Escolar Documentos
Profissional Documentos
Cultura Documentos
X4 X5 X6 X7
10/100/act
• Standard power cord
on / act 1000/act
ss lan wan
W0 X0 X1 X2 X3 X4 X5 X6 X7
W0 X0 X1 X2 X3
1000
X4 X5 X6 X7
SonicWALL TZ500 W security 10/100/act
SonicWALL TZ500 W security 10/100/act
on / act 1000/act
on / act 1000/act
console X7 X6 X5 X4 X3 X2 X1 X0
Power Supply
Console Port Provides power to
the Dell SonicWALL
Access the SonicOS Command X2 - X7 Ports X1 Port appliance
Line Interface (CLI) using a For WAN access
compatible CLI cable Configurable ports
X0 Port
Reset Button
Press and hold for several CAUTION: Only use the included power adaptor
with this appliance. Do not use a power adaptor
For LAN access seconds to set the appliance
into Safe Mode
©
2015 Dell Inc. ALL RIGHTS RESERVED.
This guide contains proprietary information protected by copyright. The software described in this guide
3 Connect the interfaces TIP: Your computer should be using DHCP IP • Enter the TZ appliance administrator credentials
is furnished under a software license or nondisclosure agreement. This software may be used or copied
only in accordance with the terms of the applicable agreement. No part of this guide may be reproduced addressing. to change the password, if you wish. Click Next.
or transmitted in any form or by any means, electronic or mechanical, including photocopying and
recording for any purpose other than the purchaser’s personal use without the written permission of Dell • Connect the WAN interface (X1) to your Internet
Inc.
The information in this document is provided in connection with Dell products. No license, express or
connection using a standard Ethernet cable. • Click on the link in “To launch the Dell SonicWALL NOTE: The default administrator credentials are
implied, by estoppel or otherwise, to any intellectual property right is granted by this document or in
connection with the sale of Dell products. EXCEPT AS SET FORTH IN THE TERMS AND CONDITIONS AS
Setup Wizard, click here.” Username: admin Password: password
SPECIFIED IN THE LICENSE AGREEMENT FOR THIS PRODUCT, DELL ASSUMES NO LIABILITY WHATSOEVER
AND DISCLAIMS ANY EXPRESS, IMPLIED OR STATUTORY WARRANTY RELATING TO ITS PRODUCTS
• Connect the LAN interface (X0) to your computer
INCLUDING, BUT NOT LIMITED TO, THE IMPLIED WARRANTY OF MERCHANTABILITY, FITNESS FOR A
PARTICULAR PURPOSE, OR NON-INFRINGEMENT. IN NO EVENT SHALL DELL BE LIABLE FOR ANY DIRECT,
using a standard Ethernet cable. • The automatic WAN IP settings are displayed.
INDIRECT, CONSEQUENTIAL, PUNITIVE, SPECIAL OR INCIDENTAL DAMAGES (INCLUDING, WITHOUT
LIMITATION, DAMAGES FOR LOSS OF PROFITS, BUSINESS INTERRUPTION OR LOSS OF INFORMATION) Click Next.
ARISING OUT OF THE USE OR INABILITY TO USE THIS DOCUMENT, EVEN IF DELL HAS BEEN ADVISED OF THE
POSSIBILITY OF SUCH DAMAGES. Dell makes no representations or warranties with respect to the
accuracy or completeness of the contents of this document and reserves the right to make changes to
specifications and product descriptions at any time without notice. Dell does not make any commitment
to update the information contained in this document.
If you have any questions regarding your potential use of this material, contact:
Dell Inc.
Attn: LEGAL Dept wan lan
5 Polaris Way
Aliso Viejo, CA 92656
X1 X0
Refer to our website (software.dell.com) for regional and international office information.
Internet
Patents
This product is protected by U.S. Patents. For more information, go to
• The SonicOS Startup Guide opens.
http://software.dell.com/legal/patents.aspx.
Trademarks
Dell, the Dell logo, and SonicWALL are trademarks of Dell Inc. Other trademarks and trade names may
be used in this document to refer to either the entities claiming the marks and names or their products.
Dell disclaims any proprietary interest in the marks and names of others.
TZ500 / TZ500 W Quick Start Guide
Updated - August 2015
232-002915-51 Rev A 4 Run the Setup Wizard
• Navigate to https://192.168.168.168 on your Web
browser.
http://192.168.168.168/
http://192.168.168.168/
NOTE: For manual configuration, refer to the latest
SonicOS Administration Guide.
• The new IP Configuration is displayed. Click Done.
Configuring Wireless LAN settings select the country code for the country in which the • Log in using your MySonicWALL account name and 6 Get the latest firmware
appliance will be deployed, even if you are not password. If you do not have a MySonicWALL
• Log in to your TZ appliance and click the Wizards currently in that country. account, click the Create MySonicWALL account • In a Web browser, navigate to
icon. link to create an account. http://www.mysonicwall.com
• Select the radio button for the Wireless Guide IMPORTANT: If you select the country code for
Canada, it cannot be changed except by contacting • Click Downloads and select TZ500 or TZ500 W
wizard.
Dell SonicWALL Support. Firmware from the Software Type menu.
• Click the link for the firmware you want and save
5 Register product the file to a location on your computer.
• Point your browser to the appliance LAN IP • On the TZ appliance, navigate to the
address (default https://192.168.168.168) and log System > Settings page. Click the Upload New
in using the administrator credentials. Firmware button.
• Click Register on the System > Status page under • Click the Browse button to navigate to and select
Security Services. • MySonicWALL directly obtains the necessary the firmware you just downloaded, then click
information from the TZ appliance. When Upload.
finished, you will see a message that registration
has been completed. Click Continue.
• Click Next and follow the prompts in the Wireless
Guide wizard. For more information and complete
procedures, refer to the latest SonicOS
Administration Guide.
For international (non USA or Japan) TZ Wireless
appliances, you are asked to select a country code TIP: Registering the appliance from SonicOS
when using the Wireless Guide or when you initially requires that DNS Server settings are configured on NOTE: Your appliance must be registered to
navigate to the Wireless > Settings page. Be sure to the WAN (X1) interface. download the latest firmware. • Click the Boot icon for your new firmware.
7 Mounting the TZ appliance Safety and regulatory Declaration of conformity Informationen zur stromversorgung
Wenn die Stromversorgung von der Dell-Produktpaket fehlt, wenden Dell den Technischen Support unter
information
A Declaration of Conformity in accordance with the directives and standards has A “Declaration of
WARNING: Do not mount the appliance on the Conformity” in accordance with the directives and standards has been made and is on file at Dell Products
Europe BV, Limerick, Ireland.
https://support.software.dell.com/manage-service-request.
Dieses Produkt sollte nur mit einem für den Europäischen Markt genehmigten Netzteil mit dem Logo "I.T.E.
ceiling, it is not designed for secure ceiling WARNING: For your safety, follow all instructions listed in this
CE declarations can be found online at www.dell.com. LPS" und einer Ausgangsleistung von12 VDC, mind. 3.0 A, Tma: mind. 40 Grad C, betrieben werden.
mounting. section. NOTE: Additional regulatory notifications and information for this product can be found online at:
https://support.software.dell.com/
To mount the appliance on the wall: Lithium battery warning Dieses Gerät ist nicht zur Verwendung an Arbeitsplätzen mit visuellen Anzeigegeräten gemäß § 2 der
deutschen Verordnung für Arbeitsplätze mit visuellen Anzeigegeräten vorgesehen. Um störende
Reflexionen am Bildshirmarbeitsplatz zu vermeiden, darf dieses Produkt nicht im unmittelbaren
Gesichtsfeld platziert verden.
The Lithium Battery used in the Dell SonicWALL security appliance may not be replaced by the user. Return
1 Drill two holes 5.7 inches (14.5 cm) apart in the the Dell SonicWALL security appliance to a Dell SonicWALL-authorized service center for replacement with
the same or equivalent type recommended by the manufacturer. If, for any reason, the battery or Dell
wall where you want to mount the appliance. SonicWALL security appliance must be disposed of, do so following the battery manufacturer's instructions.
Verwarnung hinweis zur lithiumbatterie
2 If using wall anchors, insert a wall anchor into Die in der Internet Security Appliance von Dell verwendete Lithiumbatterie darf nicht vom Benutzer
each hole. Cable connections ausgetauscht werden. Zum Austauschen der Batterie muss die Dell in ein von Dell autorisiertes Service-
Center gebracht werden. Dort wird die Batterie durch denselben oder entsprechenden, vom Hersteller
3 Insert a screw into each wall anchor (into each All Ethernet and RS232 (Console) cables are designed for intra-building connection to other equipment. Do
empfohlenen Batterietyp ersetzt. Beachten Sie bei einer Entsorgung der Batterie oder der Dell Internet
Security Appliance die diesbezüglichen Anweisungen des Herstellers.
hole if not using wall anchors), leaving 3/16 not connect these ports directly to communication wiring or other wiring that exits the building where the
Dell SonicWALL appliance is located.
inches (0.45 cm) of the screws exposed (including Verwarnung kabelverbindungen
screw head).
4 Position the appliance mounting slots over the Power supply information Alle Ethernet- und RS232-C-Kabel eignen sich für die Verbindung von Geräten in Innenräumen. Schließen
Sie an die Anschlüsse der Dell keine Kabel an, die aus dem Gebäude herausgeführt werden, in dem sich das
screws and press in and down until the appliance If the power supply is missing from your Dell SonicWALL product package, please contact Dell SonicWALL
Gerät befindet.