Escolar Documentos
Profissional Documentos
Cultura Documentos
Automotive
Full Range Speaker System
T 5 9 5 L i m i t e d O w n e r ’ s M a n ua l
02
Downloaded from www.dlmanuals.com
A Note on Power Handling
As a result of their high efficiency, all JBL
loudspeakers will produce reasonable vol-
ume levels in the automotive environment
using very little amplifier power. However,
the use of a small amplifier to attain very
high volume levels could lead to over-dri-
ving the amplifier. This will generate high
distortion levels which can easily damage
loudspeakers, even if the rated power of
the amplifier is below the rated maximum
power handling of the loudspeaker!
Hi-Pass Electronic Lo-Pass As a general rule, do not turn up the vol-
Crossover ume control past the point where you
hear distortion in the form of either signal
Amp for Amp for distortion from an overdriven amplifier or
Tweeters Woofers mechanical noise from an overstressed
f > 1.5kHz f < 1.5kHz speaker.
Left Right For the best performance and system reli-
ability, you should select an amplifier with
an output rating greater than the maxi-
mum power likely to be used to generate
Removing bi-amplification jumpers. the desired volume levels.
Your JBL dealer will be able to recom-
Bi-amplification: The T595 Limited speak- mend which JBL amplifiers are best for
ers are equipped with two sets of speaker your application and listening habits.
T595 terminals connected by short jumper Following these guidelines will provide
Tweeters strips. If you wish to power your loud- sound reproduction free from audible dis-
speaker system with two amplifiers you tortion and help ensure years of listening
must separate the two sets of speaker ter- pleasure.
minals. By clipping the jumper wires, the
T595 high-frequency input will be separated WARNING: Playing loud music over
Woofers from the low-frequency input and the 120dB can permanently damage your
Left Right loudspeaker system will be ready for bi- hearing. The maximum volume levels
Channel Channel amplification. (See diagram.) It is recom- achievable with JBL components and
mended that the factory 1500Hz crossover high power amplification may exceed
point be the lowest used with the high- safe levels for extended listening. When
T595 Limited in bi-amplified configuration frequency drivers of the T595 Limited listening at high volume levels, always
connected to a dedicated high-frequency (>1500Hz) speakers. The slope of any external use hearing protection or turn the volume
and a dedicated low-frequency (<1500Hz) amplifier. crossover should be 12dB per octave or down!
greater.
03
Downloaded from www.dlmanuals.com
Specifications
Component Systems
CEL
6"x 9" 3-way high-performance cast frame automotive speaker
NG
Speaker Impedance 4 Ohms
S
0
5
YEAR
Recommended Amplifier Power Range 10 – 150 Watts RMS
Frequency Response 35Hz – 22kHz
Sensitivity 94dB
Mounting Depth
Drop In: 3-5/8" (93mm)
Bottom Mount: 4-5/8" (118mm)
Mounting Cutout Diameter: Universal 6"x 9" (152mm x 229mm)
DECLARATION
DeclarationOF CONFORMITY
of Conformity
We,JBL
We, JBLEurope
Europe A/S
A/S
Kongevejen
Kongevejen 194B
194B
DK-3460
DK-3460 Birkerød
Birkerød
DENMARK
DENMARK
declare inown
declare in ownresponsibility,
responsibility, thatproducts
that the this described
loudspeaker
in this owner’s conforms
manual are to all the relevant
in compliance with technical
standards
standards: in EMC Directive (89/336/EEC).
JBL Consumer Products EN 50 081-1/1992
80 Crossways Park West EN 50 082-1/3.1995
Woodbury, NY 11797
800-336-4JBL (4525)
A Harman International Company Steen Michaelsen
JBL Europe A/S
Part No. 333406-001 Birkerød. DENMARK. 3/97
Made in USA