Escolar Documentos
Profissional Documentos
Cultura Documentos
MICRO PROJECT-1
SUBMITTED TO:
BRANCH: CSE
GROUP –R1
1
INDEX
TOPIC PAGE NO.
CERTIFICATE 3
ACKNOWLEDGEMENT 4
ABSTRACT 5
OBJECTIVE, INTRODUCTION 6
MULTISIM 7
PROCEDURE 8
RESULT 9-10
CONCLUSION 11
2
CERTIFICATE
All the facts and statements made in this project have been
verified to be true to best of the candidate’s knowledge.
SHIVAM GUPTA
(101753015)
3
ACKNOWLEDGEMENT
4
ABSTRACT
This project includes application of concepts of clamping of
electronic circuits. All the applications are here explained with
the help of MULTISIM software. The application includes
solved problems related to clamping of circuits. In electronics,
A clamper is an electronic circuit that fixes either the positive or
the negative peak excursions of a signal to a defined value by
shifting its DC value.
OBJECTIVE
Q1. Design a clamper circuit using diode, capacitor, resistor etc.
The input to the clamper circuit is a square wave with 10 V and
6 V peak to peak whose frequency is 1 KHz and 10 KHz
respectively. Choose appropriate values of the capacitor and
resistor. Use MultiSim software to design the circuit.
5
INTRODUCTION
CLAMPERS:
A clamper is an electronic circuit that fixes either the positive or
the negative peak excursions of a signal to a defined value by
shifting its DC value.
The clamper does not restrict the peak-to-peak excursion of the
signal, it moves the whole signal up or down so as to place the
peaks at the reference level. A diode clamp (a simple, common
type) consists of a diode, which conducts electric current in only
one direction and prevents the signal exceeding the reference
value; and a capacitor which provides a DC offset from the
stored charge.
The capacitor forms a time constant with the resistor load which
determines the range of frequencies over which the clamper will
be effective.
6
MULTISIM
NI Multisim (formerly MultiSIM) is an electronic schematic
capture and simulation program which is part of a suite of circuit
design programs, along with NI Ultiboard. Multisim is one of
the few circuit design programs to employ the
original Berkeley SPICE based software simulation. Multisim
includes microcontroller simulation (formerly known as
MultiMCU), as well as integrated import and export features to
the Printed Circuit Board layout software in the suite, NI
Ultiboard.
Multisim is widely used in academia and industry for circuits
education, electronic schematic design and SPICE simulation.
7
PROCEDURE
CLAMPER CIRCUIT
Open MultiSim.
Place the function generator by clicking on Stimulate >
Instruments > Function Generator.
Place the oscilloscope by clicking on Stimulate >
Instruments > Oscilloscope.
Place different components by clicking on Place and
selecting components.
8
Connect the wires between different components by
clicking on Place > wire.
Check the output waveform by clicking on oscilloscope.
9
2. FOR BATTERY(3V) AND INPUT(1KHz) :
10
DESIGN ISSUES
CONCLUSION
11