Escolar Documentos
Profissional Documentos
Cultura Documentos
AN/PRC-119F
(NSN 5820-01-451-8252) (EIC: N/A)
AN/VRC-87F
(NSN 5820-01-451-8248) (EIC: N/A)
AN/VRC-88F
(NSN 5820-01-452-8435) (EIC: N/A)
AN/VRC-89F
(NSN 5820-01-451-8247) (EIC: N/A)
AN/VRC-90F
(NSN 5820-01-451-8246) (EIC: N/A)
AN/VRC-91F
(NSN 5820-01-451-8249) (EIC: N/A)
AND
AN/VRC-92F
(NSN 5820-01-451-8250) (EIC: N/A)
NOTE: The portion of text affected by the changes is indicated by a vertical line in the outer
margin of the page. Changes to illustrations are indicated by a vertical line adjacent to the
title.
Date of issue for the original manual and changed pages are:
A/(B blank)
TM 11-5820-890-30P-3
You can help improve this manual. If you find any mistakes, or if you know of a way to improve the
procedures, please let us know. Mail your letter, DA Form 2028 (Recommended Changes to Publications
and Blank Forms) or DA Form 2028–2 located in back of this manual direct to: Commander, US Army
Communications-Electronics Command and Fort Monmouth, ATTN: AMSEL-LC-LEO-D-CS-CFO, Fort
Monmouth, New Jersey 07703-5006. The fax number is 732-532-1413, DSN 992-1413. You may also e-
mail your recommendations to AMSEL-LC-LEO-PUBS-CHG@cecom3.monmouth.army.mil
TABLE OF CONTENTS
Illus/
Page Figure
Section I. Introduction ................................................................................................... 1
II. Repair Parts List............................................................................................ 1
Group 00 SINCGARS Family of Radios .................................................................. 1-1 1
64 Radio Receiver-Transmitter RT-1523E(C)/U .................................................. 2-1 2
6401 Electronic Assembly.............................................................................. 3-1 3
640101 Protocol Module Assembly................................................................ 4-1 4
640102 Radio Frequency Module Assembly .................................................. 5-1 5
6402 Rear Cover Assembly ........................................................................... 6-1 6
6403 Chassis Assembly-Receiver-Transmitter............................................... 7-1 7
640301 Electrical Chassis.............................................................................. 8-1 8
6404 Top Cover Assembly............................................................................. 9-1 9
6405 Battery Cover Assembly........................................................................ 10-1 10
65 Vehicular Amplifier-Adapter AM-7239E/VRC.................................................. 11-1 11
6501 Electrical Chassis-Electronic Equipment-Adapter/Power Supply............ 12-1 12
6502 Electronic Components Assembly-Sidehat ............................................ 13-1 13
6503 Electronic Components Assembly-Power Control.................................. 14-1 14
i
TM 11-5820-890-30P-3
TABLE OF CONTENTS
Illus/
Page Figure
Group 6504 Access Cover-Power Control
(see group 65 for listing of parts)
6505 Sidehat Cover
(see group 65 for listing of parts)
6506 Electrical Equipment Shelf .................................................................... 15-1 15
6507 Electrical Equipment Mounting Base ..................................................... 16-1 16
66 Radio Set AN/PRC-119F (see group 00 for listing of parts)
6601 Receiver-Transmitter RT-1523E(C)/U
(see group 64 for listing of parts)
6602 Manpack Antenna AS-3683/PRC
(see TM 11-5820-890-30P-1 for listing of parts)
6603 Handheld Remote Control Radio Device C-12493/U
(see TM 11-5820-890-30P-1 for listing of parts)
67 Radio Set AN/VRC/-87F (see group 00 for listing of parts)
6701 Receiver-Transmitter RT-1523E(C)/U
(see group 64 for listing of parts)
6702 Vehicular Amplifier-Adapter AM-7239E/VRC
(see group 65 for listing of parts)
68 Radio Set AN/VRC-88F (see group 00 for listing of parts)
6801 Receiver-Transmitter RT-1523E(C)/U
(see group 64 for listing of parts)
6802 Vehicular Amplifier-Adapter AM-7239E/VRC
(see group 65 for listing of parts)
6803 Manpack Antenna AS-3683/PRC
(see TM 11-5820-890-30P-1 for listing of parts)
6804 Handheld Remote Control Radio Device C-12493/U
(see TM 11-5820-890-30P-1 for listing of parts)
69 Radio Set AN/VRC-89F (see group 00 for listing of parts)
6901 Receiver-Transmitter RT-1523E(C)/U
(see group 64 for listing of parts)
6902 Vehicular Amplifier-Adapter AM-7239E/VRC
(see group 65 for listing of parts)
6903 Radio Frequency Amplifier, AM-7238B/VRC
(see TM 11-5820-890-30P-1 for listing of parts)
70 Radio Set AN/VRC-90F (see group 00 for listing of parts)
7001 Receiver-Transmitter RT-1523E(C)/U
(see group 64 for listing of parts)
7002 Vehicular Amplifier-Adapter AM-7239E/VRC
(see group 65 for listing of parts)
7003 Radio Frequency Amplifier, AM-7238B/VRC
(see TM 11-5820-890-30P-1 for listing of parts)
71 Radio Set AN/VRC-91F (see group 00 for listing of parts)
7101 Receiver-Transmitter RT-1523E(C)/U
(see group 64 for listing of parts)
7102 Vehicular Amplifier-Adapter AM-7239E/VRC
(see group 65 for listing of parts)
7103 Radio Frequency Amplifier, AM-7238B/VRC
(see TM 11-5820-890-30P-1 for listing of parts)
7104 Manpack Antenna AS-3683/PRC
(see TM 11-5820-890-30P-1 for listing of parts)
ii
TM 11-5820-890-30P-3
TABLE OF CONTENTS
Illus/
Page Figure
Group 7105 Handheld Remote Control Radio Device C-12493/U
(see TM 11-5820-890-30P-1 for listing of parts)
72 Radio Set AN/VRC-92F (see group 00 for listing of parts)
7201 Receiver-Transmitter RT-1523E(C)/U
(see group 64 for listing of parts)
7202 Vehicular Amplifier-Adapter AM-7239E/VRC
(see group 65 for listing of parts)
7203 Radio Frequency Amplifier, AM-7238B/VRC
(see TM 11-5820-890-30P-1 for listing of parts)
7204 Electronic Equipment Auxiliary Kit MK-2312/VRC
(see TM 11-5820-890-30P-1 for listing of parts)
97 Interconnecting Group ON-373B/GRC .......................................................... 40-1 40
9701 Electrical Communications Equipment Case
(see TM 11-5820-890-30P-1 for listing of parts)
970101 Equipment Case
(see TM 11-5820-890-30P-1 for listing of parts)
970102 Equipment Cove
(see TM 11-5820-890-30P-1 for listing of parts)
9702 Power Supply
(see TM 11-5820-890-30P-1 for listing of parts)
970201 Chassis/Power Supply Assembly
(see TM 11-5820-890-30P-1 for listing of parts)
97020102 Electrical Equipment Chassis
(see TM 11-5820-890-30P-1 for listing of parts)
9703 Electrical Wiring Harness - Radio Frequency Power Amplifier Adapter
(see TM 11-5820-890-30P-1 for listing of parts)
9704 Electrical Wiring Harness - Fill Device
(see TM 11-5820-890-30P-1 for listing of parts)
9705 Branched Wiring Harness - Receiver - Transmitter
(see TM 11-5820-890-30P-1 for listing of parts)
9706 Branched Wiring Harness - Control Monitor
(see TM 11-5820-890-30P-1 for listing of parts)
9707 Branched Wiring Harness - Electrical Power
(see TM 11-5820-890-30P-1 for listing of parts)
9710 Static Control Tablerunner
(see TM 11-5820-890-30P-1 for listing of parts)
97 9711 Branched Wiring Harness - Amplifier - Adapter
(see TM 11-5820-890-30P-1 for listing of parts)
9712 Electrical Wiring Harness - Power Supply
(see TM 11-5820-890-30P-1 for listing of parts)
9713 Branched Wiring Harness - Auxiliary RFPA Mount
(see TM 11-5820-890-30P-1 for listing of parts)
9714 Branched Wiring Harness - Power Supply Adapter
(see TM 11-5820-890-30P-1 for listing of parts)
9715 Branched Wiring Harness - Battery Box
(see TM 11-5820-890-30P-1 for listing of parts)
9716 Branched Wiring Harness - Battery Tray
(see TM 11-5820-890-30P-1 for listing of parts)
9717 Branched Wiring Harness - Control Unit Loudspeaker
(see TM 11-5820-890-30P-1 for listing of parts)
iii
TM 11-5820-890-30P-3
TABLE OF CONTENTS
Illus/
Page Figure
Group 9718 Branched Wiring Harness - Remote Control Unit
(see TM 11-5820-890-30P-1 for listing of parts)
9719 Branched Wiring Harness - Splitter Cable
(see TM 11-5820-890-30P-1 for listing of parts)
9724 Branched Wiring Harness - Amplifier - Adapter
(see TM 11-5820-890-30P-1 for listing of parts)
9725 Branched Wiring Harness - Receiver - Transmitter
(see TM 11-5820-890-30P-1 for listing of parts)
9726 Branched Wiring Harness - Receiver - Transmitter................................ 41-1 41
9727 Adapter Cable Assembly - Y ................................................................. 42-1 42
9728 Circuit Card Assembly - Extender Card ................................................. 43-1 43
iv
TM 11-5820-890-30P-3
SECTION I
INTRODUCTION
1. Scope
This RPSTL lists and authorizes spares and repair parts; special tools; special test, measurement, and diagnostic
equipment (TMDE); and other special support equipment required for performance of unit and direct support
maintenance of AN/PRC-119F, AN/VRC-87F, AN/VRC-88F, AN/VRC-89F, AN/VRC-90F, AN/VRC-91F, and
AN/VRC-92F. It authorizes the requisitioning, issue, and disposition of spares, repair parts and special tools as
indicated by the source, maintenance and recoverability (SMR) codes.
2. General
This Repair Parts and Special Tools List is divided into the following sections:
a. Section II, Repair Parts List. A list of spares and repair parts authorized by this RPSTL for use in the
performance of maintenance. The list also includes parts which must be removed for replacement of the
authorized parts. Parts lists are composed of functional groups in ascending numeric sequence, with the parts in
each group listed in ascending item number sequence. Figure numbers are listed directly beneath the group
header. Repair part kits are listed separately in their own functional group within section II. Repair parts for
reparable special tools are also listed in this section. Items are shown on the associated illustration.
b. Section III, Special Tools List. A list of special tools, special TMDE, and other special support equipment
authorized by this RPSTL (as indicated by Basis of Issue (BOI) information in DESCRIPTION AND USABLE ON
CODE (UOC) column (5) for the performance of maintenance.
c. Section IV. Cross-Reference Indexes. There are two cross-reference indexes in this RPSTL: the National
Stock Number Index and the Part Number Index. The National Stock Number Index refers you to the figure and
item number. The Part Number Index refers you to the figure and item number.
1st two
XX XX X
positions
NOTE
Complete repair: Maintenance capacity, capability, and authority to perform all
corrective maintenance tasks of the “Repair” function in a use/user environment in
order to restore serviceability to a failed item.
1
TM 11-5820-890-30P-3
(1) Source Code. The source code tells you how to get an item needed for maintenance, repair, or overhaul
of an end item/equipment. Explanations of source codes follows:
Code Explanation
XA — Do not requisition an “XA” coded item. Order its next higher assembly.
XB — If an “XB” item is not available from salvage, order it using the CAGEC and part number given.
XC — Installation drawing, diagram, instruction sheet, field service drawing, that is identified by manufacturers
part number.
XD — Item is not stocked. Order an “XD” coded item through normal supply channels using the CAGEC and
part number given, if no NSN is available.
NOTE
Cannibalization or controlled exchange, when authorized, may be used as a source of
supply for items with the above source codes, except for those source coded “XA” or
those aircraft support items restricted by requirements of AR 750-1.
2
TM 11-5820-890-30P-3
(2) Maintenance Code. Maintenance codes tell you the category of maintenance authorized to USE and
REPAIR support items. The maintenance codes are entered in the third and fourth positions of the SMR code as
follows:
(a) The maintenance code entered in the third position tells you the lowest maintenance category
authorized to remove, replace, and use an item. The maintenance code entered in the third position will indicate
authorization to one of the following categories of maintenance.
Code Application/Explanation
Code Application/Explanation
O — Organizational or aviation unit is the lowest category that can do complete repair of the item.
F — Direct support or aviation intermediate is the lowest category that can do complete repair of the item.
H — General support is the lowest category that can do complete repair of the item.
L — Specialized repair activity (designated the special repair activity) is the lowest category that can do
complete repair of the item.
D — Depot is the lowest category that can do complete repair of the item.
Z — Nonreparable. No repair is authorized.
B — No repair is authorized. (No parts or special tools are authorized for the maintenance of a “B” coded
item.) However, the item may be reconditioned by adjusting, lubricating, etc., at the user
category.
(3) Recoverability Code. Recoverability codes are assigned to items to indicate the disposition action on
unserviceable items. The recoverability code is entered in the fifth position of the SMR Code as follows:
Recoverability Application/Explanation
codes
Z — Nonreparable item. When unserviceable, condemn and dispose of the item at the category of
maintenance shown in the third position of SMR code.
O — Reparable item. When uneconomically reparable, condemn and dispose of the item at
organizational or aviation unit category.
F — Reparable item. When uneconomically reparable, condemn and dispose of the item at the direct
support or aviation intermediate category.
H — Reparable item. When uneconomically reparable, condemn and dispose of the item at general
support category.
D — Reparable item. When beyond lower category repair capability, return to depot. Condemnation and
disposal of item not authorized below depot category.
L — Reparable item. Condemnation and disposal not authorized below specialized repair activity (SRA).
A — Item requires special handling or condemnation procedures because of specific reasons (e.g.,
precious metal content, high dollar value, critical material, or hazardous material). Refer to
appropriate manuals/directives for specific instructions.
3
TM 11-5820-890-30P-3
c. NSN (Column (3)). The national stock number for the item is listed in this column.
d. CAGEC (Column (4)). The Commercial and Government Entity Code (CAGEC) is a 5-digit numeric code
which is used to identify the manufacturer, distributor, or Government agency, etc., that supplies the item.
e. Part Number (Column (5)). Indicates the primary number used by the manufacturer (individual, company,
firm, corporation, or Government activity), which controls the design and characteristics of the item by means of
its engineering drawings, specifications standards, and inspection requirements to identify an item or range of
items.
NOTE
When you use an NSN to requisition an item, the item you receive may have a
different part number from the part ordered.
f. Description and Usable on Code (UOC) (Column (6)). This column includes the following information:
(1) The Federal item name and, when required, a minimum description to identify the item.
(2) The statement “END OF FIGURE” appears just below the last item description in Column (5) for a given
figure in both section II and section III.
g. Qty (Column (7)). Indicates the quantity of the item used in the breakout shown on the illustration figure,
which is prepared for a functional group, subfunctional group, or an assembly. A “V” appearing in this column in
lieu of a quantity indicates that the quantity is variable and the quantity may vary from application to application.
NSN When using this column to locate an item, ignore the first four
(e.g., 5385-01-574-1476) digits of the NSN. Use the complete NSN (13 digits) when
requisitioning items by stock number.
(2) Fig. column. This column lists the number of the figure where the item is identified/located. The
illustrations are in numerical sequence in sections II and III.
(3) Item column. The item number identifies the item associated with the figure listed in the adjacent Fig.
column. This item is also identified by the NSN listed on the same line.
b. Part Number Index. Part numbers in this index are listed by part number in ascending alphanumeric
sequence.
(1) CAGEC column. This column lists the Commercial and Government Entity Code (CAGEC).
(2) Part number column. This column indicates the part number assigned to the item.
(3) Stock number column. This column lists the National stock number for the associated part number and
manufacturer identified in the part number and CAGEC columns to the left.
(4) Fig. column. This column lists the number of the figure where the item is identified/located in sections II
and III.
(5) Item column. The item number is that number assigned to the item as it appears in the figure referenced
in the adjacent figure number column.
4
TM 11-5820-890-30P-3
5. Special Information
a. Associated Publications. The following publications pertain to SINCGARS Ground Radio Sets:
TM 11-5820-890-20-1 Unit Maintenance Manual for Radio Sets AN/PRC-119A, AN/PRC-119D, AN/PRC-119F,
AN/VRC-87A, AN/VRC-87D, AN/VRC-87F, AN/VRC-88A, AN/VRC-88D, AN/VRC-88F, AN/VRC-89A, AN/VRC-
89D, AN/VRC-89F, AN/VRC-90A, AN/VRC-90D, AN/VRC-90F, AN/VRC-91A, AN/VRC-91D, AN/VRC-91F,
AN/VRC-92A, AN/VRC-92D and AN/VRC-92F.
TM 11-5820-890-20-2 Unit Maintenance Manual for Radio Sets AN/PRC-119A, AN/PRC-119D, AN/PRC-119F,
AN/VRC-87A, AN/VRC-87D, AN/VRC-87F, AN/VRC-88A, AN/VRC-88D, AN/VRC-88F, AN/VRC-89A, AN/VRC-
89D, AN/VRC-89F, AN/VRC-90A, AN/VRC-90D, AN/VRC-90F, AN/VRC-91A, AN/VRC-91D, AN/VRC-91F,
AN/VRC-92A, AN/VRC-92D and AN/VRC-92F.
TM 11-5820-890-20P-1 Unit Maintenance Repair Parts and Special Tools List for Radio Sets AN/PRC-119,
AN/PRC-119A, AN/PRC-119D, AN/VRC-87, AN/VRC-87A, AN/VRC-87D, AN/VRC-88, AN/VRC-88A, AN/VRC-
88D, AN/VRC-89, AN/VRC-89A, AN/VRC-89D, AN/VRC-90, AN/VRC-90A, AN/VRC-90D, AN/VRC-91, AN/VRC-
91A, AN/VRC-91D, AN/VRC-92, AN/VRC-92A and AN/VRC-92D.
TM 11-5820-890-20P-2 Unit Maintenance Repair Parts and Special Tools List for Radio Sets AN/PRC-119F,
AN/VRC-87F, AN/VRC-88F, AN/VRC-89F, AN/VRC-90F, AN/VRC-91F and AN/VRC-92F.
TM 11-5820-890-30P-1 Direct Support Maintenance Repair Parts and Special Tools List for Radio Sets AN/PRC-
119, AN/PRC-119A, AN/PRC-119D, AN/VRC-87, AN/VRC-87A, AN/VRC-87D, AN/VRC-88, AN/VRC-88A,
AN/VRC-88D, AN/VRC-89, AN/VRC-89A, AN/VRC-89D, AN/VRC-90, AN/VRC-90A, AN/VRC-90D, AN/VRC-91,
AN/VRC-91A, AN/VRC-91D, AN/VRC-92, AN/VRC-92A and AN/VRC-92D.
TM 11-5820-890-30P-2 Direct Support Maintenance Repair Parts and Special Tools List for SINCGARS GD
Radio Sets.
TM 11-5820-890-30-6 (5 Volumes) Direct Support Maintenance Manual for SINCGARS Ground Radio Sets.
b. Illustrations-Listing. Only those parts coded “O”, “F” in the third position of the SMR code are listed in the
tabular listing. Only illustrations containing unit and direct support authorized items appear in this manual.
c. National Stock Numbers. National Stock Numbers (NSNs) that are missing from “P” source coded items
have been applied for and will be added to this TM by future change/revision when they are entered in the Army
Master Data File (AMDF). Until the NSNs are established and published, submit exception requisition to: US Army
Communications-Electronics Command and Fort Monmouth, ATTN: AMSEL-LC-COM-R-SR, Fort Monmouth, NJ
07703-5023 for the part required to support your equipment.
d. Serial Number Effectivity. When part numbers of spare/repair items are not the same for all serial numbered
equipment, of the same model, serial number effectivity will identify the correct parts to be ordered. The serial
number effectivity that appears in the tabular list is the serial number effectivity for the next higher assembly. If a
figure has more than one model, both models will be shown, each with it’s own serial number effectivity. If a part
in the tabular list does not have a serial number effectivity then that part can be used in any model. Whereas, if a
part has a serial number effectivity, it is model unique and can only be used in the model marked with the same
serial number effectivity.
5
TM 11-5820-890-30P-3
(2) Second. Find the figure covering the assembly group or subassembly group to which the item belongs.
(3) Third. Identify the item on the figure and note the item number.
(4) Fourth. Refer to the Repair Parts List for the figure and item numbers. The NSNs and part numbers are
on the same line as the associated item numbers.
b. When National Stock Number or Part Number is Known.
(1) First. If you have the national stock number, look in the STOCK NUMBER column of the National Stock
Number Index. The NSN is arranged in national item identification number (NIIN) sequence (see paragraph 4a).
Note the figure and item number next to the NSN.
(2) Second. Turn to the figure and locate the item number. Verify that the item is the one you are looking
for.
NOTE
If you have the part number, look in the PART NUMBER column of the Part Number
Index. Identify the figure and item number, look up the item on the figure in Section II.
7. Abbreviations
Not applicable.
6
TM 11-5820-890-30P-3
EL9WK500
EL9WK501
2
5
1
EL9WK502
EL9WK503
EL9WK504
2
9
1
1 8
4
7
6
EL9WK505
8
1
10
9
P/O 10
P/O 10
P/O 10
7
P/O 10
6 6
EL9WK506
19
11
18
21
20
17
12
16
13
15
14
EL9WK507
Figure 1. SINCGARS Family of Radios (Ancillary Items) (Sheet 8 of 8)
SECTION II TM11-5820-890-30P-3
(1) (2) (3) (4) (5) (6) (7)
ITEM SMR PART
NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY
FIGURE 1
END OF FIGURE
1-1
TM 11-5820-890-30P-3
FIGURE 2
END OF FIGURE
2-1
TM 11-5820-890-30P-3
FIGURE 3
END OF FIGURE
3-1
TM 11-5820-890-30P-3
FIGURE 4
END OF FIGURE
4-1
TM 11-5820-890-30P-3
FIGURE 5
END OF FIGURE
5-1
TM 11-5820-890-30P-3
FIGURE 6
END OF FIGURE
6-1
TM 11-5820-890-30P-3
FIGURE 7
END OF FIGURE
7-1
TM 11-5820-890-30P-3
FIGURE 8
END OF FIGURE
8-1
TM 11-5820-890-30P-3
FIGURE 9
END OF FIGURE
9-1
TM 11-5820-890-30P-3
FIGURE 10
END OF FIGURE
10-1
TM 11-5820-890-30P-3
FIGURE 11
END OF FIGURE
11-1
TM 11-5820-890-30P-3
FIGURE 12
END OF FIGURE
12-1
TM 11-5820-890-30P-3
FIGURE 13
END OF FIGURE
13-1
TM 11-5820-890-30P-3
FIGURE 14
END OF FIGURE
14-1
TM 11-5820-890-30P-3
FIGURE 15
END OF FIGURE
15-1
TM 11-5820-890-30P-3
FIGURE 16
END OF FIGURE
16-1
TM 11-5820-890-30P-3
FIGURE 40
END OF FIGURE
40-1
TM 11-5820-890-30P-3
FIGURE 41
41-1
SECTION II TM11-5820-890-30P-3
(1) (2) (3) (4) (5) (6) (7)
ITEM SMR PART
NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY
END OF FIGURE
41-2
TM 11-5820-890-30P-3
FIGURE 42
END OF FIGURE
42-1
TM 11-5820-890-30P-3
FIGURE 43
END OF FIGURE
43-1
TM 11-5820-890-30P-3
FIGURE 50
END OF FIGURE
50-1
TM 11-5820-890-30P-3
GROUP 51
51-1
SECTION III TM11-5820-890-30P-3
(1) (2) (3) (4) (5) (6) (7)
ITEM SMR PART
NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY
END OF FIGURE
51-2
TM 11-5820-890-30P-3
FIGURE 52
END OF FIGURE
52-1
TM 11-5820-890-30P-3
FIGURE 53
53-1
SECTION III TM11-5820-890-30P-3
(1) (2) (3) (4) (5) (6) (7)
ITEM SMR PART
NO CODE NSN CAGEC NUMBER DESCRIPTION AND USABLE ON CODES(UOC) QTY
END OF FIGURE
53-2
SECTION IV TM11-5820-890-30P-3
CROSS-REFERENCE INDEXES
5330-00-009-7725 40 1 5120-01-119-2586 53 10
5965-00-043-3463 1 2 5120-01-119-2593 53 6
51 3 5305-01-126-4708 11 4
5305-00-054-6668 7 19 5310-01-145-3154 6 11
5310-00-057-0573 2 24 4240-01-165-8865 51 6
3 7 5325-01-173-5655 53 16
41 37 5325-01-180-6844 53 14
5120-00-138-6803 53 21 5305-01-185-6872 3 6
5305-00-147-8050 7 13 5305-01-186-4535 4 2
5310-00-194-3647 2 5 5 8
5310-00-224-0746 41 38 5975-01-188-8873 1 12
5120-00-227-8095 53 43 5325-01-199-6349 53 13
5120-00-240-8703 53 42 5325-01-199-6350 53 12
5120-00-245-9539 53 20 5305-01-200-0197 2 8
5935-00-259-0205 52 5 11 3
5120-00-289-0534 53 35 5305-01-200-3940 40 4
5140-00-315-2747 53 1 5340-01-200-6617 15 3
5935-00-355-4459 41 40 5325-01-201-0429 53 15
5305-00-433-3741 41 33 5325-01-201-0831 53 18
5305-00-459-4687 41 39 5340-01-201-3440 14 5
5305-00-465-6745 41 42 5310-01-203-2654 40 5
5310-00-550-3715 41 46 5995-01-203-4653 52 6
5920-00-557-2647 52 10 5305-01-204-3017 2 25
5365-00-598-5394 42 5 13 14
5325-00-631-7891 8 2 5325-01-216-7444 53 17
5120-00-720-1975 53 29 5895-01-216-9552 1 10
5975-00-727-5153 13 4 5985-01-235-9189 1 5
41 6 5120-01-258-7503 53 23
42 6 3040-01-261-2630 16 3
5315-00-805-7287 8 1 5895-01-261-2913 51 2
5940-00-813-0698 13 2 5935-01-263-5855 41 22
5935-00-926-7523 52 8 5310-01-266-3060 14 21
5310-00-933-8121 14 11 5310-01-268-1237 14 22
5120-00-935-7473 53 28 5315-01-280-6209 14 1
5305-01-020-9560 7 22 5920-01-292-7060 51 5
5305-01-034-6624 11 11 5310-01-298-1440 6 9
12 14 12 16
14 4 5935-01-303-3092 41 13
5935-01-037-3476 52 9 6625-01-303-3093 51 19
5925-01-047-1458 14 16 5995-01-304-2025 52 3
5120-01-051-3506 53 41 5995-01-304-2026 1 8
5305-01-064-4046 7 6 5995-01-306-8107 51 25
5999-01-069-7758 41 47 5310-01-307-7702 14 23
5935-01-076-9450 41 23 5985-01-308-8988 1 13
6240-01-093-7323 14 8 5995-01-310-0335 1 6
5120-01-109-4788 53 36 5998-01-312-7994 53 40
5120-01-114-0946 53 8 5935-01-323-2684 41 12
5120-01-118-6267 53 11 5305-01-331-6050 11 6
5120-01-118-6280 53 4 12 3
5120-01-118-6281 53 5 13 9
I-1
SECTION IV TM11-5820-890-30P-3
CROSS-REFERENCE INDEXES
5305-01-331-6050 14 14 5985-01-425-7305 1 16
5120-01-335-0852 53 24 5310-01-426-7543 16 6
5120-01-335-0906 53 27 5330-01-430-5004 12 26
5340-01-345-5988 12 32 5310-01-430-9243 16 4
13 18 5315-01-431-2255 12 31
5340-01-346-2498 14 19 5305-01-431-7596 12 1
5340-01-346-4291 2 14 5935-01-431-8667 12 34
12 5 13 17
13 16 5935-01-431-8673 42 12
5940-01-346-9237 13 1 5935-01-431-8679 41 29
5120-01-348-7271 53 25 5895-01-432-8370 1 14
5310-01-352-9590 41 41 5340-01-433-5455 16 7
5985-01-353-4943 1 15 5310-01-437-9253 6 6
5120-01-357-2327 53 34 12 6
5340-01-357-2333 12 17 6135-01-438-9450 1 4
5136-01-357-6176 53 3 2 11
5136-01-357-6177 53 39 5305-01-439-4201 41 30
5136-01-357-6178 53 38 5305-01-439-4220 14 6
5136-01-357-8584 53 37 15 4
5136-01-357-8585 53 32 5310-01-440-3574 12 4
5995-01-361-5103 52 2 14 20
5995-01-361-5104 52 4 5995-01-442-7267 51 18
5210-01-361-7641 53 22 5895-01-444-1218 1 7
5120-01-367-3497 53 44 5820-01-444-1219 1 1
5995-01-371-2405 51 21 5998-01-455-1788 3 5
5995-01-371-2407 51 27 5998-01-455-9638 6 14
5995-01-371-2408 51 22 5998-01-455-9639 5 4
5995-01-371-2409 51 15 5998-01-455-9640 7 3
5995-01-371-2410 51 30 5998-01-455-9641 3 2
6130-01-371-2417 51 14 5895-01-455-9642 2 16
5995-01-371-4035 51 17 5998-01-455-9650 5 7
5995-01-371-4036 51 20 5998-01-456-0851 3 4
5995-01-371-4037 51 26 5998-01-456-0852 4 1
5995-01-371-4038 51 29 5998-01-456-2389 4 4
5995-01-371-4039 51 24 5998-01-456-4410 12 37
5995-01-371-5579 51 23 5985-01-456-4416 7 20
5995-01-371-5580 51 16 5998-01-456-4417 12 24
5985-01-371-6944 51 4 5998-01-456-5449 14 10
5850-01-372-0153 14 7 5998-01-456-6398 13 10
5995-01-372-0243 51 28 5340-01-456-7985 1 11
5305-01-373-8817 2 19 5120-01-458-8206 53 30
6625-01-375-6344 52 7 5998-01-459-6621 52 13
5310-01-378-3033 40 2 5995-01-459-6623 51 34
5305-01-379-5930 5 1 5930-01-459-6624 52 12
5935-01-386-0360 7 18 5995-01-459-8517 51 33
5999-01-388-9075 13 21 5895-01-459-8523 50 1
5895-01-407-2627 1 9 5895-01-461-4505 1 3
5310-01-412-9771 12 19 5340-01-461-4741 1 19
5310-01-412-9772 12 18 5995-01-461-6738 12 38
5305-01-417-2469 16 8 5995-01-461-6876 13 12
I-2
SECTION IV TM11-5820-890-30P-3
CROSS-REFERENCE INDEXES
5995-01-461-7148 13 11 5935-01-464-6216 12 11
5995-01-461-7150 6 2 5999-01-464-6283 12 35
5995-01-461-7541 7 26 5310-01-464-7088 7 17
5995-01-461-7545 13 19 5310-01-464-7089 7 14
5995-01-461-7547 2 10 5330-01-464-8046 12 30
5995-01-461-8616 7 9 5340-01-464-8367 4 3
5355-01-461-8648 7 15 5310-01-464-8777 7 21
6160-01-461-9622 2 12 13 15
5995-01-461-9777 2 26 5935-01-464-9471 12 10
5935-01-461-9832 6 12 5999-01-464-9510 11 16
5340-01-462-0317 2 7 9330-01-464-9853 15 1
5305-01-463-4307 2 6 16 1
5305-01-463-4447 6 1 5310-01-465-0750 6 8
7 1 12 15
5305-01-463-4490 6 10 5310-01-465-0774 7 5
5935-01-463-7167 42 1 5310-01-465-0855 2 18
5999-01-463-7195 5 6 5310-01-465-0906 6 7
5935-01-463-8290 1 18 5310-01-465-1159 7 4
5340-01-463-9002 1 20 5340-01-465-4793 13 13
5305-01-463-9019 6 13 5340-01-465-4794 12 2
11 14 5961-01-466-3789 14 12
12 8 5310-01-466-4854 16 5
5305-01-463-9206 2 3 5975-01-467-4678 1 21
5331-01-463-9499 6 3 5935-01-469-9928 41 1
5305-01-464-0368 7 16 5998-01-470-3965 14 10
5305-01-464-0503 12 21 5331-01-470-6772 10 1
5331-01-464-1101 7 25 5331-01-470-6775 9 1
5340-01-464-1755 12 33 5331-01-470-6780 6 4
5330-01-464-2017 11 15 5331-01-470-6782 2 15
5331-01-464-2476 14 15 5935-01-470-7486 43 1
5331-01-464-2485 13 3 52 11
5998-01-464-2511 7 2 5995-01-470-8487 12 23
5340-01-464-2798 14 3 5310-01-472-8625 7 12
5340-01-464-2857 2 4 5331-01-473-2351 6 15
5340-01-464-3477 7 7 5895-01-473-6804 2 17
5305-01-464-4458 14 13 5340-01-477-6223 12 36
5305-01-464-4617 9 4 14 24
5305-01-464-4908 2 2 5895-01-479-3963 2 1
5998-01-464-5445 3 5 5330-01-482-3077 7 8
5995-01-464-5977 12 27 5330-01-482-4442 12 28
5995-01-464-5983 12 23 9330-01-482-7388 7 11
5995-01-464-5991 12 22 5136-01-490-6450 53 31
5995-01-464-5999 12 9 5120-01-492-6137 53 45
5995-01-464-6004 12 29 5120-01-492-6138 53 46
5995-01-464-6008 14 9 5120-01-492-6139 53 47
5995-01-464-6017 12 25 5995-01-494-7961 51 32
5995-01-464-6021 12 20 5995-01-494-7962 51 31
5970-01-464-6092 9 3
5935-01-464-6212 12 12
41 32
I-3
SECTION IV TM11-5820-890-30P-3
CROSS-REFERENCE INDEXES
I-4
SECTION IV TM11-5820-890-30P-3
CROSS-REFERENCE INDEXES
80063 A3013739-310 14 17
80063 A3013739-311 13 8
14 18
80063 A3013739-312 13 5
80063 A3013739-313 13 6
80063 A3013739-314 41 16
80063 A3013824-3 5995-01-304-2026 1 8
80063 A3013902-4 5995-01-306-8107 51 25
80063 A3013903-1 5995-01-203-4653 52 6
80063 A3014023-10 40 6
80063 A3014125-3 40 3
80063 A3014484-1 5895-01-261-2913 51 2
80063 A3018049-2 53 33
80063 A3018226-2 5315-01-431-2255 12 31
80063 A3018440-3 41 36
42 9
80063 A3018583-1 5995-01-304-2025 52 3
80063 A3018693-2 5985-01-371-6944 51 4
80063 A3018715-1 51 7
80063 A3018731-4 2 20
80063 A3018767-1 5210-01-361-7641 53 22
80063 A3019064-11 5310-01-464-8777 7 21
13 15
80063 A3019064-14 5310-01-437-9253 6 6
12 6
80063 A3019064-16 5310-01-412-9771 12 19
80063 A3019064-17 5310-01-465-0750 6 8
12 15
80063 A3019064-8 5310-01-465-0774 7 5
80063 A3019079-2 5310-01-465-0855 2 18
80063 A3019239-3 41 48
80063 A3131805-1 51 8
80063 A3132832-2 5305-01-439-4220 14 6
15 4
80063 A3132871-2 5340-01-346-4291 2 14
12 5
13 16
80063 A3132871-3 5340-01-346-2498 14 19
80063 A3132871-4 5340-01-357-2333 12 17
80063 A3132871-9 5340-01-345-5988 12 32
13 18
80063 A3140088-5 5305-01-417-2469 16 8
80063 A3140090-10 5305-01-439-4201 41 30
80063 A3142076-2 5895-01-461-4505 1 3
80063 A3142124-1 6625-01-303-3093 51 19
80063 A3142236-1 5935-00-355-4459 41 40
80063 A3148220-1 5995-01-361-5104 52 4
80063 A3148221-1 5995-01-361-5103 52 2
80063 A3167692-2 5330-01-464-2017 11 15
80063 A3167702-3 5935-01-469-9928 41 1
80063 A3167747-1 6130-01-371-2417 51 14
I-5
SECTION IV TM11-5820-890-30P-3
CROSS-REFERENCE INDEXES
I-6
SECTION IV TM11-5820-890-30P-3
CROSS-REFERENCE INDEXES
I-7
SECTION IV TM11-5820-890-30P-3
CROSS-REFERENCE INDEXES
I-8
SECTION IV TM11-5820-890-30P-3
CROSS-REFERENCE INDEXES
I-9
SECTION IV TM11-5820-890-30P-3
CROSS-REFERENCE INDEXES
I-10
SECTION IV TM11-5820-890-30P-3
CROSS-REFERENCE INDEXES
I-11
RECOMMENDED CHANGES TO EQUIPMENT TECHNICAL PUBLICATIONS
5-6 5-8 Add new step f.1 to read, •Replace cover plate removed in
step e.1, above."
FORM PREVIOUS EDITIONS P.S. - IF YOUR OUTFIT WANTS TO KNOW ABOUT YOUR
DA 2028-2
1 JUL 79 ARE OBSOLETE RECOMMENDATION MAKE A CARBON COPY OF THIS
AND GIVE IT TO YOUR HEADQUARTERS.
REVERSE OF DA FORM 2028-2
Commander
U.S. Army Communications-Electronics Command
and Fort Monmouth
ATTN: AMSEL-LC-LEO-D-CS-CFO
Fort Monmouth, New Jersey 07703-5006
RECOMMENDED CHANGES TO EQUIPMENT TECHNICAL PUBLICATIONS
Commander
U.S. Army Communications-Electronics Command
and Fort Monmouth
ATTN: AMSEL-LC-LEO-D-CS-CFO
Fort Monmouth, New Jersey 07703-5006
RECOMMENDED CHANGES TO EQUIPMENT TECHNICAL PUBLICATIONS
Commander
U.S. Army Communications-Electronics Command
and Fort Monmouth
ATTN: AMSEL-LC-LEO-D-CS-CFO
Fort Monmouth, New Jersey 07703-5006
RECOMMENDED CHANGES TO EQUIPMENT TECHNICAL PUBLICATIONS
Commander
U.S. Army Communications-Electronics Command
and Fort Monmouth
ATTN: AMSEL-LC-LEO-D-CS-CFO
Fort Monmouth, New Jersey 07703-5006
TM 11-5820-890-30P-3
ERIC K. SHINSEKI
General, United States Army
Official: Chief of Staff
0219703
DISTRIBUTION:
To be distributed in accordance with the initial distribution number (IDN) 362154 requirements for
TM 11-5820-890-30P-3.
PIN: 067490-000