Escolar Documentos
Profissional Documentos
Cultura Documentos
for
Diagnostic Ultrasound System
Model SSD-5000
A Platform for Pure Harmonic Detection
2
B-mode Spectral Doppler:
Imaging Gray Scale: 256 levels
Display: Power spectrum
Scanning area:
Doppler methods:
100% to 25%, continuously changeable
PW (Pulsed Wave)
Image Zoom
HPRF (High Pulse Repetition Frequency) PW
Write zoom (magnification of real-time image):
CW (Continuous Wave)
Max. 6 times
(Available methods are probe dependent.)
Read zoom (magnification of frozen image):
Real-time Doppler Auto Trace: Possible (option)
Up to 2 times
Reference frequency:
Depth range selections:
PW: 2.14, 2.5, 3, 3.75, 5, 6, and 7.5 MHz
2 to 24 cm*, changeable by minimum 1 cm
CW: 2.14 and 3 MHz
step (* Probe dependent)
Pulse repetition frequency on PW Doppler:
Image frequency select: 4 selections
PW: 0.5 to 20 kHz
Resolution, Standard 1 & 2, Penetration
Max. velocity range:
Scanning line density:
PW/HPRF PW: +5.6 or –5.6 m/sec *
3 selections on linear, convex sector and,
CW: +15.92 or –15.92 m/sec *
phased array sector probes
* 2.14 MHz reference freq., 0 degree, with
Gain: 30 to 90 dB, continuously variable *
base line shift)
* Possible to change also after freezing.
Base line shift: Available up to double velocity
STC (sensitivity time control) — gain versus depth
Steerable CW Doppler: Possible on phased array
curve control: 8 slide controls
sector probes
Angle gain (Lateral gain control)* — gain versus
Steered linear scanning: Possible on selected linear
angle curve control: 8 slide controls
probes
* Available on phased array sector image
Max. ±30 degrees *, 1 or 5 degrees step
Contrast: 16 steps
changeable
AGC—Suppression of brightness saturation:
* Probe dependent
16 steps
Spectrum inversion: Possible
Relief: 4 selections (Off + 3 levels)
Angle correction:
Frame correlation: Continuously variable
Available up to 80 degrees presetable
Horizontal smoothing: 3 selections (Off + 2 levels)
Sample volume size for PW Doppler:
Post Processing
0.5 - 10 mm, changeable in 0.5 mm step
Echo enhance curve: 3 kinds
Wall motion filter:
Rejection: 64 steps
Manual:
View gamma: 5 kinds
50, 100, 200, 400, 800 or 1600 Hz,
Image orientation
PW and CW independently selectable
Longitudinal and lateral inversion
Auto: varies in 12 steps for a velocity range
90 degrees rotation
10 Hz – 1500 Hz
M-mode: Doppler gain: up to 50 dB, 1 dB step changeable*
Moving speed: 1, 1.5, 2, 3, 4, 6, or 8 s/screen * Possible to change also after freezing.
Gain: B-gain ±30 dB, continuously variable * Contrast: 16 steps, selectable
* Possible to change also after freezing. Black/white inversion: Possible
Contrast: 16 steps Audio output: 2 channels stereo
AGC—Suppression of brightness saturation:
16 steps
Relief: 4 selections (Off + 3 levels)
Smoothing processing: On/off selection
Window function—zoom in on the region of interest
Free Angular M-mode*—M-mode cursor can be
freely set on real-time B-mode image (* Option)
3
Color Flow Imaging Volume Mode*
Represented parameters: Scanning method:
Color Doppler mode: Mean Doppler frequency shift Electronic convex sector & mechanical sector
PowerFlow mode: Total power Image processing
Color area size: Variable from 100% to 5% Pre-processing: Gain, Opacity, Contrast, Gamma
Steered linear scanning: Possible Post-processing: Brightness
Max. ±30 degrees *, 1 or 5 degrees step Image magnification (possible on frozen images):
changeable From 0.5 to 2 times in 0.25 times increment
4
DMS (Data Management Subsystem):
Built-in digital interface option: DMS-5500B
<DICOM network communication>
Conformity to DICOM standard:
<Memory>
Service class user of storage, print , and basic work
● Cine Memory
list management. (For details, please refer to the
Display format: DICOM Conformance Statement issued by Aloka.)
Single (Full screen), Dual (2-split screen) and
Storage: Directly transmits image with patient
Quadruple (4-split screen) display
information to a DICOM file server
Loop image playback: Print: Directly printout images with DICOM
Possible independently on each split screen
compatible printer
Playback speed changeable
Work list management: Retrieval of patient and
Play-through function―simultaneous display of live reservation information from hospital information
image and cine memory image
system (HIS)
ECG synchronized image acquisition: possible NOTE: The HIS needs to be compatible with DICOM
Cine Memory capacity: standard supplement 10. The HIS network and the
NTSC
DICOM network need to be linked.
Max. 256 images (B/W) or 128 images (color)
Router setting
PAL
Max. 224 images (B/W) or 112 images (color)
<Image processing>
● Non-volatile Memory
●3-D image processing
Hard disk capacity: Volume Mode―photo-realistic display suitable for
Standard: 100 images or more
imaging fetus
Option: Up to 999 images
Spatial Echo―pseudo 3 dimensional display of
Film Box function―thumbnail display of stored gray-scale image
images and print format editing
Spatial Flow―pseudo 3 dimensional display of
Print Queue function―printout of stored images blood flow image
directly with DICOM compatible printer
Spatial Color―pseudo 3 dimensional display of
gray-scale and blood flow images
<Digital image transmission>
3D Slicing― display of planes viewed from the side
Data compression: Lossless compression and the bottom
Image degradation: 0%
●Kinetic Imaging
Output medium: Displays the movement of the endocardial wall with
MO disk (128 Mbyte/230 Mbyte/540 Mbyte)
color gradation with time
Ether net (Network interface: 10 BASE/T or 100
BASE/TX, automatically switched.)
<Stress Echo Package>
Max. data transfer rate: 10 Mbps or 100 Mbps,
Stress scoring*3
according to the network interface)
Quad-screen display
Output file format: BitMap and TIFF Exercise stress protocols:
Data attendant to the image (Automatically 2 phases (pre-exercise/post-exercise)
transferred from ultrasound main unit):
4 phases (pre-exercise/peak exercise/post-
Patient information
exercise/recovery)
Study information
Pharmacological stress protocols:
Display mode
BLPR (Baseline/low dose/ peak dose/ recovery)
Scale factor
BLMP (Baseline/low dose/ mid dose/ peak dose)
Baseline position
User's protocol: The user can make a protocol in
Look-up Table for color
which 8 stages/phases can be set at maximum.
5
Measurement and Analysis: M mode
Mitral valve
● Basic measurements
Aortic valve
On B-mode image
Tricuspid valve
Distance
pulmonary valve
Area and Circumference by ellipse/by trace
Doppler mode
Angle
LV in-flow study
Volume
LV ejection-flow study 1, 2
Histogram
RV in-flow study
PSA density
RV ejection-flow study 1, 2
Hip joint angle
SV/CO
On M-mode image
Flow volume
Velocity
● Peripheral vessels analysis
Time interval
CCA (common carotid artery)
Heart rate
ICA (internal carotid artery)
On spectral Doppler
ECA (external carotid artery)
Velocity
Vertebral artery
Acceleration
% Stenosis area
Average flow velocity
% Stenosis distance
Time interval
S/D ratio
Resistance index
● Report Functions
Pulsatility index
Obstetrical report
Pressure gradient
Cardiac report
Pressure half time
PV report
Heart rate
● Post measurement on VCR playback image:
Doppler auto trace: Possible on frozen image as
Available with auto and manual calibration.
standard. Possible on real-time image with
optional kit.
Data Communication Function (ALK-3)*
It is possible to transmit patient data and OB/GYN
Others
Stenotic rate, ratio measurement data obtained by Aloka diagnostic
ultrasound system to a personal computer.
● Cardiac analysis * Optional Isolation Unit model SIU-5500-1 is
Left ventricle analysis: necessary. Please prepare personal computer,
M mode appropriate software, and connection cable at your
Pombo, Pombo (wall) side. As for necessary conditions of such items,
Teichholz, Teichholz (wall) please contact your local distributor or Aloka office.
Gibson, Gibson (wall)
B mode Direct Printout *
Pombo, Pombo (wall)
It is possible to printout report of OB/GYN and
Teichholz, Teichholz (wall)
urological measurement directly to an external
Gibson, Gibson (wall)
printer.
Single plane ellipsoid
* Optional Isolation Unit model SIU-5500-1 is
Bi-plane ellipsoid
necessary. Please prepare printer and connection
Bullet
Modified Simpson cable at your side.
6
Viewing Monitor
Acoustic Power ・ 15-inch diagonal
・ 0 to 100%, changeable Flicker-free non-interlaced scanning (option)
・ Tilt and swivel are possible.
Preset Function
・ 15 separate programs for specific clinical
applications and/or users Safety Regulation
・ User programmable and/or factory default settings ・ Complies with IEC 60601-1 Class Ⅰ, Type BF
・ Preset contents are storable in a floppy disk by
Environmental Requirements
using PC In Operation
・ Temperature: +10 to +40 degrees C
Characters and graphic displays
・ Relative Humidity: 30 to 85%
Character input area: (non condensing)
ID, name, age, sex, retained text ・ Atmospheric pressure: 700 to 1060 hPa
Automatic Annotation Labeling: In Storage
・ Temperature: -10 to +50 degrees C
Up to 120 words registerable to each application
・ Relative Humidity: 10 to 90%
Body mark: Default setting: 53 kinds (non condensing)
User edition: 24 kinds ・ Atmospheric pressure: 700 to 1060 hPa
7
8
9
10
Color
CQ (Cardiac Quantification), A-SMA (Automated Segmental
Standard components Motion
Main unit
and Analysis)
with
optionalVideo15-inch
items &depend
KI
Cassettecolor(Kinetic
viewing
on
Recorder the printer
Imaging):
monitor
country.
Physiological signal display
*5 Flow Optional
unit
SVBK-110 (ECG,
Profile and
B/W items
2PCG,
enables
* TDI
printer
NS:
for
and
remotethe SONY
Pulse
measurements
(available
control
Non-sterilized,
VCR*
wave): (B
outside
Color
of PEU-5500
5
TDI (SONY®):
print
the
Probe
S: Profile,
Japan)
pack:
VCR from
cover*
Sterilized :
Volume Mode probe: ASU-1002
2
We care, Ultrasound@Aloka