Escolar Documentos
Profissional Documentos
Cultura Documentos
i01494879
Varistor - Test
SMCS - 4466-081
View Image
Illustration 1 g00677004
PMPE Generator Wiring Diagram
(CR1-CR6) Diodes
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/med... 14/05/2010
Service Information System Página 2 de 3
(CR7) Varistor
Ohmmeter
An ohmmeter can be used to check a varistor (CR7). Place an ohmmeter across the varistor. The
resistance should be a minimum of 15000 ohms. If the resistance is less than 15000 ohms, the
varistor is faulty.
Test Light
View Image
Illustration 2 g00555113
Test Light
Refer to the test light that is shown in Illustration 2. Follow these steps in order to test the varistor:
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/med... 14/05/2010
Service Information System Página 3 de 3
If the test light illuminates in either direction, there is a short in the varistor. Replace any faulty
varistors with varistors that have comparable operating characteristics. Include the following
information when a varistor is being ordered for replacement:
After the varistor has been replaced, verify that the strapping of the field winding lead is securely
wound on the shaft. Also, verify that the strapping of the field winding lead is securely tied.
Copyright 1993 - 2010 Caterpillar Inc. Fri May 14 13:48:08 UTC-0300 2010
All Rights Reserved.
Private Network For SIS Licensees.
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/med... 14/05/2010