Escolar Documentos
Profissional Documentos
Cultura Documentos
p 2.1
Pipe Tee Mesh
velocity-inlet-2 velocity-inlet-1
10. Set the Selection Filter to Faces
and select one of the pipe end
faces as shown. Right-click in the
Model View and choose Create
Named Selection. Enter velocity-
inlet-1 for the Selection Name
11. Repeat for the other two pipe end
faces using
g the namingg as shown
12. The Named Selections just pressure-outlet
created are listed in the Outline by
expanding Named Selections
Selections.
The names assigned here will be
transferred to the CFD solver so
the appropriate flow conditions
can be applied on these surfaces.
ANSYS, Inc. Proprietary April 28, 2009
© 2009 ANSYS, Inc. All rights reserved. 2-37 Inventory #002645
Introduction to the ANSYS Meshing Application
icon in the menu bar. Left click, Clicking on either side of the Plane tool will cut
the mesh on each side respectively. Clicking
hold and drag the cursor in the twice on one side will change the view to a planar
slice.
direction of the arrow as
When the position is finalized, select a view
illustrated to create the Section manipulation tool
Plane
18 Created
18. C t dS Section
ti PlPlanes are
listed (bottom left). Planes can
be individually activated using
th checkbox,
the h kb d
deleted
l t d and d
toggled between 3D element
view and 2D slice view. Try this
now (you
( will
ill needd tto rotate
t t th
the
model to see the cross-section)
ANSYS, Inc. Proprietary April 28, 2009
© 2009 ANSYS, Inc. All rights reserved. 2-39 Inventory #002645
Introduction to the ANSYS Meshing Application