-146MHz Middle 14.48
High 16.66
Low 14.25
430MHz-440MHz Middle 13.65
High 14.27
Report No. AGC01039140302EE02
Page 35 of 43
APPENDIX 1
PHOTOGRAPHS OF TEST SETUP
RADIATED SPURIOUS EMISSION TEST SETUP
---END OF REPORT---