Pump characteristic curve flow rate is between 75.1 to 450.
2 m3/ hr and maximum head is
1395m3/hr. However The portion intended for replacement is delivering approximately 800m3/hr.of white petroleum product i.e. Automotive Gas Oil, Motor spirit Premium and Dual Purpose Kerosene. Pump characteristic curve is of which pump? From alignment sheet PS1 at 15 Km ,PS2 at 60Km,PS7 at 335 km,PS8 at 378 Km. which pump to be used for transportation of this line two portions. Kindly share the composition of the product H2S content etc. it should be available Please share the process conditions for each Product at Inlet & Outlet Points ,38-43 (Samburu Area) & 390-400 (Konza area) including flowrates, operating pressure, operating temperature, Product Characteristics, API Gravity, compositions, and environmental data. Any specific software to be use for surge analysis Valve chamber detail? Please share previous valve chamber selection philosophy Low point drain collection area?