Escolar Documentos
Profissional Documentos
Cultura Documentos
COM
1. Repulsion motor
2. Reluctance motor
3. Hysteresis motor
4. Universal motor
1. 100 uF
2. 00 uF
3. 300 uF
4. 400 uF
5. ANSWER : 300 uF
5.If a particular application needs high speed and high starting torque, then which of the
following motor will be preferred ?
1. Universal motor
2. Shaded pole type motor
3. Capacitor start motor
4. Capacitor start and run motor
7.Which of the following motor will have relatively higher power factor ?
1. 95% to 99%
2. 80% to 90%
3. 50% to 75%
4. 5% to 35%
ANSWER : : 5% to 35%
10.A capacitor-start single phase induction motor is switched on to supply with its capacitor
replaced by an inductor of equivalent reactant value. It will
11.In a capacitor start and run motors the function of the running capacitor in series with the
auxiliary winding is to
12.In a shaded pole single-phase motor, the revolving field is produced by the use of
1. inductor
2. capacitor
3. resistor
4. shading coils
13.Direction of rotation of a split phase motor can be reversed by reversing the connection of
ANSWER : : zero
17.Which of the following motor will give relatively high starting torque ?
1. Split motor
2. Shaded-pole motor
3. Reluctance motor
4. None of these
19.Short-circuited is used in
1. lagging
2. always leading
WWW.ALLEXAMREVIEW.COM
3. unity
4. unity to 0.8 leading
ANSWER : : lagging
ANSWER : : a single turn of heavy copper wire which is short-circuited and carries only induced
current
22.The running winding of a single phase motor on testing with meggar is found to be ground.
Most probable
ANSWER : : at the slot edge where coil enters or comes out of the slot
23.A centrifugal switch is used to dis- connect 'starting winding when motor has
24.In a capacitor start motor, the phase displacement between starting and running winding can
be nearly
1. 10
2. 30
3. 60
4. 90
WWW.ALLEXAMREVIEW.COM
ANSWER : : 90
26.Which of the following motors can be run on AC. as well as D.C. supply ?
1. Universal motor
2. Repulsion motor
3. Synchronous motor
4. Reluctance motor
29.In case of high speed universal motor which of the following needs more attention ?
1. End play
2. Air gap
WWW.ALLEXAMREVIEW.COM
3. Insulation in rotor
4. Balancing of rotor
30.In case of a shaded pole motor the direction of rotation of the motor is
32.In a two value capacitor motor, the capacitor used for running purposes is
1. air capacitor
2. paper spaced oil filled type
3. ceramic type
4. a.c. electrolytic type
1. Repulsion motor
WWW.ALLEXAMREVIEW.COM
35.Which of the following single-phase motors has relatively poor starting torque ?
1. Universal motor
2. Repulsion motor
3. Capacitor motor
4. All single phase motors have zero starting torque
36.The wattage of motor for driving domestic sewing machine will be around
1. 100 to 150 W
2. 40 to 75 W
3. 10 to 30 W
4. 5 to 10 W
1. universal motor
2. D.C. shunt motor
3. single-phase capacitor run motor
4. 3-phase synchronous motor
39.Which of the following motors can be used for unity power factor ?
WWW.ALLEXAMREVIEW.COM
1. hysteresis loss
2. magnetization of rotor
3. eddy current loss
4. electromagnetic induction
1. gear trains
2. V-belts
3. brakes
4. chains
44.The wattage rating for a ceiling fan motor will be in the range
WWW.ALLEXAMREVIEW.COM
1. 200 to 250 W
2. 250 to 500 W
3. 50 to 150 W
4. 10 to 20 W
ANSWER : : 50 to 150 W
45.Which of the following single-phase induction motors is generally used in time phonographs
?
1. Resistance start
2. Capacitor start capacitor run
3. Shaded pole
4. Universal
1. zero slip
2. negative slip
3. positive slip
4. all of the above
47.Which of the following single-phase motors is suitable for timing and control purposes ?
1. Reluctance motor
2. Series motor
3. Repulsion motor
4. Universal motor
48.Which of the following motor will give the highest starting torque ?
1. A.C. only
2. D.C. only
3. either A.C. or D.C.
4. none of the above
1. Electric shavers
2. Refrigerators
3. Signalling and timing devices
4. Lifts and hoists
1. pulsating
2. uniform
3. none of the above
4. nil
ANSWER : : nil
53.As hysteresis motors are free from mechanical and magnetic vibrations therefore these are
considered as suitable for
1. fans
2. blowers
3. sound equipment
4. mixer grinders
WWW.ALLEXAMREVIEW.COM
1. aluminum
2. cast iron
3. chrome steel
4. copper
1. friction
2. varying the resistance
3. tapping the field
4. centrifugal mechanism
1. retentivity
2. resistivity
3. susceptibility
4. none of the above
ANSWER : : retentivity
WWW.ALLEXAMREVIEW.COM
60.The direction of rotation of universal motor can be reversed the by reversing the flow of
current through
1. armature winding
2. field winding
3. either armature winding or field winding
4. none of the above
1. is self-starting
2. is constant speed motor
3. needs no D.C. excitation
4. all of the above
1. Hysteresis motor
2. Schrage motor
3. Universal motor
4. Reluctance motor
1. A.C. motor
2. D.C. shunt motor
3. D.C. series motor
4. none of the above
WWW.ALLEXAMREVIEW.COM
1. shunt motor
2. series motor
3. compound motor
4. separately excited motor
68.Which of the following motors is used in a situation where load increases with speed ?
1. Induction motor
2. Three-phase series motor
3. Schrage motor
4. Hysteresis motor
73.The rotor slots, in an induction motor, are usually not quite parallel to the shaft because it
ANSWER : : helps in reducing the tendency of the rotor teeth to remain under the stator teeth
WWW.ALLEXAMREVIEW.COM
74.If the centrifugal switch does not open at 70 to 80 percent of synchronous speed of motor, it
would result in
75.Which of the following applications always have some load whenever switched on ?
1. Vacuum cleaners
2. Fan motors
3. Pistol drills
4. All of the above
77.After the starting winding of a single phase induction motor is disconnected from supply, it
continues to
1. run only on
2. running winding
3. rotor winding
4. field winding
5. compensating winding
1. can be operated either on D.C. or A.C. supply at approximately the same speed and
output
2. can be marketed internationally
3. runs at dangerously high speed on no-load
4. can be operated either on D.C. or A.C. supply at approximately the same speed and
output
91.To reverse the direction of rotation of a capacitor start motor while it is running we should
1. Disconnect motor from the supply till it stops then reconnect it to supply with reversed
connection of main or auxiliary winding
2. Disconnect motor from supply and immediately reconnect it to supply with reversed
connections of the main winding
3. Reverse the direction of connection of the auxiliary winding and after motor comes to
rest then connect auxiliary winding to the supply
4. Reverse the direction of connections of the auxiliary winding and immediately connect it
to supply
ANSWER : : Disconnect motor from the supply till it stops then reconnect it to supply with
reversed connection of main or auxiliary winding
1. Hysteresis motor
2. Reluctance motor
3. Capacitor-run motor
4. Universal motor
1. centrifugal switch
2. capacitor
3. commutator
4. all of the above
94.Which of the following motors has two separate windings on the motor ?
1. Repulsion motor
2. Repulsion induction motor
3. Repulsion start induction run motor
4. None of the above
95.In a A.C. series motor armature coils are usually connected to commutator
1. through resistance
2. through reactances
3. through capacitors
4. solidly
96.If starting winding of a single-phase induction motor is left in the circuit, it will
1. run faster
2. spark at light loads
3. draw excessive current and overheat
4. run slower
98.Which of the following statements regarding two value capacitor motor is incorrect ?
1. It is a reversing motor
2. It is preferred to permanent-split single-value capacitor motor where frequent reversals
are
3. required
4. It has low starting as well as rushing currents
5. It has high starting torque
ANSWER : : In fractional horse power motors, it has replaced the capacitor motors
102.If the centrifugal switch of a two-value capacitor motor using two capacitors fails to open
then
1. spark excessively
2. have poor efficiency
3. have poor power factor
4. all of the above
105.In case of a reluctance motor, when the load is increased so that it cannot maintain
synchronous speed the motor will
1. become unstable
2. draw excessive armature current and may burn out
3. fall out of synchronism and come to stand still
4. run as induction motor
106.Two-value capacitor motor finds increased application as compressor motor in small home
air conditioners because
1. it is comparatively cheaper
2. it has almost non-destructible capacitor
3. it has low starting as well as running currents at relatively high power factor
4. it is quiet in operation
ANSWER : : it has low starting as well as running currents at relatively high power factor
WWW.ALLEXAMREVIEW.COM
107.If a single phase induction motor runs slower than normal, the most likely defect is
1. worn bearings
2. short-circuit in the winding
3. open-circuit in the winding
4. none of the above
108.Starting winding of a single phase motor of a refrigerator is disconnected from the circuit by
means of a
1. magnetic relay
2. thermal relay
3. centrifugal switch
4. none of the above
1. voltage rating
2. dielectric medium
3. polarity marking
4. definite value
1. gearing
2. belts
3. brakes
4. chains
ANSWER : : gearing
1. armature
2. field
3. rotor
4. stator
WWW.ALLEXAMREVIEW.COM
ANSWER : : stator
113. Which of the following statements regarding single-phase induction motoris correct ?