Escolar Documentos
Profissional Documentos
Cultura Documentos
1 Introduction
Warranty Card
1
1.2 The Front Panel of the HG655b
2
1.3 The Rear Panel of the HG655b
The rear panel of the HG655b provides the following interfaces and buttons:
z One ADSL interface: DSL
z Two RJ-11 phone interfaces: PHONE2, PHONE1
z Four LAN interfaces: LAN4, LAN3, LAN2, LAN1
z One POWER interface: POWER
3
2 Installation Guide
To connect the cables for installing the HG655b, do as follows:
4
2.1 Connecting the HG655b to the Fixed Network
Step 1 Connect the telephone jack on the wall to the LINE interface on the splitter
with a telephone line. Connect the telephone to the PHONE interface on the
splitter with a telephone line.
####
####
####
LINE PHONE
Step 2 Connect the DSL interface on the HG655b to the MODEM interface on the
splitter with a telephone line.
5
z If you have two VoIP numbers, you can connect two telephones to the PHONE1
and PHONE2 interfaces respectively.
z If you have no VoIP number and use only the PSTN function, then connect the
telephone to the PHONE interface through splitter, refer to 2.1 Connecting the
HG655b to the Fixed Network.
Connect Ethernet interface on the computer to any of the four LAN interfaces on the
rear panel of HG655b with an Ethernet cable.
6
2.4 Supplying Power to the HG655b
Connect the power adapter to the power interface on the back of the HG655b and plug
the power adapter into a wall outlet.
After you power on the HG655b, the DSL indicator blinks (for less than three
minutes), which indicates that the HG655b is being activated. After the DSL
indicator stops blinking, the POWER and DSL indicators turn solid on, which
indicates that the HG655b is working properly.
7
3 Configuring the HG655b
You can access the Internet by use the following two methods:
z Using the Embedded PPP Dial-Up Software of the HG655b to Get Online
z Using the PPP Dial-Up Software of the Computer to Get Online
Please use the parameters provided by your internet service provider (ISP) for
configuration. If the configuration is wrong, you will not be able to access the
Internet.
8
If the embedded dial-up function of the HG655b is enabled, you need to power off
the HG655b when you do not want to access the Internet. Otherwise, the ISP may
calculate the fee for accessing the Internet even if you have powered off your
computer.
9
There are two methods to configure the wireless network connection to enable the
Wi-Fi function of the HG655b:
10
Step 2 Press the WPS button on the side panel. The WPS negotiation function is then
enabled.
Step 3 Enable the WPS negotiation function of the wireless network adapter within 2
minutes.
After you install a wireless network adapter on your PC and enable the WPS
negotiation function, the wireless data card automatically searches for an available
wireless network and connect to the wireless network automatically.
Step 4 Wait for a few seconds, and then you can see the Wi-Fi indicator
turning red permanently on the front panel of the HG655b and the wireless
icon on the corner to the right of the task bar of the PC.
11
Copyright © Huawei Technologies Co., Ltd. 2010. All rights
reserved.
NO WARRANTY
THE CONTENTS OF THIS MANUAL ARE PROVIDED “AS IS”.
EXCEPT AS REQUIRED BY APPLICABLE LAWS, NO WARRANTIES
OF ANY KIND, EITHER EXPRESS OR IMPLIED, INCLUDING BUT
NOT LIMITED TO, THE IMPLIED WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE,
ARE MADE IN RELATION TO THE ACCURACY, RELIABILITY OR
CONTENTS OF THIS MANUAL.
TO THE MAXIMUM EXTENT PERMITTED BY APPLICABLE LAW, IN
NO CASE SHALL HUAWEI TECHNOLOGIES CO., LTD BE LIABLE
FOR ANY SPECIAL, INCIDENTAL, INDIRECT, OR CONSEQUENTIAL
DAMAGES, OR LOST PROFITS, BUSINESS, REVENUE, DATA,
GOODWILL OR ANTICIPATED SAVINGS.
Issue: 01 (2010-02-03)
Part Number: 201172
12