Escolar Documentos
Profissional Documentos
Cultura Documentos
22)
Table 1 Appearance
Component (b)
Visually obvious, when the color difference ΔE ≤ 2 Arbitration
b: decorative patterns and color excluded.
For a table surface defects are not involved, in line with the requirement does not affect the demand side,
the principle agreed upon by both parties.
Table 4 Performance
Quality of visual appearance test should be in non-direct sunlight, natural light conditions. The direction
of the plate by the same production makes up side by side Celi side plate and the horizontal angle 70 ° ±
10 °, away from the center of the board makes up 3m at the visual. To the various defects of the visual,
the use of 1mm minimum scale is a ruler to measure the maximum size, the maximum size of defects in
Table 1 shall not exceed the ceiling set. Samples were not collected and placed in visual tests. When the
color of the visual results of disputes, arbitration test color by GB / T 11942 methods, test specimens
should be maintained in the direction of the consistency of production.
After the test specimen may not have a plastic phenomenon. According to GB / T 11942, GB / T 9754
and GB / T 1766 Measurement of the same direction the same position in the specimen before and after
color coating aging, loss of light levels, and other aging properties. Loss of color and light levels in all
samples as the arithmetic mean of the experimental test results, and other aging properties to all
specimens were the worst in the test results.