Escolar Documentos
Profissional Documentos
Cultura Documentos
SOLUTION
TORNADO
SOLUTIONS :
At equilibrium:
dm g
dP = − dF / A = − = − ρ g dz (1)
A
RT MA
PV = n RT and P=ρ or ρ=P (2)
MA RT
1
C. SOLUTION
where MA = 0.0290 kg/mol, is the molar mass of the air. Now we have:
dP g MA
=− dz (3)
P RT
−α z g MA
P( z ) = P0 , with α= (4)
RT0
(b) Now the temperature varies with altitude: T = T0 − b z . Eq. (3) becomes :
P dP g M A z dz P g M A T0 − b z
∫ P0 P
=−
R ∫0 T0 − b z
, which gives: ln
P0
=−
bR
ln
T0
(5)
Finally:
g MA
−
bz bR
P ( z ) = P0 1 − (6)
T0
(9.8) (0.029)
−
(6.5e − 3)(1e3) (6.5 E −3)(8.314)
PB = 1e5 1 − = 8.87 ×104 Pa (7)
288
Thus the pressure is lower by 11.3% at the base of the cumulonimbus cloud compared to the ground.
(a) Because point G is in the isobar boundary layer we have: PG = PB. Using Bernoulli’s equation at
point A and G, and assuming constant air mass density :
2 2
PA + 12 ρ v A + ρ g z A = PG + 12 ρ vG + ρ g zG (8)
2( PA − PB ) 2(1e5 − 0.887e5)
vG = = = 137 m/s (9)
ρ 1.2
which is within the range of speed for a deadly tornado (v ~ 100 m/s).
2
C. SOLUTION
(b) Due to conservation of angular momentum we have (using point G as a reference or any point P at
altitude z) :
m vC rC = m vG rG = m v r (10)
Thus:
v r
v( r ) = G G (11)
r
(c) Consider point P along the boundary between region I and II as shown above. This boundary layer
is also an isobar boundary layer thus PP = PG. We have:
2 2
PG + 12 ρ vG + ρ g zG = PP + 12 ρ vP + ρ g z (12)
2 2
vG = vP + 2 g z (13)
From part (b) we have: v( r ) = vG rG / r . Note that v is only a function of r not altitude z as stated in the
problem. Thus we have:
v
2
rG 2
z= G 1 − (14)
2g r
Alternatively we can express the tornado shape as a function of radius versus altitude below and plot it
in Figure 3 below.
3
C. SOLUTION
r 1
= (15)
rG 2g z
1− 2
vG
As we can see, in comparison with a real life tornado picture, this equation describe the general feature
of tornado shape remarkably well despite a very simple model.
Figure 3. (a) The tornado shape function for two speeds with h = 1 km. The higher the speed the more pipe-
like it looks like. (b) A real life tornado for comparison (Valparaiso, Nebraska, US, 2001).
2
(d) Higher speed will make the term 2 g z / vG in Eq. (15) smaller, thus r becomes a weaker function
of z, in other words the tornado shape becomes more uniform or pipe-like. This is also illustrated
in Figure 3(a).
(a) Consider a parcel of air rotating around the tornado as shown below:
The differential pressure exerts the centrifugal force to the air parcel:
4
C. SOLUTION
ΣF = m v 2 / r , or: dP A = ρ A dr v 2 / r (16)
Thus we have:
∂P ρ v 2
= (17)
∂r r
(b) Because the core is approximated as a rigid body, the angular velocity is constant everywhere
inside the core, given as: ω = vC / rC . Thus the velocity at any point inside the tornado:
vC r
v = ωr = (18)
rC
So unlike in region I, in the core (region II) the velocity is proportional to the radius. The overall
tangential velocity profile is given below:
Figure 5. The tangential velocity profile of the tornado showing clear difference between region I and II.
Note that this model is in reasonably good qualitative agreement with an actual tornado
measurement as shown below:
Figure 6. An actual tangential velocity profile of a tornado (Dallas, TX, 2 April 1957) [1].
(c) The pressure inside the tornado can be calculated with respect to a far away reference point on the
ground where P = P0 and using point G as a reference:
5
C. SOLUTION
∞ rG 2 ∞ 2 2
vG r v r
P0 − PT = ∫ ρ v / r = ρ ∫
2
2
dr + ρ ∫ G 3G dr (19)
0 0 rG rG
r
rC
2 2 12 2
P0 − PT = ρ vG
1
2 + ρ vG rG 2
1
2 = ρ vG (20)
r ∞
2
PT = P0 − ρ vG (21)
PV γ = C1 , and PV = n RT (23)
P1−γ T γ = C2 (24)
where γ is the heat capacity ratio which is for air : γ = 1.4.
Assuming a far away point with pressure P0 and temperature T0, the temperature at the core of tornado
TT is:
γ −1 0.4
P γ
77,477 1.4
TT = T0 T = 288 × = 268 K = -5 °C (25)
P0 1e5
(e) Such a low temperature will cause condensation of moisture that get sucked into the tornado core,
and the condensation will release latent heat. Multiplied by massive influx of air mass to the
tornado –this latent heat could provide the tremendous energy for the tornado.
(a) We assume that the house is tightly enclosed maintaining the initial pressure at P0. When the
tornado approaches at a distance d = 2 rC from the house, the differential pressure will be (Eq. 19):
6
C. SOLUTION
∞ 2 2
v r
∫2 r Gr 3G dr = 18 ρ vG = 18 ×1.2 ×137 = 2,815 Pa
2 2
∆P = P0 − PX = ρ (26)
G
F ∆P A ∆P 2815
= = = = 3.6 (27)
W At ρ Roof g ρ Roof g t 800 × 9.8 × 0.1
(b) The lift force is not much larger than the weight of the roof – and certainly most roof are mounted
firmly to withstand forces multiple of its weight. So chances are the tornado pressure differential
would not cause the house to explode so soon (unless the roof is very poorly mounted, or you are
inside the tornado in which case this question becomes irrelevant).
Furthermore some residual opening in the house like ventilation and chimney will alleviate the
pressure differential. However at a very close distance of 2 rG. it is more likely the house get
smashed with flying debris. Thus you would just close all the windows.
REFERENCES
[1] W.H. Hoecker, “Wind speed and air flow patterns in the Dallas tornado of April 2, 1957”,
Mon. Wea. Rev. 88, 167-180.