Você está na página 1de 3

EAPL

Model A1D1-X(60M) FRONT VIEW


FUNCTION
INSTRUCTION MANUAL
A1D1-X (60M) is an ON Delay Timer.
A1D1-X ON DELAY TIMER
www.eaplindia.com On Power application preset timing starts and at
the end of the timing 2C/O relay contacts
DIMENSIONS changes over and remain in this state till the
NOTE: ALL DIMENSION ARE IN MM
power is interrupted.

Terminal Details

A1, A2 : Source Voltage

15, 16, 18 : C, NC, NO

25, 26, 28 : C, NC, NO

Contact Rating
CONNECTIONS SIDE VIEW 5Amps@250V AC/28V DC Resistive Load

1. Terminal block
2. Slide switches for range selection
3. Relay status LED
4. Time Tuning Pot
5. Range viewing Window

DOC NO: OD RA XN 19000 0 REV NO. : 00 Dtd: 26/03/2014

Page 1 of 2
PROGRAMMING INSTRUCTION : CAUTION
TROUBLE ANALYSIS
 Select the range with the help of 2 slide  Do not change the time range & set
switches on the side panel. The selected time while the timer is in operation.  Unit not working.
range can be seen in the windows on the  Switch off the power while changing the Check power supply
front panel. time range and set time. (Rated supply should be applied).
 Set the required time by gently rotating the  Application of voltage other than the
Front pot with suitable screw driver. specified one will permanently damage
 Apply rated voltage across A1 and A2 the timer. CONTACT
terminals.  Do not forcibly rotate the pot. It will
 The LED glows and the time starts. damage the timer. Electronic Automation Pvt. Ltd
 After the set time the LED goes off and # 20, KHB Industrial area
relay contact changes from NC to NO. Yelahanka
 Relay contacts remains in same position, Bangalore -64
till power is interrupted. DISPOSITION
Ph : +91-80-28567561/2 /42802345
Once the product life is over, you may send
HINTS ON CORRECT USAGE back the unit to EAPL for disposition. Email : info@eaplindiamail.com
www.eaplindia.com
 Use proper gauge wires for connections.
 Ensure all terminals are tightly screwed.
 Source Voltage should not exceed
specified limits it will damage the unit
beyond repair.
 Adjust the positions of slide switches
and Pot to get desired time.

DOC NO: OD RA XN 19000 0 Dtd: 26/03/2014

Page 2 of 2
SIGN & DATE PREPARED: V.N.Sudhamani CHECKED: B.S.Sridevi APPROVED: Kalavati Shanbhag
24/03/2014 26/04/2014 26/03/2014

DOC NO: OD RA XN 19000 0 Dtd: 26/03/2014

Você também pode gostar