Escolar Documentos
Profissional Documentos
Cultura Documentos
(c) Both
(a) Pumps
(b) Compressors
(c) Both
(d) None
be sealed.
(a) Static
(b) Dynamic
(c) Any of a & b
(a) Series
(b) Parallel
(a) Impulse
(b) Reaction
(c) Both
8. The tendency of air or gas to move outward from the center of rotating
(a) Centrifugal
(b) Rotary
(c) Centripetal
(d) Linear
at ...... velocity.
(a) Minimum
(b) Maximum
(c) Medium
(d) Zero
10. The diffuser coverts the velocity of the gas to increase gas ..................
(a) Temperature
(b)Pressure
(c) Volume
(d)Energy
11. A centrifugal compressor by doing work on a gas imparts both .......... &
(d)Velocity, temperature
12. At any given RPM, the work done by the compressor on each pound of
(b)Variable
(c) Increasing
(d)Decreasing
required............
(a) Decrease
(b)Increase
(c) Remained constant
(d)None of above
minimum.................
(a) Head
(b)Pressure
(c) Capacity
(d)BHP
(a) increase
(b)decrease
(c) vary
16. Steam turbines are ..............speed driven
(a) Constant
(b)Variable
(b)Nozzle
(c) Diffusers
(d)Diaphragm
18. Restrictive ring shaft seals consist of rings of low friction material
like...........
(b)Mild steel
(c) Rubber
(d)Carbon
19. The rotary speed at which the shaft vibrates at its natural frequency is
its.......speed
(a) Highest
(b)Lowest
(c) Critical
(a) 1 X
(b)2 X
(c) 5 X
(d)10X
(b) Less
22. Packing is chosen on the basis of liquid being pumped and its .............
(a) Pressure
(b) Temperature
(c) Density
(a) 1 inch
(b)1⁄2 inch
24. Which of the following will offer better resistance to unexpected load and
shock conditions?
25. In a full journal bearing or bushing the strength comes from .........
29. For high speed machine what kind of lubrication will be preferred?
(d) Grease
32. Which one will require a lubrication filter build up at start up?
(c) Cage
III)
36. In centrifugal pump ribs are provided on the back of impeller for.....
37. Write down at least one cause for the following problems in a steam
turbine?
38. The speed-sensing drive which indicates turbine speed and makes
correction is called..............
(a) Tachometer
(b)Speed sensor
(c) Governor
(a) Wide
(b)Narrow
(b)Labyrinth seals
(a) Horizontally
(b)Vertically
(c)
(a) Smaller
(b) Larger
(c) Equal
42. In a pump, the close fit between the stationary wear ring and the rotating
wear ring ...........the amount of high pressure liquid going back into the
suction.
(a) Increase
(b) Decrease
43. An unbalance impeller may cause a ..............vibration.
(a) Axial
(b)Radial
(a) Small
(b)Large
47. The balancing drum is attached to the shaft at the ...........end of the
compressor.
(a) Suction
(b)Discharge
(b) Multistage
(c) Both
EXCHANGER?
HEATING
COOLING
B
C
METAL
LIQUID
GASES
_____________.
INCREASING LOAD
DECREASING LOAD
SAME
GREATER
LOWER
C
WATER
METHANE
HYDROGEN
ACIDIC
ALKALINE
NEUTRAL
TRUE
FALSE
Q-8. A SET CONTAINING FINITE NUMBERS OF ELEMENTS IS
CALLED ____________________.
NULL SET
SUPER SET
FINITE SET
INFINITE SET
B
C
-1
Q-10. (x – 6) (x – 4) = ________________. A
2 + 10 x + 24
x
2 – 10 x - 24
2 + 10 x – 24
2 – 10 x + 24
– 30 ARE.
2, 15
2, -15
-3, 10
3, -10
VARIABLE.
TRUE
FALSE
___________________.
A
B
ONE ROOT
NO ROOT
TWO ROOTS
14
49
128
64
TRUE
FALSE
IS CALLED _______________________.
B
C
EQUILATERAL TRIANGLE
RHOMBUS
ISOSCELES TRIANGE
ONE POINT
TWO POINTS
THREE POINTS
FOUR POINTS
CALLED ___________________.
ARC
POINT OF CONTACT
CHORD
SECANT
CORRESPONDING CENTRAL
NONE OF THESE.
A
B
MOLECULAR
MOLAL
EQUIVALENT
TEMPERATURE.
INCREASED
DECREASES
REMAINS AS SUCH
LOG
NEGATIVE LOG
LOGe
IN COMBUSTION
B
C
COMBUSTABLE GAS
STEAM
AIR
D SOURCE OF HEAT
100 ml
150 ml
125 ml
250 ml
N2 + H2 NH3
N2 + 3H2 2NH3
NONE OF ABOVE
B
C
NH4 – CO – NH4
NH3 – CO – NH3
NH2 – CO – NH2
NONE OF ABOVE
NaOH
KOH
BOTH
TRUE
FALSE
______________________.
C
D
TEMPERATURE
SURFACE AREA
VELOCITY OF WIND
ALL ABOVE
DURING TITRATION.
YES
NO
SOLUTE
SOLVENT
EVOLVED
SUPPLIED
NEITHER OF ABOVE
YES
NO
OF A PARTICULAR ELEMENT.
YES
NO
He
Ar
N2
CO2
THE __________________.
C
FREEZING POINT
BOILING POINT
FLASH POINT
MOLECULES IN_______________.
HCI
H2SO4
HNO3
HCN
0 oF
-40 oF
-212 oF
-32 oF