Escolar Documentos
Profissional Documentos
Cultura Documentos
milla, or Roman or Italian mile (commonly used in 15th C nautical reckoning) = 1,480
meters or .8 nautical mile (1 nautical mile = 1,852 meters) or slightly less than a
Castillian mile
legua legal, or legal league (land measurement) = 4.19 km or 2.59 miles
legua común, or common league (land measurement) = 5.572 km or 3.46 miles
Spanish Volume:
fanega = about 1 ½ bushels
Spanish Weight:
arroba = 14.69 kg or about 32 lbs
quintal= Bankston gives a quintal as 101.467 English pounds of 46.025 kg (de Palacio
1981: 200). Barkham (1981:26-27) gives a quintal as approximately 150 lbs. Doursther
reckons the Bilbao quintal to be 48.93 kb (1965: 458); Kisch (1977: 238) reckons the
Castilian quintal as 4 arrobas, or 46.088 kg; and Ross, using archaeological data from
Red Bay, calculated the quintal to be 107.3 lb or 48.69 kg (Ross 1980: 53). This
discussion taken from Light 1990: endnote 5.
1
from Smith 1993: 53-56; Hudson 1997: xvi-xvii; Chardon 1980a, 1980b
Portuguese tonel =
Basque tonel macho = 1.683 cubic meters
10 Viscayan toneles = 12 Sevillian toneladas
Linear Distance:
The French foot, pied, measured 32.48 cm, and was divided into 12 inches—pouces—of
2.71 cm. The inch was further divided into 12 lines—lignes—of .226 cm, and finally, the
line was divided into 12 points—points—measuring .0188 cm each.
The fathom—brasse—was five French feet, or 1.62 meters (as opposed to the English
fathom of 6 English feet).
The ell—aune—was 1.188 meters in length (used for measuring sail canvas)
Weight:
The French pound—livre—weighed 0.489 kilograms. It was divided into 16 ounces—
onces—of 30.563 grams each.
One hundred French pounds made the 48.9 kg quintal—quinteau—which is roughly the
equivalent of the English hundredweight.
2
from Boudriot and Berti 1993: 10.
Two thousand French pounds equaled a ton—tonneau—or 978 kilograms. When
measuring the burthen of ships, there was also the cubic ton, which is about 42 cubic feet
or 1.43 cubic meters.
Liquid Measure:
The English quart is the equivalent of the pinte de Paris, which measured 0.93 liters. The
pinte was divided into two chopines (46.5 centiliters), and the chopine was divided into
two demi-chopines (23 cls), which in turn was divided into four boujarons (5.8 cls) so
that 16 boujarons = 1 pinte. The pot (1.86 liters) was equal to two pintes.
The French Navy needed to use larger measures, such as the barrique, a cask (roughly
equivalent to the English hogshead) which held 242 liters. There is some problem
translating French to English terms, as the English in the late 18th century used different
measures for wine, ale, beer, and dry goods, none of which correspond exactly to French
measures. The closest (about 2.5% smaller) is the English measure used for wine; this
therefore is the English equivalent used by Boudriot’s translator (Boudriot 1986b: 108).
The French Navy also used half-hogsheads or demi-barriques of 121 liters and third-
hogsheads or tierçons of 161 liters (equivalent to 1/3 of 2 hogsheads).
The ship’s water casks were usually larger than single barriques, and were available in
multiples of hogsheads, between two and eight. They were rated as pièces de 2 (482
liters), pièces de 3 (726 liters), pièces de 4 (968 liters), pièces de 5 (1,210 liters), pièces
de 6 (1,452 liters), pièces de 7 (1,694 liters), and pièces de 8 (1,936 liters). The larger
sizes were used exclusively by slave ships, as the French Navy typically didn’t utilize
casks larger than pièces de 4.
The hundredweight (cwt.) equaled 112 pounds or four quarters (50.848 kilograms).
3
From Lavery 1987
The ell equals 45 inches or 1.143 meters (4.5 cm shorter than the French ell).
The bushel is 8 gallons or 35.648 liters of dry goods, and the chaldron is 36 bushels
(1,283.328 liters).
4
From O’Neill 2003: 75
5
From Hoving 1995
1 Swedish foot = 0.296 meter
References
Boudriot, Jean and Hubert Berti
1993 The History of the French Frigate 1650-1850. Jean Boudriot Publications,
Ashley Lodge, Rotherfield, United Kingdom.
Chardon, Roland
1980a The Elusive Spanish League: A Problem of Measurement in Sixteenth-Century
New Spain. Hispanic American Historical Review 60: 294-302.
1980b The Linear League in North America. Annals of the Association of American
Geographers 70: 129-153
Creswell, John
1972 British Admirals of the Eighteenth Century: Tactics in Battle. Archon, New
York.
Hoving, A.J.
1995 Seagoing Ships of The Netherlands. In The Heyday of Sail: The Merchant Sailing
Ship 1650-1830, edited by P. Bosscher, pp. 34-54. Conway's History of the Ship,
R. Gardiner, general editor. Conway Maritime Press, London.
Hudson, Charles
1997 Knights of Spain, Warriors of the Sun: Hernando de Soto and the South’s Ancient
Chieftoms. University of Georgia Press, Athens.
Light, John D.
1990 The 16th Century Anchor from Red Bay, Labrador: Its Method of Manufacture.
International Journal of Nautical Archaeology 19(4):307-316.
Lavery, Brian
1987 The Arming and Fitting of English Ships of War, 1600-1815. Naval Institute
Press, Annapolis, Md.
O'Neill, Timothy P.
2003 Coopering. In Traditional Crafts of Ireland, edited by D. Shaw-Smith, pp. 75-79.
Revised edition. Thames & Hudson, New York.
Smith, Roger C.
1993 Vanguard of Empire: Ships of Exploration in the Age of Columbus. Oxford
University Press, New York.