Escolar Documentos
Profissional Documentos
Cultura Documentos
Table of Contents:
6 TROUBLESHOOTING .......................................................................................2
6.1 General .............................................................................................................2
6.2 Electric Equipment ............................................................................................3
Aker Pusnes AS
Page 1 of 3
CONFIDENTIAL
SHOULD NOT BE DISTRIBUTED AND / OR BE MADE AVAILABLE TO THIRD PARTIES WITHOUT OUR WRITTEN CONSENT
Doc. Type: Issued by/Date:
Doc. No.: Rev by/Date:
Rev. No.: 00
Title: TROUBLESHOOTING
Rev. Date: 06 Nov. 08
6 TROUBLESHOOTING
6.1 General
In general, see scheme: Faults and their effects on the electric systems.
The following table deals with repeated customer problems, and is based on our
experience with mooring operations.
Aker Pusnes AS
Page 2 of 3
CONFIDENTIAL
SHOULD NOT BE DISTRIBUTED AND / OR BE MADE AVAILABLE TO THIRD PARTIES WITHOUT OUR WRITTEN CONSENT
Doc. Type: Issued by/Date:
Doc. No.: Rev by/Date:
Rev. No.: 00
Title: TROUBLESHOOTING
Rev. Date: 06 Nov. 08
B Insufficient 1 If running in 3rd step and tension pull is over 1 Check that the control pedestal shows
50% the speed is reduced to 2nd step (For correct operation mode.
speed mooring only).
speed 2 Check if there is a signal from the load cell 2 Open loop from the load cell gives a
when pulling torque constant failure signal at the pedestal.
speed 3 Check input signal from manoeuvring 3 Check signal from manoeuvring joystick
joystick on control pedestal. on control pedestal.
speed 4 Check that the motor brake is released. 4
speed 8 Anchor is less than 5 meters from ship side 8 Gives blinking on the anchor lamp
torque 5 In mooring the torque is limited to 110% 5 Check indicating value on the pedestal.
torque 6 In anchor the torque is limited to 150% 6 Check indicating value on the pedestal.
torque 7 Check that the “Slip HUB” is not slipping,
ref. Chpt. 5.4.
Aker Pusnes AS
Page 3 of 3
CONFIDENTIAL
SHOULD NOT BE DISTRIBUTED AND / OR BE MADE AVAILABLE TO THIRD PARTIES WITHOUT OUR WRITTEN CONSENT