Owner's Manual Open Oil Cap (Positive pressure? Gasket leak) Check coolant reserve (bubbling? Gasket leak) GENERAL INFO Smoke (Water, Blue, White, Black?) Model Rev (Unusual sound? Smoke?) Odometer Check leaks again Price Rad fan (auto on/off?) RFS Modification, Replacement ELECTRICAL (Start Condition) Any issue Battery (check on stop condition) Gamit ng sasakyan, km per liter? Alternator (14VDC) magkano nabili? Lights (front rear) Dome, Cluster, sensors, panel, radio BODY (Bangga) Alarm, wiper, horn Rust, Scratch, Masilya, Welding (chassis, frame & rad) Fuel Pump (hissing?), check leak Check engine bay, inspect frame straight Check trunk, inspect frame straight A/C (Stop and Start) Under board, chassis Compressor Fender, Hood, Doors, Windshield, Bumper RPM Seat Belt, Chair, Floor, trimmings Temperature Switches SUSPENSION (Stop Condition) Shock Absorber (1 bounce) STEERING (Start Condition) Ball Joint, Strut, Coil (Rust and Leaks) Hard steering? Tire Life (Good?) Alignment of left and right wheel All 4 tire same? Check wheel support again Check Alignment TRANSAXLE (Start condition) BRAKE (Start and Stop) Smooth shifting Brake fluid (actual lvl o top up?) Shifter knob (Maalog) Booster/Master Cylinder (oil leak?) Shifting cable (Check below) hard braking? hand brake CLUTCH Wheel Support 3rd Gear Starting, good?
ENGINE (Stop Condition) IMPORTANT:
Oil leak (gasket, oil cap, shaft, transmission) Check for the following before and after start: Dipstick, good? No grit? Light? Engine Mounts Engine Oil Cap, no foam? Check inside Foams Coolant (cap,reserve)(no oil, no foam, not pure h20) Bubbling Belt (not shinny, tight, no cracks) Leaks Engine Support (stop and start) Smoke Pedal Wear Intake, Exhaust Manifold, Muffler (damage)