Escolar Documentos
Profissional Documentos
Cultura Documentos
Step by Step procedures on how configure the LP-8186, LP-8186c, LP-8616, LP-8686, LP-8696 and LP-
9386 router on DHCP connection (PLDT, GLOBE, DIGITEL, SMARTBRO, WIMAX, WI-TRIBE and all Cable
Internet)
Set the Wiring Connection: MODEM - ROUTER - COMPUTER (desktop or laptop)
After connect all cable to the router, get your MAC Address
Click start and control panel
2
Select Switch to Category View on the left control panel and double click Network Connections
now copy the Physical Address value this is your computer MAC address
Now open internet browser it could be your windows default (Internet Explorer), Mozilla Firefox, Opera,
Netscape Navigator, Maxton, or Safari for windows. On the browser’s URL or Address bar, type the
default IP address of the router which is 192.168.1.254, and then press the “enter key”.
On the left site under Site contents click “TCP/IP Settings” and click on WAN Interface.
1. Select DHCP Client on WAN Access Type
2. Select Attain DNS Automatically
3. Fill your MAC address in the Clone MAC Address without dashes (capital or small letter is accepted)
4. Check all Enable box under of Clone MAC Address
5. click Apply Changes and wait for 15 seconds for the router to restart and initialize
4
Under Site content left menu click Wireless and click basic settings
1. In SSID you can change the default name, this is your WI-FI/Wireless router name
2. click Apply Changes and wait for 15 seconds for the router to restart and initialize
Note: On the browser’s URL or Address bar, type the new IP address of the router which is 192.168.10.254, and
then press the “enter key”.
Now click on the Management and click on “Status”, to check if your WAN Configuration has an IP
address and that you are already connected to the internet. Shown below:
Note: the IP Address below is sample only