Escolar Documentos
Profissional Documentos
Cultura Documentos
1.1 DESCRIPTION:
A. The Work shall consist of furnishing and installation of all pipe expansion
joints as required, or as shown on the drawings and specified herein.
1.2 REFERENCES:
1.3 SUBMITTALS:
1.4 WARRANTY:
00 PART 2 - PRODUCTS
B. General: Provide bellow type joints where indicated for piping systems, with
pressure/temperature ratings to suit intended service. Select joints to provide
200% absorption capacity of piping expansion between anchors. All expansion
joints shall be factory tested to 150% of maximum rated pressure for 12 minutes
before shipment.
C. Rubber bellow type joints shall be peroxide cured EPDM throughout with
manufacturer’s standard tire cord reinforcement, single or double bellows as
applicable for the type of expansion joint. Expansion joints for copper pipes, 2”
and smaller shall have brass threaded ends, and 2-1/2” and larger shall have
interlocked ductile iron flanges. Expansion joints for steel pipes, 2” and smaller
shall have ductile iron threaded ends, and 2-1/2” and larger shall have
interlocked ductile iron flanges. Contractor shall provided calculations the
selected expansion joints for the approval of Engineer before ordering the
material.
E. Guides shall be constructed with steel base and T-bar with teflon or graphite
plates bonded to the steel components to allow minimum static friction and
self- lubrication for unlimited movement. Units shall be factory painted.
Guide base shall be welded to the pipe.
00 PART 3 - EXECUTION
3.1 INSPECTION:
END OF SECTION