2008 Honda Accord V6-3.5L
Vehicle > Engine, Cooling and Exhaust > Engine > Specifications > Mechanical
GENERAL SPECIFICATIONS
cylinder Head
Torque .ncnenne 30 Nem (3.0 kgf-m, 22 Ibfft)After torquing, tighten all eylinder head bolts in two steps (90" per step). If you are using anew cylinder head
bolt, tighten the bolt an extra 90°
NOTE: Remove the cylinder head bolt if you
tightened it beyond the specified angle, and go
back to step 8 of the procedure. Do not loosen it
back to the specified angle.
FIRST STEP
THIRD STEP SECOND STEP
(New bolt) ¥
Measure the diameter of each cylinder head bolt at point A and point B.50 mm (2.0 in.)
om 20%n)
45 mm (1.8 in.)
a
If either diameteris less than 10,6 mm (0.42 in), replace the cylinder head bolt.
Intake Manifold
Tighten the bolts and nuts sequentially in three steps: