Escolar Documentos
Profissional Documentos
Cultura Documentos
BTS11 Software
First steps to install or update the BTS11 Software
New installation >>>> If you are the only user of the PC>>Do not change anything in the default
settings!Only press save and next !
Update>>>>>>>>> Make a copy of your database and store it were you can find it.
Proceed as in”New installation ”
***********
Connecting the POB 30
Connect the communication cable to POB and laptop
Connect +and—to one of the coils output and to the SA10
Connect the motor output from the POB to the SA10
Choose in the Setup menu>>Hardware>>Power supplies and choose according your
needs.
Ready!!Al Voltage settings will be done in the BTS11 software
Quick Set up of a new Breaker Configuration
>> Connect the SA10 and transducer to the breaker>>Use the push buttons to test that CB working
>> Go to Service menu >> Control unit>>Transducer>2500 pulse>reset>close CB>Note the Value for later use, and
Close the Control unit.