Escolar Documentos
Profissional Documentos
Cultura Documentos
OPERATION &
MAINTENANCE GUIDE
1. LOGIN to U2000 & LMG
2. Hardware maintenance
3. Alarm monitoring
4. PSTN Subscriber user creation & Checking its Status.
5. ISDN PRI User Creation & Checking its status.
6. Circuit & Loopline test.
NE Window
Login to NE by CLI mode from U2000
Right Click on NE > Tools > Telnet – Opens Operator Terminal
Username : xxxxxx
Password : xxxxxxx
KTK_BLR_INR_LMG1_PVM >enable
KTK_BLR_INR_LMG1_PVM#config
KTK_BLR_INR_LMG1_PVM(config)#
2. Hardware maintenance
Checking the status of FRAMES.
Command: # display board <frame id> //Displays the status of all the boards inserted in the frame.
#display board 0 // Displays the status of Boards of Frame 0
#display board 1 // Displays the status of Boards of Frame 1
NOTE : This command shows the status of Power Boards, Controller Boards & Subscriber Line Boards.
Main Topology > Select Required NE > Right click on NE > NE Explorer or Double Click on NE –
It opens the NE Panel & displays the status of Power Boards, Controller Boards & Subscriber Line
Boards.
NE PANEL Window
Commands :
KTK_BLR_INR_LMG1_PVM(config)#
KTK_BLR_INR_LMG1_PVM(config)#esl user
NE Panel > Right Click on Subscriber Board > Port View or Double click on Subscriber Board – Opens the
list of configured numbers on respective Ports.
Command2: #display port state <frame id/slot id> // Displays the status of all ports in the Slot.
#display port state <frame id/slot id/port id> // Displays the status of respective Port.
NOTE: If SvcState is StartSvc, the user is registered with IMS Core. Dial Tone on Subscriber Port.
If SvcState is RemoBlk, the user is not registered with IMS Core. No Dial Tone.
U2000:
Right Click on Required Port/number > Trace Port Indicator Status > Opens the Trace Port Indicator
Status Window.
Click on any Port – Check the information of Port in the ‘Basic Info’ Tab.
(config)#esl user
(config-esl-user)#display sipprauser <frame id/slot id> //Displays all the configured ports
in the Slot.
(config-esl-user)#display sipprauser <frame id/slot id/Port id> //Displays the configured info
of the particular Port.
NE Panel > Right Click on EDTB Card > Port View or Double click on EDTB Card.