Você está na página 1de 48

Reservoir Production Processes

Basics of Reservoir Engineering


(Reserves, Reservoir Drive Mechanisms, GOR, Phase
Diagrams, Oil Recovery Factor)

Copyright 2007, , All rights reserved


Hydrocarbon Volumes
(Basic Concepts)

„ OIIP: Oil Initially In Place


„ STOIIP: Stock Tank Oil Initially In Place
„ Reserves
„ Recovery Factor

Copyright 2007, , All rights reserved 2


Oil Initially In Place (OIIP)

Where;
A: Area
h: Thickness
φ: Porosity
Sw: Water Saturation

Copyright 2007, , All rights reserved 3


Stock Tank Oil Initially In Place (STOIIP)

Where:
„ A: area h: formation thickness
„ φ: porosity Sw: water saturation
„ Bo: formation volume factor

Copyright 2007, , All rights reserved 4


What are Reserves?

Oil and gas trapped beneath the earth’s surface that can be
recovered under existing economic conditions and with current
technology.

Copyright 2007, , All rights reserved 5


Recovery Factor

Np
RF =
N
„ where:
– N: stock tank oil originally in place
– Np: cumulative stock tank oil prod.
„ Affected by:
– Reservoir Rock
– Fluid Properties
– Reservoir Continuity, Heterogeneity
– Economic Conditions
– Technology

Copyright 2007, , All rights reserved 6


Reserves Uncertainty

I II III

Range of
Increasing Recovery Estimates
Recovery
True Ultimate
Recovery
Cumulative
Production

Time
Wells Abandonment At
Completed Economic Limit

Copyright 2007, , All rights reserved 7


Global Oil and Gas Fields

Gas
Oil

Copyright 2007, , All rights reserved 8


Where are those Reserves?

Copyright 2007, , All rights reserved 9


Largest Hydrocarbon Basins by Ultimate
Potential

Copyright 2007, , All rights reserved 10


World Fuel Consumption: 1975-2000
Oil
Natural Gas
8,000 Nuclear Energy
Hydroelectricity
7,000 Coal
Million tonnes oil equivalent

6,000

5,000

4,000

3,000

2,000

1,000

1995
1983

1999
1979

1993

1997
1975

1977

1981

1985

1987

1989

1991
Year
Copyright 2007, , All rights reserved 11
Projected World Energy Supplies

Careers in
Oil & Gas Hydroelectric

New Technologies
1993 Will be Important
100
100 BILLION
BARRELS Solar Wind
Geothermal
80
Billion World Energy Demand
Nuclear Electric
Coal
Equivalent

(GBOE) Natural
40 Gas

Fossil Fuels
Decreasing
Crude Oil
20

Tar Sands/Oil Shales

1900 1920 1940 1960 1980 2000 2020 2040 2060 2080 2100

Copyright 2007, , All rights reserved 12


Gas-Oil Ratio (GOR)

„ What is the STOIIP in the following case (in bbls)?


A: 300m x 500m h: 200m φ: 20%
Sw: 25% Bo: 1.35
1m3 = 6.289bbls
„ If ultimate RF of this reservoir is 30% and oil price is $30/bbl,
how much is the total revenue? Assume there is no market
for the gas in this case.

Copyright 2007, , All rights reserved 13


Oil Reservoir Drive Mechanisms

„ Solution-gas drive
„ Gas-cap drive
„ Water drive
„ Combination drive
„ Gravity-drainage drive

Copyright 2007, , All rights reserved 14


Sources of Reservoir Energy

„ Liberation, expansion of solution gas


„ Influx of aquifer water
„ Expansion of reservoir rock and compression of pore volume
„ Expansion of original reservoir fluids
– Free gas
– Interstitial water
– Oil, if present
„ Gravitational forces

Copyright 2007, , All rights reserved 15


Solution Gas Drive in Oil Reservoirs

Copyright 2007, , All rights reserved 16


Solution Gas Drive in Oil Reservoirs

„ No original gas cap or aquifer


„ Main source(s) of reservoir energy
– liberation and expansion of dissolved gas
„ Possible secondary gas cap
– liberated free gas can migrate up-structure
„ Typical production characteristics
– Rapid GOR increase after Pb

Copyright 2007, , All rights reserved 17


Solution Gas Drive in Oil Reservoirs
Formation of Secondary Gas Cap

Copyright 2007, , All rights reserved 18


Solution Gas Drive in Oil Reservoirs
Typical Production Characteristics

Initial reservoir
Reservoir pressure, psig

pressure
Reservoir pressure behavior

Bubblepoint
pressure

0 5 10
15 Oil recovery, % of OOIP

Copyright 2007, , All rights reserved 19


Solution Gas Drive in Oil Reservoirs
Typical Production Characteristics

400
Oil production rate, STB/D

800 400 Production data

Gas/oil ratio, SCF/STB


Pressure, psia

Gas/oil
600 300 ratio 300

400 200 Reservoir 200


pressure

Oil production rate


200 100 100

0 0 0
Time, years

Copyright 2007, , All rights reserved 20


Gas Cap Drive

Oil producing well

Oil Oil
zone Gas cap zone

Cross Section
Copyright 2007, , All rights reserved 21
Gas Cap Drive

„ Free gas phase exists as an original gas cap


„ Pure gas-cap drive reservoir has no aquifer
„ Main source(s) of reservoir energy
– Expansion of gas cap and liberation and expansion of solution
gas in the oil zone
„ Gas cap expands pushing GOC down and maintaining
higher pressure
„ Good sweep
„ Typical production characteristics
– dramatic GOR increase when gas breakthrough
Copyright 2007, , All rights reserved 22
Gas Cap Drive
Typical Production Characteristics
Pressure, psia
Production data
1300
Reservoir pressure
1200
1100

Gas/oil ratio, scf/STB


1000
900 800
Gas/oil ratio
600
Oil production rate,

400
2 200
MSTB/D

0
Oil
1

0
Time, years

Copyright 2007, , All rights reserved 23


Water Drive in Oil Reservoirs

„ Oil zone in communication with acquifer


„ Main source(s) of reservoir energy
– influx of acquifer water - edge-water drive, bottom-water drive
„ Pressure decline relatively slow
„ GOR kept relatively low and stable
„ Water production increases steadily
„ Oil production declines when water breakthrough
„ Reasonable sweep - depends on mobility ratio

Copyright 2007, , All rights reserved 24


Water Drive in Oil Reservoirs
Edge-Water Drive

Oil producing well

Oil Zone

Water Water

Cross Section
Copyright 2007, , All rights reserved 25
Water Drive in Oil Reservoirs
Bottom-Water Drive

Oil producing well

Oil Zone

Water

Cross Section

Copyright 2007, , All rights reserved 26


Water Drive in Oil Reservoirs
Typical Production Characteristics

Production data
Pressure, psia

Gas/oil ratio, MSCF/STB


2300
2200
Reservoir pressure
2100
2000 2
Gas/oil ratio
1900 40

Water cut, %
1
0 30
Oil production rate,

100 Water
20
80 10
MSTB/D

60 0
Oil
40
20
0

Time, years
Copyright 2007, , All rights reserved 27
Water Drive in Oil Reservoirs
Effect of Production Rate on Pressure
Production data - lower oil production rate
Pressure, psia

2000

Gas/oil ratio, MSCF/STB


Reservoir pressure
1900
1800 2
Gas/oil ratio
1700 1

Water Cut, %
0 60
Water
40
Oil production,

20 20
MSTB/D

15 0
Oil
10
5
0
Time, years

Copyright 2007, , All rights reserved 28


Reservoir pressure

Reservoir pressure in this reservoir declines more slowly and


even rises because the aquifer is able to provide enough
pressure support to offset lower fluid withdrawal from this
reservoir. Oil production rate in the figure above is lower than
in the previous example.

Copyright 2007, , All rights reserved 29


Combination Drive in Oil Reservoirs

Gas cap

Oil zone

Water

Cross Section

Copyright 2007, , All rights reserved 30


Combination Drive in Oil Reservoirs

„ Basic drive mechanisms usually occur in combination.


„ A large aquifer and a large gas cap can occur in a reservoir
simultaneously.
„ Oil production pressure drop results in some dissolved gas drive
component in any oil reservoir drive mechanism (even in water-drive
and gas-cap drive).

„ Dominant drive mechanism depends on the “strength" of each of the


source(s) of reservoir energy: size of original gas cap, "strength" of
aquifer (size and permeability), and degree of pressure decline.

Copyright 2007, , All rights reserved 31


Gravity Drainage in Oil Reservoirs

Main energy - gravitational force


Good drainage efficiency and recovery factor

Gas

Gas

Oil

Gas
Oil Point C

Point B
Oil
Point A

Copyright 2007, , All rights reserved 32


Gravity Drainage in Oil Reservoirs

„ Gravity drainage may occur in any type of reservoir.


„ Gravity drainage is particularly important in solution-gas and gas-cap
drive oil reservoirs.

„ Gravitational segregation can improve recovery efficiency substantially


when it has time to act.
„ In solution-gas drive reservoirs, liberated solution gas may segregate
from oil to form a secondary gas cap.
„ In gas-cap drive reservoirs, oil in gas-invaded region drains down to
rejoin oil column, reducing residual oil saturation (and thus improving
recovery efficiency).
„ Recovery efficiency for a gravity-drainage reservoir may approach that
of better water-drive reservoirs.

Copyright 2007, , All rights reserved 33


Pressure Trend
Reservoir pressure trends
100

Water drive
80
Reservoir pressure,
Percent of original

60

Gas-cap drive
40

20
Solution
-gas drive
0 0 20 40 60 80 100
Copyright 2007,
Cumulative oil produced, percent of original oil in place
, All rights reserved 34
GOR Trends

Gas/oil ratio trends


5

Solution-
gas drive
4
Gas/oil ratio, MSCF/STB

Gas-cap drive
3

1
Water drive

0
Cumulative oil produced, percent of original oil in place
Copyright 2007, , All rights reserved 35
Gas Reservoir Drive Mechanisms

„ Volumetric reservoir (gas expansion drive)


„ Water drive

Copyright 2007, , All rights reserved 36


Volumetric Gas Reservoirs

„ Gas reservoir with no acquifer


„ Main source(s) of reservoir energy
– expansion of gas
„ Pressure decline slowly and continuously
„ No water production
„ Flowing life can be increased by reducing surface back-
pressure through installing compression

Copyright 2007, , All rights reserved 37


Water Drive in Gas Reservoirs

„ Gas reservoir with acquifer


„ Main source(s) of reservoir energy
– expansion of gas and water influx
„ Pressure decline slower than volumetric gas reservoir
„ Water production may start early and increases with time
„ Flowing life can be increased by installing continuous or
intermittent water removal equipment

Copyright 2007, , All rights reserved 38


Average Recovery Factors
Oil Reservoirs

Average Oil Recovery


Drive Mechanism Factors,
% of OOIP
Range Average
Solution-gas drive 5 - 30 15
Gas-cap drive 15 - 50 30
Water drive 30 - 60 40
Gravity-drainage 16 - 85 50
drive
Copyright 2007, , All rights reserved 39
Average Recovery Factors
Gas Reservoirs

Average Gas Recovery Factors,


Drive Mechanism % of OGIP
Range Average
Volumetric 70 - 90 80
reservoir
(Gas expansion
drive)
Water drive 35 - 65 50

Copyright 2007, , All rights reserved 40


Properties Favorable for Oil Recovery

„ Solution-gas drive oil reservoirs


– Low oil density
– Low oil viscosity
– High oil bubblepoint pressure
„ Gas-cap drive oil reservoirs
– Favorable oil properties
– Relatively large ratio of gas cap to oil zone
– High reservoir dip angle
– Thick oil column

Copyright 2007, , All rights reserved 41


Properties Favorable for Oil Recovery

Water drive oil reservoirs


„ Large aquifer „ High relative oil permeability
„ Low oil viscosity „ Little reservoir heterogeneity
and stratification
Gravity drainage oil reservoirs
„ High reservoir dip angle „ Large fluid density difference
„ Favorable permeability „ Large segregation area
distribution „ Low withdrawal

Copyright 2007, , All rights reserved 42


Properties Favorable for Gas Recovery

„ Volumetric gas reservoir (gas expansion drive)


– Low abandonment pressure
„ Water-drive gas reservoir
– Large aquifer
– Small degree of reservoir heterogeneity and stratification

Copyright 2007, , All rights reserved 43


Oil Recovery factor

(Solution Gas Drive – API study)

ER = Oil recovery efficiency (recovery factor), [% (for API study)]


φ = Reservoir porosity, fraction
Swi = Interstitial water saturation, fraction
Bob = Formation volume factor of oil at bubblepoint, RB/STB
k = Reservoir permeability, [darcy (for API study);
mob = Oil viscosity at bubblepoint pressure, cp
pb = Bubblepoint pressure of oil, psig
pa = Abandonment reservoir pressure, psig

Copyright 2007, , All rights reserved 44


Oil Recovery factor

(Water Drive – API study)

ER = Oil recovery efficiency (recovery factor), [% (for API study)]


φ = Reservoir porosity, fraction
Swi = Interstitial water saturation, fraction
Bob = Formation volume factor of oil at bubblepoint, RB/STB
k = Reservoir permeability, [darcy (for API study);
mob = Oil viscosity at bubblepoint pressure, cp
mo = Oil viscosity at initial conditions, cp
mw = Water viscosity, cp
pb = Bubblepoint pressure of oil, psig
pa = Abandonment reservoir pressure, psig
Copyright 2007, , All rights reserved 45
Oil Recovery factor

(Water Drive – Guthrie-Greenberger study)

ER = Oil recovery efficiency (recovery factor), [fraction]


k = Reservoir permeability, md
Swi = Interstitial water saturation, fraction
φ = Reservoir porosity, fraction
µo = Oil viscosity, cp
h = Thickness, ft

Copyright 2007, , All rights reserved 46


The Area and the Thickness of the Reservoir

Copyright 2007, , All rights reserved 47


Exercise

Determine the Recovery Factor for one of your fields

Copyright 2007, , All rights reserved 48

Você também pode gostar