Escolar Documentos
Profissional Documentos
Cultura Documentos
1000
1050
1100
1150
1200
1250
750
800
850
900
950
condition with a hardness of 38-42 HRC.
46
44
Hardness HRC
Characteristics 42
40
Applications
Welding Recommendations
• THYROPLAST® PH X SUPRA is recommended for tools/
molds for the processing of corrosive plastics. • THYROPLAST® PH X SUPRA can be welded using shielded
metal arc welding process. Oxyacetylene welding is not
Physical Properties (38-42 HRC) recommended.
• THYROPLAST® PH X SUPRA usually does not require
Density: 0.285 lbs./in3 (room temperature) preheating to prevent cracking
Coefficient of
700F – 2000F 700F – 4000F 700F – 7500F • AWS E/ER 630 filler material should be used to produce properties
Thermal
5.9 X 10-6 /0F 6.0 X 10-6 /0F 9.2 X 10-6 /0F comparable to the parent material.
Expansion
• If welded in the solution-treated condition, the welds can be aged
0
to the desired strength level after welding.
940 F
Thermal 700F 3000F
115 Btu/in/ft2/hr/0F 125 Btu/in/ft2/hr/0F
155 Btu/in/ft2/ • If welded in the over aged condition, the part must be solution
Conductivity
hr/0F treated and then aged. It may be advantageous to preheat to ap-
proximately 2000F and weld in the over aged (H 11500F) condition
for repair welds more than 1” deep or where high welding stresses
Mechanical Properties are anticipated.
Toughness (Charpy-V notch): 25 ft-lbs. at 38 HRC • For less critical applications, where high weld strength, hardness,
final polish or texture quality is not paramount a standard austenitic
Y.S stainless steel filler, E/ER308L, should be considered. This type of
Hardness T.S. EL
(0.2%) filler will not produce the precipitation hardening response.
HRC Ksi (%)
Ksi
Polishing
Tool should be polished using the guidelines for polishing
stainless steel. When properly polished, an A-1 surface finish is
achievable. .
General Notes
All statements regarding the properties or utilization of the materials or products
mentioned are for the purposes of description only. Guarantees regarding the
existence of certain properties or a certain utilization are only valid if agreed
upon in writing.