Escolar Documentos
Profissional Documentos
Cultura Documentos
TEST 1
SEMESTER I
SESSION 2018/2019
PROGRAMME : BDD
DURATION : 1 ½ HOURS
CONFIDENTIAL
Q1 (a) What are the TWO (2) types of gear train and describe three practical applications
of compound gear train. (5 marks)
(b) Figure Q1 shows a motor accelerating a hoist of diameter 0.9m, through two sets of
gear reducing system. Gear ratio for gear 1 and 2 is 1/3.5 while for gear 3 and 4 is 1/
4.5. Moment of inertia for the motor shaft is 5 kgm 2, middle shaft is 20 kgm2 and
hoist shaft is 100 kgm2. The rope that is encircled on the hoist must be capable to lift
up a load of 5 tones that is sliding on a 1 in 50 slope. Friction on the slope is 1000N
and the total torque at motor required to raise the load is 1500N. Use gear efficiency
of 90% for both gear set. If there is friction torque effect on the middle shaft,
T X 150 Nm and at hoist shaft is T y 800 Nm.
(b) Following are the details of a crossed belt drive. Determine the length of the belt.
(c) A flat rubber belt is used to drive a dynamo generating 20 kW power at 2250 rpm. It
is fitted with a 200 mm diameter pulley. The design data for the belt drive system is
as below;
Allowablle stress for belt = 2.3 MPa
Density of rubber belt = 90 kg/m3
Angle of contact for dynamo pulley = 160°
Coefficient of friction between belt & pulley = 0.3
Thickness of rubber belt = 10 mm
2
CONFIDENTIAL
CONFIDENTIAL BDA20303
- END OF QUESTION –
TEST 1
SEMESTER/SESSION : I/2018/2019 PROGRAMME : BDD
COURSE : MECHANICS OF MACHINE COURSE CODE : BDA 20303
Figure Q1
Figure Q1
3
CONFIDENTIAL