Você está na página 1de 7
HADP-SKVA Dry-type Test Transformer Console User Manual Himalayal Corporction Limited @hHimalayai” WWW.HIMALAYAL.COM.: 1. Overview This product matches with the HV test transfarmer. It has the advantages of superior performance, many functions, small volume, light weight, reliable use, beautiful appearance, convenient operation and mainteance etc. 2. Structure and Panel Layout The structure of equipment is cabinet type the cabinet body is aluminum alloy chassis; all electrical components are installed on the skeleton; the panel has a power cable; itis easy to install and maintzin. ‘The alarm device has a simple circuit and reliasle performance, and has the functions of timing, sound and light synchronization alarning. The layout of panel is given below and the etectrical diagram is attached in the last page. 7.2621 6101 sy Your side. Copy fight’® HIMALAYA info@himalayal.com Page" All ight @himalayai" 3. Working Conditions © Temperature: 0°C-40'C © Altitude < 100m © Relative temperature < 85% © The workplace should be free of gases, steam, chemical dust and other explosive and erosive media that seriously affect insulation. 4. Operating Instructions (2) Connect the console, test transformer and test object well according to the test requirements. (2) Set the action values of overcurrent relay(-KA) and time relay (-KT) according to the current and withstand voltage time required by the test object in the normal test. (3) Plug in and rotate the hand wheel of voltage regulator to the zero position; the green light (-HG) is on. That means you ian perform test operations. Do not approach the test transformer in case of danger. (4) Press the start button (-ST); the primary circuit (-KM) pulls-in; the voltage regulator receives the power. Turn the hand wieel of voltage regulator clockwise and the voltage Increases. At this time, the zero Ight (-HY) is off; the working indication light (-HR) is on. Closely watch the voltmeter (-PV); when increases to the specified withstand voltage value of test object, press the timer button [-ST2) and pay daUteriuiun w Ue West object (5) When the timing is due, the operating ccbinet sounds the alarm automatically Turn the hand wheel of voltage regulator counterclockwise immediately to the zero position; press the stop button (-SP) and timer button (-ST2). The red light is off and the yellow light is on. The test is over. (6) If the short circuit, flashover end breakdown occurs during the voltage increase or withstand process, the overcurrent relay sperates to cut off the circuit. At this time, turn the voltage regulator counterclockwise immediately to the zero position. Notes: Slowly and evenly increase the voltage; quickly decrease the voltage; do not plug off directly to avoid the overvoltage andcause damage to the equipment. 5. Cautions ®@ Check whether the equipment is damagec in transit after unpacking. @ After a period of use, check that electrical components are in good conditions, especially the voltage regulator brush. © Please read the instructions carefully befere use and strictly follow the operating instructions to operate the equipment © If the equipment is idle for a long time, please use the 2500V megger to measure the main circuit to ground insulation resstance before reuse. The value should not be less than 1.5MQ. © The equipment should be stored at a vell-ventilated, dry and non-corrosive yal, always by your side. Cony rs Page 5

Você também pode gostar