Escolar Documentos
Profissional Documentos
Cultura Documentos
Time Remaining:
The CIR can be no lower than the port speed of the local loop.
The CIR defines the contracted maximum rate available from the service provider on the Frame Relay circuit.
2 What are two WAN protocols that define parameters for data encapsulation? (Choose two.)
PPP
V.35
X.21
HDLC
EIA/TIA-232
Refer to the exhibit. What can be determined from the output of the show ip nat translation command?
Dynamic NAT addressing is enabled.
NAT overload is enabled on router R1.
The outside local and outside global addresses have been misconfigured.
The outside global address has been dynamically assigned from a NAT pool.
5
Refer to the exhibit. None of the hosts in network A are able to access the Internet. How can this problem be resolved?
Configure dynamic NAT instead of PAT.
6 Which command should a network administrator issue to disable default summarization in an EIGRP network?
Router(config-router)# no ip summary-address
Router(config-if)# no ip summary-address
Router(config-if)# no auto-summary
Router(config-router)# no auto-summary
Refer to the exhibit. Using the command ip route 192.168.1.0 255.255.255.0 10.1.1.2 150, the network administrator configu
new route. Which statement describes how the router will use the new route?
The new route will be ignored and will never be added to the routing table.
The new route will be added to the routing table and will be the primary route to the 192.168.1.0/24 network.
The previously existing dynamic route will be replaced with the new static route.
The new route will be displayed in the routing table if the dynamic routing information for this route is lost.
8 Why should default route redistribution be implemented in a multirouter RIP network?
allows for greater scalability in networks with multiple edge routers
provides the same gateway of last resort for every router in the network
allows for greater flexibility in networks with multiple vendor ISP connections
Refer to the exhibit. EIGRP has been configured on all routers in the network with default values. Which route will be installed
routing table of R1 to reach the 10.1.2.0/24 network?
The route through R2 will be installed.
10
Refer to the exhibit. The network administrator wants to restrict the Production network from accessing the HR network. All ot
traffic will have access to all networks. Which combination of interface and direction should the administrator use to apply the
Fa0/1, out
Fa1/0, out
Fa0/1, in
Fa1/0, in
11 Which function does the access layer provide in a hierarchical internetworking model?
It provides a high-speed backbone layer between geographically dispersed networks.
It provides hierarchical design between the core layer and the distribution layer.
It provides data security and traffic management for the core layer.
An ACL is active immediately after it has been created in global configuration mode.
A router compares a packet to all statements of an ACL before permitting or denying access through an interface.
13
Refer to the exhibit. All routers are configured to use the OSPF protocol with default settings. Which router will act as the BDR
routers start at the same time?
R1
R2
R3
R4
14 What are two benefits of implementing VLANs in an enterprise network? (Choose two.)
eliminates the need for a Layer 3 device
allows for the propagation of broadcasts from one local network to another
OPSF
RIPv1
RIPv2
16
Refer to the exhibit. RIPv2 has been configured on all routers. Host H2 attempts to ping host H1 but only half of the echo requ
result in successful echo replies. How can this problem be remedied?
Replace failed switch S1.
Add an entry for the 192.168.4.0 network to the routing table on R1.
17 Which three IP addresses are valid host addresses in the 10.200.0.0/20 network? (Choose three.)
10.200.11.69
10.200.16.1
10.200.0.255
10.201.0.55
10.200.15.240
10.200.30.29
IP is used to specify all TCP/IP protocols including TCP, UDP, ICMP and routing protocols.
Traffic can be filtered on source and destination address, protocol, and specific port number.
19
Refer to the exhibit. How many routers have established OSPF adjacencies with R1?
2
21 Which two addresses are RFC 1918 private addresses? (Choose two.)
10.192.32.67
64.10.10.2
172.31.220.7
172.168.12.1
192.16.0.1
22 Which address is used to access a switch from a remote location in order to make configuration changes?
the default gateway that is configured on the switch
the IP address configured on the VTY line that is used to establish an incoming connection to the switch
23 Which two statements are correct about Cisco HDLC encapsulation? (Choose two.)
It defines a Layer 3 framing structure.
24 What are two reasons for assigning switch ports to different VLANs? (Choose two.)
They increase network security.
25
Refer to the exhibit. Traffic from which network will be translated into a single public IP address?
10.0.0.0/24
192.168.0.0/23
192.168.1.0/24
192.168.2.0/24
192.168.3.0/24
26
Refer to the exhibit. What is the administrative distance for OSPF routes?
0
65
110
120
128
27
Refer to the exhibit. A network administrator is configuring an ACL on router R1. The purpose of the ACL is to ensure that traf
the Internet will only be allowed if it is in response to a request that is initiated from the internal network. However, after the AC
been applied, internal users report that they cannot visit external web sites. What can be done to solve this problem?
Remove the deny any any statement.
Add a permit tcp any any eq www statement to the top of the ACL.
28
Refer to the exhibit. A network support technician has been asked to set an IP address on one of the FastEthernet interfaces
router. What is causing the interface to reject the address?
The IP address is already in use.
29
Refer to the exhibit. A network administrator enters the command ip route 10.10.4.16 255.255.255.248 s0/0/1 into the router.
will be the result of this configuration?
A static route pointing to 10.10.4.16/29 is placed into the routing table.
A static route to 10.10.4.16/29 is placed into the routing table if interface FastEthernet0/1 goes down.
A static route pointing to 10.10.4.16/29 is only placed into the routing table if the route to 10.10.4.0 is removed.
A static route is not placed into the routing table because a RIP route that includes the destination network already exist
30
Refer to the exhibit. Workstation H1 is unable to reach the Internet. A network technician issues a ping command to troublesh
problem. Based on the results of the commands that are shown, what could be the cause of the problem?
The default gateway on H1 is incorrect.
31 Which type of documentation describes the procedures for teleworkers to connect to the company network by using a VPN co
business security plan
business continuity plan
32
Refer to the exhibit. All routers are configured to use the EIGRP routing protocol, and the network administrator has configure
interface with the displayed commands. Which summary route will show in the routing table of R1 as a result of these comma
a route pointing to the FastEthernet0/0 interface
33
Refer to the exhibit. Router1 and Router2 are both running RIPv1. Which subnet mask will Router1 associate with network 19
255.255.0.0
255.255.240.0
255.255.255.0
255.255.255.240
255.255.255.248
34 What factor is important to consider when configuring manual summarization with EIGRP?
EIGRP authentication must be enabled.
Networks that are being summarized must use the same subnet mask.
35 Which route will be excluded from the updates that are sent to the neighbor routers?
R 192.168.1.0/24 [120/1] via 192.168.100.1, 00:00:12, FastEthernet0/1
36
Refer to the exhibit. Which VTP function will this switch perform?
It will create, change and share local VLAN information with other switches in the XYZ domain.
It will forward to other switches the VLANs that are created in Switch1.
It will back up the VTP database for domain XYZ.
37
Refer to the exhibit. EIGRP has been configured on all routers in the network. Router R1 cannot form a neighbor relationship
the basis of the show ip protocols command output that is provided, what could be the cause of the problem?
Automatic summarization is enabled on both routers.
The metric value for K2, K4, and K5 parameters on both routers is set to “0."
38
Refer to the exhibit. The command that is displayed was run on a switch with 24 FastEthernet ports. Why are some ports miss
The missing ports are administratively down.
The missing ports are not configured for STP.
enterprise campus
enterprise edge
edge device
40
Refer to the exhibit. The network administrator has configured R1, R2, and R3 to use RIPv2, and the network is fully converge
the internal network are able to access R2, but they are unable to access the Internet.
Configure a default route on R2 and propagate it via RIPv2 to routers R1 and R3.
Configure a default route on the ISP, and it will be automatically propagated to all routers.
Configure a default route on R1, and it will be automatically propagated to all routers.
Add more VLANs to each switch and assign fewer users per VLAN.
42 What information is displayed in the output of the show version command on a router?
interface addresses
A PVC prevents small messages from being held up behind larger messages.
A PVC requires call set-up information to be sent before transmitting any data.
44 An organization is planning to expand by adding five new branches. After the expansion, it will require secured, full-time, and
connectivity for its new branch offices with the central office. There is only one port available on the central office router. Whic
can be used in this situation?
PPP
ISDN
Frame Relay
analog dialup
It designates the called device to control the frequency and timing of the authentication.
What are two best practices that should be followed when implementing access lists on a network?(Choose two.)
Edit ACLs directly on the router when troubleshooting.
Configure the same access group to filter incoming and outgoing traffic.
47
Refer to the exhibit. What is the lowest cost OSPF path for traffic that is sourced from H2 and destined for H3?
R3 to R5
R3 to R2 to R5
R3 to R4 to R5
R3 to R2 to R1 to R5
48
Refer to the exhibit. If R4 is announcing all shown internal networks as a summary address to the ISP, which summary
most specific?
192.168.1.0/22
192.168.4.0/21
192.168.6.0/23
192.168.8.0/21
192.168.4.0/22
49
Refer to the exhibit. A network administrator is configuring an ACL. Which statement is true about the effect of the ACL
A host with the IP address 192.168.10.22 is allowed to access the FTP server that has the IP address 172.17.2.2
A host with the IP address 192.168.10.42 is allowed to access the FTP server that has the IP address 172.17.2.2
A host with the IP address 192.168.10.12 is allowed to access the web server that has the IP address 172.17.2.2
A host with the IP address 192.168.10.52 is allowed to have SSH access to the server that has the IP address 17
50 Assuming VLSM is not being used, what impact will adding the command ip route 172.16.64.0 255.255.240.0 serial0/
that is already operational in a network?
All packets with a destination address between 172.16.64.1 and 172.16.80.254 will be forwarded out serial0/0.
All packets with a destination address between 172.16.64.1 and 172.16.255.254 will be forwarded out serial0/0.
All packets with a destination address between 172.16.64.1 and 172.16.79.254 will be forwarded out serial0/0.
All packets with a destination address between 172.16.0.1 and 172.16.64.254 will be forwarded out serial0/0.