BS 5950 : Part 1:
Appendix C and D
1990
8.2.7 Plates and flats
For an individual plate, (lat, or other solid rectangular
seetion subject to a moment about its major axis
rueen 2 (22)
‘
ry
cee ners
picasaess
tis the thickness,
1 sasaiven in 4.3.7.0,
B.3 Beams of varying section throughout
their length
When the section of a beam varies along its length between
restraint points, the bending strength, pp, is determined.
using the properties of the section at the point of maximum
‘moment. This value of D aoolies throughout the lenath
between adjacent restraints
Provided that A Is not ess than 0.2, the value of 1 to be
Used in the expression for Nv should be determined from:
1.5 ~ 0.5A4) but 21.0,
where
2, is tho ratio of the flange area at the point of
minimum moment to that at the point of maximum
‘moment between adjacent restraint points;
‘Ay teters either to the ratio ot total area ot both
flanges or to the area of the compression flange only,
whichever gives the smaller value of F.
For non-uniform sections, 9 ~ 1.0 (see 4.3)
Appendix C. Compression strength:
Perry strut formula
CA Basis
tive strength, p_, may be obtained from:
PePy
Dey)?
py + (n+ Vac
where p= Ort int NAc
Me z
where
Pe is the Euler strength (1? E/N’);
», isthe design strength:
11 isthe Perry factor
“The above formula for pg isthe smaller root of:
be PdMey Pe) ~ WP.
C2 Perry factor
The Perry factor, n, for flexural buckling under load should
‘be obtained from:
= 0.001210 ~ Ag) but not less than zero
where
4 Is the Robertson constant. which has the following
values:
2.0 tor table 27(a)
3.5 for table 27(b)
5.6 Fer table 23/6)
8.0 for table 271d)
A. ie the slendarnass (sme 4.7.31;
“which should be taken as:
Aa ete limiting sander
o2 (EE)
Dy
C3 Strutaction
The moment due ¢o strut action fhas a maximum vaiue
Mrnax Midway between points of inflexion of the buckled
shape (the points betwnan which the affective langth is
measured) aiven by:
nfs
tea
where
Is the compressive stress due to axial load;
5 is the plastic modulus
‘The moment at any other point can be obtained by
assuming a sinusoidal variation, ie. the moment due to
stiut ovtive at a puint, istannve Ly front @ point of
inflaxion, ie given by:
vm (2
Appendix D. Effective lengths of struts
in simple construction
D1 Stanchions for single storey
buildings (see 4,7.2|c))
D.1.1 Typical cases
Figures 17 to 21 illustrate how the effective lengthe of
typical stanchions in single storey buildings may be
determined provided the following conditions apply.
(a) tn the plane of the diagram the stanchions act as
cantilevers tied together by the roof trusses, but in this
plane the tops of the stanchions are not otherwise held
in position or restrained in direction.