Escolar Documentos
Profissional Documentos
Cultura Documentos
RTTC Mysore 1
Broadband Modem Configuration
2 RTTC Mysore
Broadband Modem Configuration
Modem Configuration
Initially after setting up of the IP address , now the ADSL modem can be configured.
Generally the following parameters are being configured in the ADSL MODEM.
1) Use the value of VPI(Virtual Path Identifier) as ‘0’ (zero) and VCI(Virtual
Circuit Identifier) as ‘35’.
2) Enter the User name & Password pertaining to that subscriber as created at NIB.
3) Select ‘PPPOE’ in PPP settings.
4) Enable ‘ DNS’.
5) Select ‘LLC’ in encapsulation.
6) Enter Service name as ‘BSNL’ or ‘Dataone’ or any alphabetic characters.
1)Go to the Browser and type http://192.168.1.1 and enter. A dialog box appears as
follows. Type against User name - admin & against Password- admin and click OK.
RTTC Mysore 3
Broadband Modem Configuration
4 RTTC Mysore
Broadband Modem Configuration
4) Select PVC0
Select PPPOE button and the resulting page will appear as follows.
RTTC Mysore 5
Broadband Modem Configuration
7) Go to TOOLS.
Select System Settings.
Click SAVE & RESTART button.
Wait for 2 minutes till the device restarts.
Afterwards switch OFF & ON the modem.
Now the Modem configuration is over and is ready for installation at sub premises.
6 RTTC Mysore
Broadband Modem Configuration
Open Internet Explorer & Type http://192.168.1.1 in the Address Bar of the browser.
When prompted, enter the User Name and Password. The Default Username and
Password are
Username : admin
Password: admin
Click OK.
Click Basic settings and select CONNECTIONS. Here all the PVCs mentioned are in
Bridge modes. Now delete PVC-0 value and create a new entry as show below.
Now select Wan Type as PPPoE and type 0 & 35 against VPI & VCI respectively. Then
type the Username & password of the subscriber.
Now apply. Save the Changes by pressing Save All Button in left hand screen.
To reset the modem to factory default settings
RTTC Mysore 7
Broadband Modem Configuration
8 RTTC Mysore
Broadband Modem Configuration
The Home page will look as below. Select the SETUP Tab for configuring the Modem.
RTTC Mysore 9
Broadband Modem Configuration
Under SETUP Tab Select PVC-0 and Type PPPoE Check the options NAT and Firewall.
Then type the username and password. Type VPI = 0 and VCI =35 .Then check Set Rout
Apply the settings and Save and restart settings by navigating to TOOLS Tab.
The Screen will appear as below
10 RTTC Mysore