Escolar Documentos
Profissional Documentos
Cultura Documentos
2. Edges & corners should be stripe coated at least once during the coating
process…? True
4. Coatings applied at excessive (high) DFT may develop internal stresses &
crack…? True
11. Hydrolysis is the process of mixing water with coatings prior to application,
to assist the cure…? False
13. Millscale consists of oxides of iron formed when the steel is hot…? True
14. Aromatic hydrocarbon solvents are all associated with benzene, since they
contain the benzene ring group…? True
17. Pigments are solid particles, and therefore not hazardous…? False
22. Undercutting of a coating film can be reduced by the use of inhibitive pigments
in primers…? True
23. Welds are always better when ground flat before painting occurs…? False
25. Because they are based on water used as a carrier, emulsion coatings don’t
polymerize…? False
26. When corrosion becomes localized, and penetration into the metal occurs,
the effect is called :
a. Local corrosion
b. Cathodic penetration
c. Under cut corrosion
d. Pitting corrosion (answer)
28. Premature coating failures occur when the coating fails to protect the
surface earlier than was expected for the particular in-service
condition…? True
31. The addition of thinners to coatings at the time of application does not affect
their VOC rating…? False
34. When steel that has been blasted turns dark within a few minutes after blasting,
it means…?
a. the steel is probably contaminated with soluble salts
b. relative humidity is high
c. the steel is not totally clean
d. all of the above (answer)
e. none of the above
36. The formation of surface oxide layers through corrosion does not affect
the rate of corrosion…? False
37. Solvent evaporation coatings may become embrittled with age due to…?
a. Using the wrong curing agent
b. Loss of plasticizer of the film (answer)
c. Added solvent
d. All of the above
c. None of the above
40. Phenolic resins are often cured by the application of high temperatures…? True
41. Faying surfaces must be coated to maintain the strength at the joints…? False
45. Oxidation cure coatings react over time with atmospheric oxygen, so there is
no limit to the cure time or the film thickness…? False
47. Coating inspectors may be required to test whether a coating has cured
or not…? True
48. When coatings are applied to zinc surfaces, all corrosion salts must be
removed prior to painting…? True
49. Which of the following is not a common solvent used in the manufacture of
liquid coatings…?
a. MEK c. MIBK
b. MIAK d. MICK (answer)
52. Problems with solvents escaping from a coating film may be seen as…?
a. bubbles or blisters at the surface
b. craters
c. pinholes
d. all of the above (answer)
e. none of the above