Escolar Documentos
Profissional Documentos
Cultura Documentos
_______________________________________________________________
Interpretation: 09-1
Record: 09-517
Question: Does the hub slope have the limitation of 18 degree max. (1:3)
for Fig. 1 of B16.47-2006?
Reply: No.
_______________________________________________________________
Interpretation: 08-1
Record: 07-657
Reply: No.
________________________________________________________________
Subject: B16.47-1996
Record: 06-1180
Reply: Yes.
Interpretation: 3-1
File: B16-98-002
Reply (1): the figures for Tables 13, 14 and 15 will be corrected as errata
in the next addenda. (Note: This was corrected in ASME B16.47a-1998.)
Question (2): In ASME B16.47-1996 are the 150 and 300 Class flanges
that are referred to in paragraph 6.1.1.1 required to have 0.25 inch raised face?
File: B16-96-013
Reply: Yes, within the restriction of General Note (b) of Table 1A.
________________________________________________________________
Interpretation: 1-1
File: B16-95-07
Question (1): Does B16.47-1990 require dual taper hubs as shown in Figs.
1 and 2?
Reply (1): No. See para. 6.4 and Note (3) to Figs 1 and 2.
Reply (2): No. B16.47 does not address where to measure dimension “A.”
________________________________________________________________