[FOURTH AUSTRALASTAN CONFERENCE
Monash University, Melbourne, Australia
1971 Movenver 29 to Deoenber 3
[ENERGY LOSS 10 OPEN CHANNEL 90° BEND
‘mergy lose in open channel bend depends on several parsmeters such
erastee mmbery Froude mamnry ogghness’ eter" Ta thie paper the reguate
Sf O03 t/orratio withy various Reynolae munber, Froude fmber and Manning's
hy nave Been presented: Zt hae boon established that Froude. similitude 10
Senter Rengareh Aneistant, civit and Wydrautte Ing. Dept.» In
Professor, Civil and Hydraulic Engg. Dept., Indian Institute of Science,
Bengalore’ 12, Indiney Lats en un 0° "HANOMYESUARA SEETHARAMA
vorarz0¥ ca
b= widen of the fisme Ry + Reynolds mmbor
yz Froude umber Yan Sy = bed slope
«
“y+ Kinmatio viseostty
6
Sten saeco a acento Se om ciated
ee marae eee eee tee |
wor@y (&) is defined ae the ratio of the vend loss (hyp) te the velocity
i ceciee ate cee acee celia
we @)
Boussineng (1877) C4] wae the fires to attomt to ostinate she tone
mer and Urick Civ3-t4) Cig) sagewated. 20
Seaver [6,71 20
See eaeiseail
correlated with Froude mmber, Rayncidva number, yq/0 satio for aifferent
Nenning*= ns
rectangtiar cross-section with a 90° sireuisr bond with r/o = 0.5 ondeeributton fe the 9 ‘bea for getting Toveh=
ean: Hirst corresponding vaine of Manning's vas Getersined, “'Ratis of
¥4/P covered during the investigation was 0:205 74/0 = 1-03.
‘Typical non-dinensionlined saovels at different sections are shown in
Big. 2.7 The woivetty measured 4n 90° and 60° section represents the component
Secuered sivaye away from the
depen wee net mininums msds
conrrscrmr oF Lass oF exexor ($)
‘Tale has been determined by
is SE er hceae ea ete hog rt
coat tain ns Rennie year.
CSL) RSE Dimer ae Ste rn
"ine cowfeictent of
gartelt ange” tn" taen” Enron
BIRD Us tusgumeaaal enema
ee eaa hoe ee eae
yement with "2 results @xcept that the value of
ee
Froude musber sinilarity te very important in open channel. Previous
Anyestigntgee except Hayat £3] 64a nat cesveiate the’ conftiotent of i
Sf Tene of enerey” should sieo te eapeotad to be difterent in grosettioe!t
Siniler medal.” {1°ie sntorenting to note thst tne coorticiont of lose of
‘sn Prove mmber for '«. given Reynolds ‘mimbor
jefficient of loss of energy increased with increase in
Froude munber Zor she sane range of Reynolds. nombe! and for a given rouphnes
‘Thin Goafisient 18 very high at higher Froude muaber,. This {2 de tothe
By careful comparison of the Fes. 3,l,5 reveal hat the coefficient of
tose of onerey inereasen ae the valve of & incrennes for A given Froute, mbar
* Wien the Froude mmbor covered in the upstream (section A) te greeter than
cute: duo to conatrievion of flav arte) She aydsealse haap casera’
sacre, m cooure