Escolar Documentos
Profissional Documentos
Cultura Documentos
Table of Contents
1.2 Version
2.1
5 October 2009
1.4 Purpose
CAUTION: If the player has the most recent firmware, there is no need to perform
a firmware update.
2) Press the [SETUP] button on the remote control to display the player’s MENU.
3) Using the [UP ARROW] or [DOWN ARROW] on the remote control, highlight
DISPLAY and then press [OK].
4) Press and hold the [STATUS] button on the remote control to display the current
firmware version in the lower right corner of the DISPLAY screen.
Reasons why the player may have a more recent firmware version:
• If the player was manufactured after the firmware was released, the firmware
update may have already been installed.
• If the player was serviced by an authorized Panasonic service center, a service
technician may have already installed the latest firmware update.
NOTES:
• Use one of the below methods to burn the firmware file to a CD-R disc.
• Use the ISO-9660 file system without using Joliet.
1) Insert a blank CD-R disc into a CD Burner Drive installed in or attached to the computer.
2) If the below (or similar) screen appears (Windows XP), left click on CANCEL.
3) Right click on the PANA_DVD.FRM file on the DESKTOP, mouse over SEND TO, and
then left click on the CD BURNER DRIVE.
6) Type a name for the CD, check the CLOSE THE WIZARD AFTER THE FILES HAVE
BEEN WRITTEN check box, and then left click on NEXT.
NOTE: The below screen will appear during the burning process.
7) After the PANA_DVD.FRM has been burned to the CD, the disc should automatically
eject from the CD Burner Drive. If it doesn’t, manually eject the disc.
Refer to the software application’s owner’s manual or HELP files for instructions on how to
copy the PANA_DVD.FRM to a CD-R disc using the ISO-9660 format without using Joliet.
Follow the procedure beginning with STEP 4) under SECTION 4.1 on PAGE 6 of 8.
1) Press the [POWER] button on the Blu-Ray Disc Player to turn it ON, if it is not already
powered ON.
2) Press the [OPEN/CLOSE] button to open the disc tray.
3) Load the CD with the firmware update into the disc tray.
4) Press the [OPEN/CLOSE] button to close the disc tray.
NOTES:
• After the disc tray closes, the player will first display BYE on the front panel
display, automatically turn itself OFF, restart again within a few seconds, and
begin installing the firmware update from the CD.
• If the player does not restart automatically following powering OFF, press the
[POWER] button on the main unit to turn it ON.
• During the installation process you’ll see various messages flash on the front
panel display.
• If the firmware version in the unit is the same as or higher than the firmware
CD, UNSUPPORT will scroll across the front panel display. In this case, an
update is unnecessary. Please remove the disc.
5) When the firmware installation is complete, FINISH will be displayed on the front panel
and the disc tray will open automatically. (If it doesn’t, press the [OPEN/CLOSE]
button.)
6) Remove the firmware update CD, but do not close the disc tray.
7) Press the [POWER] button to turn the power OFF. The disc tray will automatically
close and the unit will power OFF.