Escolar Documentos
Profissional Documentos
Cultura Documentos
STANDARD
0000-E-004
FOR
FOR
REV.
BECHTEL CHILE LTDA. STANDARD No. 0
0000-E-004
\\IW\job24017\Drawings\Electrical\OSF\pu
07/09/18
Standard for Electrical Numbering and Identification System
0000-E-004 Rev. 0
TABLE OF CONTENTS
References:
1) Project Procedure.
2) 0000-E-006, Setroute Notes & Details.
\\IW\job24017\Drawings\Electrical\OSF\pu
09/08/99
Page 2 of 12
Standard for Electrical Numbering and Identification System
0000-E-004 Rev. 0
1.1 Purpose
This electrical numbering system suplements and clarifies further the project
numbering systems as specifically applicable to the electrical equipment, devices
and engineering documents. It utilizes the facility codes and equipment
designations included in the project engineering procedure.
\\IW\job24017\Drawings\Electrical\OSF\pu
09/08/99
Page 3 of 12
Standard for Electrical Numbering and Identification System
0000-E-004 Rev. 0
Refer to Project Procedure Manual, Section 5, Subject Numbering systems, Exhibit A for
equipment designator
4.1.1 SWITCHGEAR
0220SG221
4.1.2 MOTORS
0210CR001-1A
\\IW\job24017\Drawings\Electrical\OSF\pu
09/08/99
Page 4 of 12
Standard for Electrical Numbering and Identification System
0000-E-004 Rev. 0
Note :
a) Letters A to P are reserved only for Motors (letters “O & I” are not used).
0210CR001-1CO1
\\IW\job24017\Drawings\Electrical\OSF\pu
09/08/99
Page 5 of 12
Standard for Electrical Numbering and Identification System
0000-E-004 Rev. 0
Schematic and block diagram numbering system is described below for numbering other
type of document see project procedure (Reference 1)
EXAMPLE : 0000-E-501-1
0210-E-501-1
E : Electrical Discipline
EXAMPLE 1
\\IW\job24017\Drawings\Electrical\OSF\pu
09/08/99
Page 6 of 12
Standard for Electrical Numbering and Identification System
0000-E-004 Rev. 0
EXAMPLE 2
NOTE: In case of schematic drawing has more than one sheet, add “-1, -2, etc” at the
end of the drawing number described before, as follow:
The service level is assigned to every cable & raceway to insure that the cable is routed
in the proper service level raceways.
\\IW\job24017\Drawings\Electrical\OSF\pu
09/08/99
Page 7 of 12
Standard for Electrical Numbering and Identification System
0000-E-004 Rev. 0
Scheme numbers are derived from the Mechanical equipment number and consist
of nine or more alphanumeric characters as follows :
EXAMPLE :
Scheme N°.: 0210-CR001-1 (Primary Crusher Hydraulic System Skid)
0210-CR001-1
Loop numbers are derived from P & ID and consists of nine or more
alphanumeric characters as follows:
EXAMPLE :
Scheme N°.: 0210-L0123 (Level measurement on P & ID for FAC 0210)
0210-L0123
\\IW\job24017\Drawings\Electrical\OSF\pu
09/08/99
Page 8 of 12
Standard for Electrical Numbering and Identification System
0000-E-004 Rev. 0
Cable numbers consist of the scheme or loop number with service level
and cable sequential number.
EXAMPLE : (SCHEME)
0210CR001-1P01
EXAMPLE : (LOOP)
0210F1013J01
F : Loop function
J : Service Level
01 : (01-99) Cable Sequential Number
\\IW\job24017\Drawings\Electrical\OSF\pu
09/08/99
Page 9 of 12
Standard for Electrical Numbering and Identification System
0000-E-004 Rev. 0
EXAMPLE : 0310CA001
0310CA001
A : Service Level
EXAMPLE : 0310TA001
0310TA001
A : Service Level
\\IW\job24017\Drawings\Electrical\OSF\pu
09/08/99
Page 10 of 12
Standard for Electrical Numbering and Identification System
0000-E-004 Rev. 0
EXAMPLE : 0310PB001
0310PB001
EXAMPLE : 0310MH01
0310MH01
NOTE : Additional details for Raceway and Cable Codes are in the document
0000-E-006 : “ SETROUTE NOTES & DETAILS”. (Reference 2)
\\IW\job24017\Drawings\Electrical\OSF\pu
09/08/99
Page 11 of 12
Standard for Electrical Numbering and Identification System
0000-E-004 Rev. 0
Additionally for MEL internal use, the 220/69kV substation equipment are also
numbered as follows in conformance with the numbering system used for the existing
substation equipment.
TX: Transformer X
Where X: 1, 2, 3, 4, 5, 6, 7
LX: Line X
Where X: 1, 2, 3, 4
SERVICE LEVEL
J: 220kV
B: 69kV
EXAMPLES:
a) 89JT1-1
220 kV disconnect switch for transformer # 1
\\IW\job24017\Drawings\Electrical\OSF\pu
09/08/99
Page 12 of 12