Escolar Documentos
Profissional Documentos
Cultura Documentos
4. After beep, open the notepad at the accessory when the computer recognizes the
barcode reader.
5. Confirm a laser beam that is irradiated by pushing trigger switch of the barcode reader,
and read out the next barcode label by a laser.
<FN3>STIREV
6. Revision of firmware that was read out from the barcode will be shown at the note pad,
and confirm whether the display of revision is [NBRTEAAL].
If the display of revision is not [NBRTEAAL], because of firmware has not done to
update of firmware, please retry to update of firmware according to install manual of
firmware.
7. Mark a dot on the label by using permanent marker as the following picture after
confirmation
1/1