Escolar Documentos
Profissional Documentos
Cultura Documentos
****************************************************************
DEPARTMENT ELECTRONICS AND COMMUNICATION ENGINEERING
2. The contents of different registers are given below. Find out the physical address for
different addressing mode.
Interrupts:
6. Discuss the Interrupt structure of 8086
a) Types of interrupts
b) Interrupt response sequence with diagrams and flow chart
c) Structure interrupt vector table
d) Explain the INT 0 and INT 3 interrupts in 8086
Evolution of 8086:
7. Explain the following about the evolution of microprocessor
a) List out the important features of 4004, 8085,8086,80386
b) Give the main differences/ advancements in the evolution of the processors
Programs:
8. Develop a 8086 assembly language programs with CPU running at 5MHz
a) To generate a delay of 100ms
b) To generate a delay of 10 minutes.
c) Give the delay formulae and calculations
Interfacing:
12. Design a 4 way Traffic light system with 8086 using the following specification
a. Identify the components required for the application
b. Give the Design (Block diagram and schematic diagrams)
c. Develop the program using 8086 assembly language
d. Show the Simulation output using simulation tool
13. Design a 4 stair Elevator control system with 8086 using the following specification
a. Identify the components required for the application
b. Give the Design (Block diagram and schematic diagrams)
c. Develop the program using 8086 assembly language
d. Show the output using Kit/ simulation tool
14. Design a Sinusoidal signal wave form generator with 8086and DAC using the
following specification
a. Identify the components required for the application
b. Give the Design (Block diagram and schematic diagrams)
c. Develop the program using 8086 assembly language
d. Show the output using Kit/ simulation tool
15. Design the LED blinking interfacing with 8086 using the following specification
a. Identify the components required for the application
b. Give the Design (Block diagram and schematic diagrams)
c. Develop the program using 8086 assembly language
d. Show the Show the output using Kit/ simulation tool
16. Design the stepper motor interfacing with 8086 using the following specification
a. Identify the components required for the application
b. Give the Design (Block diagram and schematic diagrams)
c. Develop the program using 8086 assembly language
d. Show the output using Kit/ simulation tool