Escolar Documentos
Profissional Documentos
Cultura Documentos
Easy
to operate
Unusually
high
I Environmentally
j
I friendly heating
Certified in
H accordance with I
efficiency • DS/EN ISO 90011
BAXI
Make yourself independent of carbon taxes, oil price increases and fossil fuels:
Fully automatic stoker boiler with hopper
for detached houses - agriculture - trade and business
The MULTI-HEAT type is especially suit- Construction and function The hopper must typically be filled up once
able for effective and environmentally or twice a week during cold weather,
The construction of the boiler gives high
friendly firing with bio-fuels such as wood however, this will depend on the heat requi-
operational security, significant durability,
pellets, wood chips and grain/corn. Please rement, hopper size and fuel. The possibility
good stoking economy, environmentally
consult the importer (or the factory) regar- of automatic feeding of fuel is also avail-
friendly combustion and simple operation.
ding possible use of other fuels. able. Ash is removed as required.
Depending on the heating requirement, the
feeder mechanism automatically leads a
Significant savings suitable quantity of fuel into the combustion A heat storage tank
chamber. Here the build-in blower produces
on your heat bills a precise mixture of primary and secondary
is unnecessary
The stoker boiler is especially applicable for air, resulting in a very high efficiency at The boiler output can be regulated from
owners of detached houses and the agricul- 89-91%. 100% down to 30% during continuous ope-
tural sector outside of the collective grid The temperature is regulated by a two-step ration and - by stoking at intervals - as low
energy systems (i.e. areas without district control. This means that the boiler is run- as approx. 1 kW. In order to maintain the
heating and natural gas). Firing with wood ning at full output until the set temperature boiler outside the heating season, at least
pellets, wood chips or grain/corn in MULTI- is close to being achieved - then the control one hot water tank (100-300 litres) as well
HEAT can achieve considerable savings in switches over to reduced output and conti- as 1-2 radiators or under-floor heating must
comparison to oil. Such savings depend, nues at this rate. If the boiler temperature be connected (open), but as such no large
amongst other things, on the type of fuel, drops slightly below the set temperature heat storage tank of 1.000-1.500 litres is >^/
purchase prices and the annual efficiency of again, the control will once again switch necessary. Whilst firing at intervals, the use-
the old oil boiler. Furthermore many local over to full output. This control ensures con- ful effect is lower.
governments, and possibly yours, are giving stant heat - almost like an oil-fired furnace. In order to obtain the best possible yield as
grants or subsidies for the installation of With regard to the efficiency of the pre- far as the firing economy, the environment
Multi Heat boilers using renewable energy combustion, the boiler size and adjustment and comfort are concerned, it is important
fuel. of the output ought to be only slightly that the boiler is correctly installed and ad-
greater than the building's requirement. justed.
For 75 years BAXIA/S - with it's approxi- based on strict requirements for material Reliability of operation, unique firing
mately 200 member Danish workforce - and technical construction design. economy and, not least, consideration of the
has been a pioneer in the development It has always been a part of the company's environment are factors which have been in-
and production of central heating objective that the products from BAXI A/S strumental in placing BAXI A/S as an inter-
boilers. should satisfy the users' requirements nationally recognised supplier of central
BAXI A/S has grown to be Denmark's regarding both the functional quality and heating boilers.
leading producer of central heating systems good taste. Currently, BAXI A/S carries out To maintain its leadership position, BAXI
used to supply the space heating and quality control in accordance with DS/EN A/S constantly looks to develop and
domestic hot water needs of private dwel- ISO-9001, which is an extensive, internatio- improve its products. There is never a
lings. nally recognised standard for quality control compromise of principle, solid quality, high
The production of BAXI A/S products are systems. output or timeless design.
Solid quality Control panel
Flue gas-affected, water-cooled steel This is placed above the doors and is
plates in the interior of the boiler are 6 operated from the front.
mm thick and especially exposed parts Easy to place in the room
of the combustion chamber are of acid- where it is to be set up Cleaning the boiler
free stainless steel. The flue-gas exit is from the top Removing ash and cleaning the fire
of the boiler and can easily be led
tubes can easily be carried out from
to the chimney. The doors are re-
versible and can be opened the front.
towards the left or the right.
MULTI-HEAT
Can be supplied with various sizes of
fuel hoppers (see technical details). The
door for the hopper is reversible so that
it is possible to fill up fuel either from
Wood pellets,
the back, or from the right or left side.
wood chips and
grain/corn
These are renewable, environmentally
friendly, inexpensive and often
domestic fuels which can replace
imported, more expensive and environ-
MULTI-HEAT
mentally straining fossil fuels (oil). A boiler for the future.
When firing with wood chips, a stirring
device must be mounted in the hopper,
as shown in the illustration.
Wood chips consist of wood which has been mechanical-
ly chopped to a suitably small size. Fine wood chips
must be used, 15-30 mm, or 5-50 mm with a maximum
water content of 25%.
15 cubic meters of coniferous or soft wood can substitute
approx. 1000 litres of oil. *
11 cubic meters of deciduous or hard wood can substitute
approx. 1000 litres of oil. *
o • ©
Extra accessories:
Pressure vessel set for automatic water sprinkling
Oxygen control for Multi-Heat
Shunt valve
VBF 100-200 MK II wall-hung hot water tank
VBF-S 150-200-333 floor sited hot water tank
Copper spiral for hot water for types 1.5 and 2.5
Cover with 2 inch socket for electrical element
for types 1.5 and 2.5
Draft stabiliser for chimney/boiler flue outlet
Automatic shunt control
External Feeding Unit
Fuel:
Suitable fuels: wood pellets, grain/corn and wood
chips. During combustion of wood chips a stirrer or
agitator must be fitted in the hopper (implementa-
tion F). Model 1.5 is principally developed for Technical data:
firing with wood pellets. If other forms of fuel are
desired, please contact the importer (or the factory). MULTI-HEAT Model 1,5 Model 2,5 Model 4,0
Operating temperature °C 60-85 60-85 60-85
Arrangement conditions: Output (nominal) with wood pellets kW 15 25 43
MULTI-HEAT must be set up in a room with a suf- Output (nominal) with grain/corn kW - 23 37
ficient supply of air. The magnitude of the air- Output (nominal) with wood chips) kW - 23 37
intake must correspond to the inside diameter of the
Output (minimum) with wood pellets kW 4,5 7,5 8
chimney, however at least 0.02 m2.
• The chimney draft must be at least 1.0-2.5 mm Output (minimum) with grain/corn kW - 6,8 9
water column. Output (minimum) with wood chips kW - 6,8 10
• Furthermore, the local building regulations in the Output (stand-by) recommended ** approx. kW 0,5 0,8 1,0
area of the installation must be followed.
• Request, if necessary, further installation and Smoke temperature at nom. output, wood pellets °C 130 170 158
operational guidelines with further information Smoke temperature at nom. output, grain/corn °C - 167 152
from the importer. Smoke temperature at nom. output, wood chips °C - 178 183
Smoke temperature at min. output, wood pellets *** °C 60 80 75
Our assortment of solid fuel boilers also
comprises the following: Smoke temperature at min. output, grain/corn *** °C - 85 80
Smoke temperature at min. output, wood chips °C 85 80
• MB-SOLO MK II (for wood, coal, coke and oil)
• SOLO INNOVA with induced draft (for forest Fuel consumption at nom. output, wood pellets kg/h 3,4 5,7 10
wood products - connected to the storage tank) Fuel consumption at nom. output, grain/corn kg/h - 6,0 11
• DUO PLUS COMPACT, double chamber boiler Fuel consumption at nom. output, wood chips kg/h 7,2 11
(for oil/gas and wood).
Test pressure, boiler bar 4,0 4,0 4.0
Guarantee: DTI-approved fuel types: wood pellets, approx. 8% water X X X
Fully effective guarantee as in accordance with gu- grain/corn (barley and wheat), approx. 15% water - X X
arantee conditions from the importer/dealer. wood chips, approx. 25% water X X
NB: Type MULTI-HEAT is supplied without built-
in hot water supply.
Installation data:
** Least recommended stand-by output whilst
firing at intervals so that the fire can be main- MULTI-HEAT Model 1,5 Model 2,5 Model 4,0
tained. ADepth - total mm 1435 1578 1693
*** This is the minimum smoke temperature BWidth - boiler mm 504 600 600
which is achieved by approval of the mini-
mum output. This smoke temperature is too C Height mm 1165 1475 1475
low for normal operation with ordinary chim- D Width - hopper * mm 504/904 600/1000 600/1000
neys. We consider a smoke temperature of Hopper volume litre 200/350 360/600 360/600
100°C to be the absolute minimum for ordina- Height to smoke pipe branch mm 1110 1455 1455
ry chimneys. We have therefore built in an
alarm on the smoke temperature at 100°C. Smoke pipe branch - external diameter mm 130 150 150
This is to say that if the smoke temperature Weight - empty kg 340-380 530-630 580-680
has been below 100°C for half an hour, the Water contents liter 50 125 150
boiler will stop. This alarm also ensures
against continually filling up with fuel if the Necessary door opening: Width D + 30 mm
fire has gone out.
BAX1
>ATTDN FTRF.WOOD
DISTRIBUTED BY 39B Park Farm Industrial Estate
Buntingford
Hertfordshire SG9 9AZ Smedevej, DK 6880 Tarm
Tlf. +45 97 37 1511 • Fax +45 97 37 24 34
Tel No: 01763 271271 E-mail: baxi@baxi.dk • www.baxi.dk
Fax No: 01763 271270
www.fbcgroup.co.uk
Publ. nr. 10420/0202 BAXI-katalog afsnit 5