Escolar Documentos
Profissional Documentos
Cultura Documentos
1.
Refer to the exhibit. What is the meaning of the term dynamic in the output of the command?
The bandwidth capability of the interface increases and decreases automatically based on
BECNs.
The mapping between DLCI 100 and 172.16.3.1 was learned through Inverse ARP.
DLCI 100 will automatically adapt to changes in the Frame Relay cloud.
2.
Refer to the exhibit. What can be concluded from the exhibited output of the debug ip nat
command?
3. Which data link layer encapsulation protocol is used by default for serial connections
between two Cisco routers?
ATM
Frame Relay
HDLC
PPP
SDLC
4. Which technology is used to dynamically map next hop, network layer addresses to virtual
circuits in a Frame Relay network?
Inverse ARP
LMI
DLCI
FECN
5.
Refer to the exhibit. R1 is performing NAT overload for the 10.1.1.0/24 inside network. Host
A has sent a packet to the web server. What is the destination IP address of the return packet
from the web server?
10.1.1.2:1234
172.30.20.1:1234
172.30.20.1:3333
192.168.1.2:80
6. A network technician analyzes the network and notices late collisions. The collisions occur
accompanied by jabber that originates from the server. What is the likely cause of the
problem?
7. What is the result of adding the global command service password-encryption to the
configuration of a router?
cable connectivity
9.
a successful connection but inability to make configuration changes because of the absence of
an enable secret password
10.
Refer to the exhibit. Which data transmission technology is being represented?
TDM
PPP
HDLC
SLIP
11. A company is looking for a WAN solution to connect its headquarters site to four remote
sites. What are two advantages that dedicated leased lines provide compared to a shared
Frame Relay solution? (Choose two.)
reduced jitter
reduced costs
reduced latency
the ability to borrow unused bandwidth from the leased lines of other customers
12. Which type of ACL will permit traffic inbound into a private network only if an outbound
session has already been established between the source and destination?
extended
reflexive
standard
time-based
13. An issue of response time has recently arisen on an application server. The new release of
a software package has also been installed on the server. The configuration of the network has
changed recently. To identify the problem, individuals from both teams responsible for the
recent changes begin to investigate the source of the problem. Which statement applies to this
situation?
Scheduling will be easy if the network and software teams work independently.
It will be difficult to isolate the problem if two teams are implementing changes
independently.
Results from changes will be easier to reconcile and document if each team works in
isolation.
Only results from the software package should be tested as the network is designed to
accommodate the proposed software platform.
14.
Refer to the exhibit. The corporate network that is shown has been assigned network
172.16.128.0/19 for use at branch office LANs. If VLSM is used, what mask should be used
for addressing hosts at Branch4 with minimal waste from unused addresses?
/19
/20
/21
/22
/23
/24
15. Which IEEE 802.16 broadband wireless technology allows users to connect to the ISP at
speeds comparable to DSL and cable?
Wi-Fi
satellite
WiMAX
Metro Ethernet
16.
Refer to the exhibit. Based on the output as shown, which two statements correctly define
how the router will treat Telnet traffic that comes into interface FastEthernet 0/1? (Choose
two).
using alternate paths to avoid access control lists and bypass security measures
encapsulating an entire packet within another packet for transmission over a network
18. What functionality do access control lists provide in the implementation of dynamic NAT
on a Cisco router?
Refer to the exhibit. RIPv2 has been configured on all routers in the network. Routers R1 and
R3 have not received any RIP routing updates. What will fix the issue?
Enable CDP on R2 so that the other routers will receive routing updates.
21. Which two statements are true about IPv6 link local addresses? (Choose two.)
22. An administrator learns of an e-mail that has been received by a number of users in the
company. This e-mail appears to come from the office of the administrator. The e-mail asks
the users to confirm their account and password information. Which type of security threat
does this e-mail represent?
cracking
phishing
phreaking
spamming
NCP tests the link to ensure that the link quality is sufficient.
24. Where does a service provider assume responsibility from a customer for a WAN
connection?
local loop
demarcation point
demilitarized zone
25.
Refer to the exhibit. This serial interface is not functioning correctly. Based on the output
shown, what is the most likely cause?
interface reset
unplugged cable
26.
Refer to the exhibit. Which statement correctly describes how Router1 processes an FTP
request that enters interface s0/0/0 and is destined for an FTP server at IP address
192.168.1.5?
The router matches the incoming packet to the statement that was created by the access-list
201 deny icmp 192.168.1.0 0.0.0.255 any command, continues comparing the packet to the
remaining statements in ACL 201 to ensure that no subsequent statements allow FTP, and
then the router drops the packet.
The router reaches the end of ACL 101 without matching a condition and drops the packet
because there is no statement that was created by the access-list 101 permit ip any any
command.
The router matches the incoming packet to the statement that was created by the access-list
101 permit ip any 192.168.1.0 0.0.0.255 command and allows the packet into the router.
It matches the incoming packet to the statement that was created by the access-list 201
permit ip any any command and allows the packet into the router.
27.
Refer to the exhibit. Every time the administrator reboots this router, the boot process ends in
setup mode. What is a possible problem?
The bootstrap version and the version of the IOS are different.
28. Compared with IDS systems, what can IPS systems do to provide further protection of
computer systems?
30.
Refer to the exhibit. Partial results of the show access-lists and show ip interface
FastEthernet 0/1 commands for router Router1 are shown. There are no other ACLs in
effect. Host A is unable to telnet to host B. Which action will correct the problem but still
restrict other traffic between the two networks?
Modify the second entry in the list to permit tcp host 172.16.10.10 any eq telnet .
31. A network administrator has changed the VLAN configurations on his network switches
over the past weekend. How can the administrator determine if the additions and changes
improved performance and availability on the company intranet?
Conduct a performance test and compare with the baseline that was established previously.
Interview departmental secretaries and determine if they think load time for web pages has
improved.
Determine performance on the intranet by monitoring load times of company web pages from
remote sites.
Compare the hit counts on the company web server for the current week to the values that
were recorded in previous weeks.
32.
Refer to the exhibit. A network administrator is creating a prototype to verify the new WAN
design. However, the communication between the two routers cannot be established. Based on
the output of the commands, what can be done to solve the problem?
34. What are two effective measures for securing routers? (Choose two.)
35. Which combination of Layer 2 protocol and authentication should be used to establish a
link without sending authentication information in plain text between a Cisco and a non-Cisco
router?
36. While troubleshooting a problem with an e-mail server, an administrator observes that the
switch port used by the server shows "up, line protocol up". The administrator cannot ping the
server. At which layer of the OSI model is the problem most likely to be found?
application layer
network layer
physical layer
37.
Refer to the exhibit. From the output of the show interfaces and ping commands, at which
layer of the OSI model is a fault indicated?
application
transport
network
data link
physical
38. Which Frame Relay flow control mechanism is used to signal routers that they should
reduce the flow rate of frames?
DE
BE
CIR
FECN
CBIR
39. A network administrator is instructing a technician on best practices for applying ACLs.
Which suggestion should the administrator provide?
Extended ACLs should be applied closest to the source that is specified by the ACL.
40. When Frame Relay encapsulation is used, what feature provides flow control and
exchanges information about the status of virtual circuits?
LCP
LMI
DLCI
Inverse ARP
41.
Refer to the exhibit. Results of the show vlan and show vtp status commands for switches S1
and S2 are displayed in the exhibit. VLAN 11 was created on S1. Why is VLAN 11 missing
from S2?
42. An administrator is configuring a dual stack router with IPv6 and IPv4 using RIPng. The
administrator receives an error message when trying to enter the IPv4 routes into RIPng. What
is the cause of the problem?
When IPv4 and IPv6 are configured on the same interface, all IPv4 addresses are over-written
in favor of the newer technology.
43. What will be the result of adding the command ip dhcp excluded-address 192.168.24.1
192.168.24.5 to the configuration of a local router that has been configured as a DHCP
server?
Traffic that is destined for 192.168.24.1 and 192.168.24.5 will be dropped by the router.
Traffic will not be routed from clients with addresses between 192.168.24.1 and
192.168.24.5.
The DHCP server will not issue the addresses ranging from 192.168.24.1 to 192.168.24.5.
The router will ignore all traffic that comes from the DHCP servers with addresses
192.168.24.1 and 192.168.24.5.
44.
Refer to the exhibit. Headquarters is connected through the Internet to branch office A and
branch office B. Which WAN technology would be best suited to provide secure connectivity
between headquarters and both branch offices?
ATM
VPN
ISDN
Frame Relay
broadband DSL
45. Which configuration on the vty lines provides the best security measure for network
administrators to remotely access the core routers at headquarters?
Answer: 3nd option
46. When would the multipoint keyword be used in Frame Relay PVCs configuration?
47. Which option correctly defines the capacity through the local loop guaranteed to a
customer by the service provider?
BE
DE
CIR
CBIR
48.
Refer to the exhibit. A network administrator configures a standard access control list on
Router1 to prohibit traffic from the 192.168.0.0/24 network from reaching the Internet. The
access control list also permits traffic from the 192.168.0.0/24 network to reach the
192.168.1.0/24 network. On which interface and in which direction should the access control
list be applied?
49. Which three guidelines would help contribute to creating a strong password policy?
(Choose three.)
Write passwords in locations that can be easily retrieved to avoid being locked out.
Use long words found in the dictionary to make passwords that are easy to remember.
50.
Refer to the exhibit. A host connected to Fa0/0 is unable to acquire an IP address from the
DHCP server. The output of the debug ip dhcp server command shows "DHCPD: there is no
address pool for 10.1.1.1". What is the problem?
51. Which statement is true about PAP in the authentication of a PPP session?
52.
Refer to the exhibit. A network administrator is attempting to configure a Frame Relay
network. The administrator enters the commands as shown in the exhibit on R2, but the
Frame Relay PVCs are inactive. What is the problem?
The frame-relay map commands are missing the cisco keyword at the end.
A single router interface cannot connect to more than one Frame Relay peer at a time.