Escolar Documentos
Profissional Documentos
Cultura Documentos
Instructions: This paper consists of FIVE (5) questions. Answer any FOUR (4) questions in the
answer booklet provided. All questions carry equal marks.
Question 1
(c) Evaluate the line integral ∫𝐶 𝑭. 𝑑𝒓 for 𝑭(𝑥, 𝑦) = 𝑥 2 𝒊 − (𝑥 + 𝑦)𝒋 , over the curve
𝑪: 𝑥 2 + 𝑦 2 = 9, 𝑦 ≥ 0 from (3,0) to (-3,0).
(10 marks)
Question 2
(b) Verify Green’s theorem for 𝑭(𝑥, 𝑦) = (𝑥𝑦)𝒊 + (𝑥𝑦 2 − 𝑒 𝑦 )𝒋 over region R which is a
triangle with vertices (0, 0), (3, 0) and (0, 5).
(20 marks)
MAT 3202(F) /Page 2 of 4
Question 3
1
(a) Given the complex function 𝑓(𝑧) = 𝑧 2 (1−𝑧 2 ) ,
Question 4
(a) Using the power method and four iterations, find the dominant eigenvalue and the
4 0 1
corresponding eigenvector for the matrix [−2 1 0]. Perform all calculations correct to
−2 0 1
three decimal places.
(5 marks)
(b) Using Euler’s method, compute an estimate for 𝑦(1.0) for the initial value problem
𝑑𝑦
= 𝑦 2 𝑒 𝑥𝑦 , 𝑦(0.5) = 0.5.
𝑑𝑥
Use a step size of 0.1 and perform all calculations correct to four decimal places.
(5 marks)
(c) A machine that can run at different speeds produces bearings, of which certain number are
defective. The number of defective items produced per hour depends upon the speed of the
machine (in revolutions per second, rev/s). Data collected for eight different speeds is
shown below.
(i) Let x represent the speed and y represent the number of defectives. Calculate the
means, 𝑥̅ and 𝑦̅.
(3 marks)
(ii) Copy and complete the following table.
x y (𝒙 − 𝒙
̅) (𝒚 − 𝒚
̅) ̅) 𝟐
(𝒙 − 𝒙 ̅ )𝟐
(𝒚 − 𝒚 (𝒙 − 𝒙
̅)(𝒚 − 𝒚
̅)
8 7
9 12
10 13
11 13
12 13
13 16
14 14
15 18
(5 marks)
(iii) Using the values in the table in part (ii) above, calculate the value of the product
moment correlation coefficient and interpret it.
(5 marks)
(iv) Then, calculate the value of the coefficient of determination and interpret it.
(2 marks)
Question 5
(a) An electrical component is made up of two independent circuits, 𝐶1 and 𝐶2 which are
designed to last for a year. In the past, circuit 𝐶1 has 95% chance of lasting for a year while
circuit 𝐶2 has 96% chance of lasting for a year. The electrical component will work as long
as one of the circuits is still working. Find the probability that at the end of a year
(b) (i) The volume of contents of bottles in a production line is normally distributed with
a mean of 500 ml and a standard deviation of 2.5 ml. Bottles are to be refilled if the
volume is less than 495 ml. If the production level on a particular day is 1000
bottles, what is the expected number of bottles to be refilled that day?
(3 marks)
(ii) The length of steel rods produced by a machine is normally distributed with a
standard deviation of 0.8 cm. It is found that 1% of the same type of steel rods are
less than 24 cm long. Calculate the mean length of all the steel rods produced.
(5 marks)
MAT 3202(F) /Page 4 of 4
(c) A sample of fifty lenses yields a mean thickness of 3.05 mm and a standard deviation of
0.34 mm. The desired mean thickness of the lenses is 3.20 mm.
--THE END--
MAT3202/(F)/Aug2017/SarasKrishnan/10112017