Escolar Documentos
Profissional Documentos
Cultura Documentos
(2) Consider an inductor that passes a current of 7.96 mA. What will be the value of
inductor when it is supplied with 50 V ac with a frequency of 10 kHz?
(A) 100 mH
(B) 10 mH
(C) 1 mH
(D) 1H.
ANSWER: 100 mH
(3) Let a source of 220V, 5Hz is connected to an electric bulb whose rating is 220 V.
Then, the bulb
(A) 3.18 mH
(B) 31.8 mH
(C) 15.9 mH
(D) 1.59 mH
ANSWER: 1.59 mH
ANSWER: The current through any one element less than the source current
(7) For the diagram shown below, under which of the following case the power
dissipated in R3 will increase?
(A) 2.54 A
(B) 5.08 A
(C) 1.27 A
(D) 10.26 A
View Answer / Hide Answer
ANSWER: 2.54 A
(A) 30.6 V
(B) 50.8 V
(C) 24.4 V
(D) 40.8 V
ANSWER: 50.8 V
(A) 50.5
(B) 45.5 V
(C) 39.1 V
(D) 31.9 V
ANSWER: 31.9 V
(A) 20.1°
(B) 40.1°
(C) 32.1°
(D) 28.1°
(13) From the options given below which one represents largest mmf?
(A) A 100-turn coil wound around a 30-cm cardboard core and passing a current of 0.75 A.
(B) A 20-turn coil wound around a 10 cm iron core and passing a current of 3 A
(C) A 60-turn coil wound around a 10 cm iron core and passing a current of 1 A
(D) None of the above
View Answer / Hide Answer
ANSWER: A 100-turn coil wound around a 30-cm cardboard core and passing a
current of 0.75 A.
(A) LCR-circuit
(B) LR-circuit
(C) Non-resistive circuit
(D) Resistive circuit
(15) R and L connected in series are to operate at frequencies in the range of 100 Hz,
600 Hz. Over this range it is required that the current lags the source voltage by at
least 30°. If R = 1000Ω, the appropriate value of L will be
(A) 9.2 H
(B) 0.92 H
(C) 9.2 mH
(D) 0.92 mH
ANSWER: 0.92 H
(16) For a series RC circuit, voltage across R is measured to be 4V and voltage across C
is measured to be 3 V. The ac source voltage must be
(A) 5 V
(B) 3 V
(C) 4 V
(D) 7 V
ANSWER: 5 V
The variation of impedance with frequency is shown in the figure with four zones marked as
P, Q, R and S.
(A) Q
(B) R
(C) S
(D) P
(A) Q
(B) R
(C) S
(D) P
ANSWER: S
(19) In an a.c. circuit, the minimum and maximum values of power factor are
ANSWER: 0 and 1
(20) At t = 0, when the switch is closed, the value of charging current will be
(A) 60 mA
(B) 20 mA
(C) 30 mA
(D) 120 mA
ANSWER: 60 mA
ANSWER: 12 K V/S
(22) When the capacitor voltage is 8 V, at what rate is the capacitor voltage increasing?
(A) 8 K V/S
(B) 4 K V/S
(C) 10 K V/S
(D) 6 K V/S
ANSWER: 4 K V/S
(A) 500 W
(B) 100 W
(C) 400 W
(D) 222 W
ANSWER: 222 W
ANSWER: Band-stop
(A) The strength of the magnetic field depends only on the distance from the wire.
(B) Flux lines do not intersect each other
(C) Magnetic flux lines cannot pass through all materials
(D) Flux lines begin at a point and terminate at some distance from the starting point.
(27) Consider a pure inductance. When an alternating emf is applied to it, its inductive
reactance is 10Ω. If the frequency of a.c. is doubled, the reactance will become
(A) 20Ω
(B) 10Ω
(C) 5Ω
(D) 15Ω
ANSWER: 20Ω
(A) R3
(B) R2
(C) R1
(D) All have the same resistance
ANSWER: R3
(A) R3
(B) R2
(C) R1
(D) All have the same resistance
ANSWER: R1
Consider a high pass filter having resistance R = 2 KΩ. The lowest input frequency to be
passed is 7.5 KHz
(A) 1pF
(B) 0.1pF
(C) 1μF
(D) 0.1μF
ANSWER: 0.1μF
(A) 0.75
(B) 0.0075
(C) 0.075
(D) 7.5
ANSWER: 0.075
(32) Let a.c. flows through an inductance (with no resistance). The current
Consider a parallel RLC circuit, where R = 100 Ω, L = 20 mH and C = 10μF. The supply
voltage is 35 V with a frequency of 500 Hz
(A) 1292 mA
(B) 120mA
(C) 646 mA
(D) 969 mA
ANSWER: 646 mA
(A) Inductance
(B) Capacitance
(C) Resistance
(D) Same current will pass through all
ANSWER: Capacitance
(A) Resistance
(B) Inductance
(C) Capacitance
(D) Same current will pass through all
ANSWER: Resistance
(36) At what frequency the parallel RL circuit behaves as almost purely inductive?
(A) True
(B) False
(C) Depends on the circuit parameters
(D) None of the above
ANSWER: False
(38) A certain wire has a current of 35 mA. The charge passing through a given point
in the wire in 5 ms will be
(A) 125 pC
(B) 25 pC
(C) 175 pC
(D) 75 pC
View Answer / Hide Answer
ANSWER: 175 pC
(39) Two positive charges q1 and q2, each having magnitude of 2 pC are separated by a
distance of 0.05 millimeters. The force between charges will be