Escolar Documentos
Profissional Documentos
Cultura Documentos
Vehicle Details
Odometer: 175150 Kms Engine Size: 1798
WOF Expiry: 18-May-2019 No. of Cyls: 4
Reg Expiry: 30-Jun-2018 Transmission: automatic
RUC Expiry: Drive Train: front
First Reg NZ: 10-Mar-2011 Fuel: Petrol
Seating: 5
*It is recommended that a Warrant of Fitness be less than 21 days old when a vehicle is sold
Overall Condition
Vehicle Grade:
2 - Vehicle in good condition with normal signs of use for age. Will require maintenance.
Inspector Summary
Tidy little vehicle all round.
Vehicle average condition for age and mileage
Exterior
A visual inspection of the body panels, doors, glazing, tyres and wheels.
Note that not all panel repairs may be identifiable. Previous structural repairs may not be visible.
Comments:
Few marks on front &rear bumper. Right rear wheel arch area.
Minor scrapes and dents on bodywork
Non-standard wheels fitted
Interior
Visual inspection of the vehicle interior including boot, toolkit, seats, seatbelts, interior lights, glovebox and dashboard
Comments:
2011 Nissan Tiida Reg: FWG590
Tidy
2011 Nissan Tiida Reg: FWG590
Engine Bay
Visual and diagnostic testing of battery condition, relative cylinder compression, engine oil, filters where accessible,
transmission fluids where accessible and general engine condition. Evidence is sought of recent servicing, but the
presence or lack of this is not necessarily an indicator of engine condition. Source of fluid leaks may not be available due to
general grime. TK head leak test shows cylinder head coolant seal (head gasket) condition at time of inspection only and
can change with use.
We recommend specialist technical assessment of any issues identified prior to purchase.
Compression
Balance %
Cylinder 1 2 3 4 5 6 7 8
Relative
Compression %
Comments on
Compression
Test
Comments:
Alternator charge OK, Battery condition OK, No evidence of cambelt service, Transmission fluid level & condition OK
2011 Nissan Tiida Reg: FWG590
Engine Diagnostics
Additional service to identify faults codes present at time of inspection and undertake basic engine and transmission
diagnostics. Any issues identified or concerns held should be referred to a specialist technician.
Fault Code Scan not undertaken
Cooling System
Inspection and test of the cooling system. Includes hoses and examination of engine coolant
Comments:
Good
Radiator hose condition OK, Radiator condition OK
Comments:
Comments:
Slight dampness around oil sump area.
Steering
Inspection of steering mechanism to check for excessive play or wear in steering components. May be limited if
components are covered. Note that some wear is acceptable dependent on age and mileage of the vehicle. Older and
high mileage vehicles can experience failure of steering and suspension components without warning.
Comments:
2011 Nissan Tiida Reg: FWG590
Lights
Inspection and functional test of all exterior lights. Compliance with WOF standards checked. Non-standard lights
identified.
Comments:
Good
Road Test
Subjective test of the vehicles handling and performance on the road. In urban test areas speeds may be limited to
50km, and so not all potential issues may be identified. We recommend a full speed road test by purchaser prior to
purchase. Offroad capability is not tested.
Comments:
Braking
Visual and functional test of braking systems, including park brake. Please note that mobile inspections use a "whole
of vehicle mass" braking assessment, whereas in-station inspections use modern roller brake testing of each wheel.
For this reason in-station inspections are superior to mobile inspections.
Service Breaks Right Front Left Front Left Rear Right Rear
Results 2.4 2.8 1.8 2
Park Brakes 1.7 1.6
Service Brakes:
Pass
2011 Nissan Tiida Reg: FWG590
Park Brakes:
Pass
Comments:
Front brake pads are getting low.
Brake performance OK
If you have any further queries as to the content of this report please contact the Vehicle Inspector.
We recommend any issues identified should be rectified or undergo further investigation PRIOR to
purchase of the vehicle.