Escolar Documentos
Profissional Documentos
Cultura Documentos
com
sales@pbegrp.com
sales.aus@pbegrp.com
SUPPLIED
• Key to the unit
Inside the Power Station should be:
• Assembly kit containing two glands, mounting
brackets and mounting instructions and battery
connecting cable
• PBE’s Minecom Power Coupler
• Battery with two bolts, washers and spring washers
• Installation document (MAN-02-00067)
2 Batteries (3)
4. The power supply plug can now be connected to the power socket.
5. Using a multimeter, check for a voltage of 24 V
DC across the terminal blocks.
6. Run the DC cable from the terminal blocks
through the other gland to the Power Coupler on
the Leaky Feeder cable, ensuring polarity is
correct.
7. Close and lock the unit and check the LED on
the front is green.
In
MAN-02-00067 Page 2 of 3
24 V Power Station Manual
SPECIFICATIONS
Nominal Output Voltage: 24 V
Fault Protection: Independent DIN resettable 2.0 Amp Base / Tunnel circuit breakers
DIN terminal blocks (wire size 30AWG to 12AWG)
Termination: Wire Area Size Min: 0.5mm²
Wire Area Size Solid Max: 4mm²
Battery Capacity: 18 AH, 432 WH
Charge Current: 3.6 A Continuous
Charge Time from Flat: 7 hours
Battery Lifetime: 2-3 years nominal *
Ripple current: ~ 50mV
MAN-02-00067 Page 3 of 3