Testing tools for fuel delivery, return and leak amount.
Symbol Part No. Part name
1 795-790-4700 Tester kit 6754-71-5340 Connector 3 6754-71-5350 Washer Commercially 4 Measuring cylinder available H Commercially 5 Stopwatch available Commercially Hose 6 available (Inside diameter: 14 mm) Commercially Hose 7 3) Crank the engine for 30 seconds and available (Inside diameter: 8 mm) measure the delivery with measuring cyl- inder H4. See PAGE 29 for procedure of "Testing fuel Adjust the route of the test hose so discharge, return and leakage" of HB205- that it will not slacken and put its end 1M0 and HB215LC-1M0. in an oil container. Prepare a container of 20 for fuel leakage Do not crank the engine for more than during testing. 30 seconds to protect the starting motor in any case other than this 1. Measuring supply pump delivery measurement. (4D107E-1) If the supply pump delivery is in the 1) Loosen clamp (2) of discharge tube (1) of following standard range, it is normal. the supply pump and disconnect tube (1). At cranking speed Min. 75 cc (125 rpm) At cranking speed Min. 90 cc (150 rpm)
2) Install test hose H6 to the nipple on the
discharge side of the supply pump. Fix the hose with a wire etc. Adjust the route of the test hose so that it will not slacken and put its end 4) After finishing measurement, remove the in an oil container. measuring instruments and return the removed parts. Tube sleeve nut: 35 ± 4 Nm {3.6 ± 0.4 kgm} Clamp mounting bolt: 24 ± 4 Nm {2.5 ± 0.4 kgm}