Escolar Documentos
Profissional Documentos
Cultura Documentos
Our Mission
Usually pump is operated manually at a predetermined level. Little negligence
or human error can cause overflow of the tanks or dry running of the motor, which in
turn damages the pump sets. This means loss of money, time and energy. For trouble
free pump operations use highly efficient digital technology based water level
controller.
Our newly introduced system namely Aqua Starter : Water Pump Controller &
Dual Tank Level Indicator (WPC-DTLI) System, is for domestic use. Therefore is
imperative to give a virtual demonstration and exhibition of working of the product for
the common domestic and household users as because this system will automatically
start the pump set as soon as the water level falls below the predetermined level
(usually 2/3rd tank) in the overhead Sintex tank and shall switch off the pump set as
soon as tank is full, thereby stopping the water pump before there is any overflow of
excess water. Aqua Starter : Water Pump Controller & Dual Tank Level Indicator (WPC-
DTLI) System, can also be used for indication of water level in the difficult to reach
overhead water tank by the number of lighted led lights. Thus, with the use of this
accordingly both precious water and costly electricity bills can be saved or reduced.
And that's not all, moreover, if the pump is running dry due to no availability of water
or low voltage, it sounds an alarm to alert you to switch off the controller system (and
hence the motor pump) to avoid burn and power wastage.
Finally, for the first time, an amazingly engineered IC based controller system
that adds a real new joy to your life. Painstakingly designed to ensure that you don't
have to worry about switching ON/OFF the pump. It works automatically by monitoring
the water level in the overhead tank & underground reservoir, using a safe and reliable
12volts D.C. Circuit. The built in Motor Protector protects the pump against dry pump
or jammed & airlock problems, Voltage Fluctuation.
Pumps controller systems are designed for providing maximum value for money
to the customer and total peace of mind. Once again this marvelous creation brought
to you by the pioneering giant, always innovative in your interest.
The new joy to life is to be experienced to be believed.
Introducing For the First Time for Domestic & Commercial Application for
Home, Office & Industrial Use.
Save Electricity ! Save Precious Water ! It Cuts Down Electricity Bill, Saves
Wastage Of Clean Water.
Fully Automatic, User Friendly, Easy To Install & Get Peace Of Mind, With
Better After Sales & Service.
Highlights
Automatically Starts/Stops Pumps. No Overflow.
Fully Automatic, Saves Daily On/Off Maintenance.
User-Friendly, Versatile, Dual Mode Operation,
Hygienic & Kills Germs & Durable, Easy Installations.
Dry Pump Alarm, Protects From Coil Burn, Airlock.
Optimum Usage Of Pump Maximizes Pump set's motor Life.
Prevents Wear & Tear Of The Pump & Excellently Durable.
Overhead Tank Level Indicators & Controller Panel.
Led Indicators Status panel for all functions and working State.
Ideal For Difficult To Reach Overhead Tank.
Manual Overriding switch for Emergency.
No Maintenance Cost. Efficient After Sales-Service Back-Up.
Compact & Elegant Design. Low Consumption Running Costs.
Protects Pumps From Power Surges & Short Circuits Problems.
Install This Pump Protector And Get Full Peace Of Mind.
Saves Wastage Of Precious Water & Costly, Electric Energy.
Avoid Seepage Of Roofs & Walls Due To Overflowing Tanks.
For Home, Office, Flats, Hotels & Industrial Applications.
Suitable For All Type of Pumps & Heights of Building.
Contact Information
TeleFax + 91- 3842267642,
Mobile + 91- 9435688087, + 91- 9313962444.
Address Apartment No - 19/2, Lane No - 19, Anandamoyee
Lane,
Vivekananda Road, Silchar, Assam (INDIA), Pin - 788007.
Electronic Mail
General Information (Sales) unicomsolutions@silchar.com
Webmaster (Customer Support) unicomsolutions@india.com
Website
Visit us for more details at http://unicomsolutions.orgfree.com/details.html
Send mail to sch_unicoms@bsnl.in with questions or comments about this web
site.
.
----------------------------------------------------------------------------------------
----------------------------------------------------------------------------------------
.
Copyright © 2007@ Unicom Solutions Provider. All rights Reserved.
( A House of Unique Consumer's Commodity Solutions Provider)
Models Available :
Aqua Starter (Domestic) : Single Phase General Water Pump up to 2.5 H.P.
For pumping water from underground reservoir to overhead tank by the help of
General pump of 5 H.P.
Aqua Starter (Commercial) : Single Phase compatible to Jet Water Pump up to 2.5
H.P. ( DOL/ Star Delta Starter.)
For pumping water from underground bore well to overhead tank or filter by the
help of Jet pump of 5 H.P.
Salient Features
Water pump will switch ON the pump automatically when the overhead tank is
empty and switch OFF the pump when it is full Also it will switch OFF the pump if the
under ground sump becomes empty while pumping and switch ON the pump when
water is filled in the sump Water level sensing done by the proven Electrode Switch.
The sensing circuit works on 12 volts D.C. for safety and reliability. In the event of any
other problem (except water pump failure, Air Lock) the Motor Protector circuit
implanted for early warning by alerting the user with a buzzer to check the problem
and reset the system, thereby the pump will be protected from coil burning or motor
damage.
We are strictly committed to deliver Innovative High Quality products matching
with the erratic power supply and environmental conditions. All the incoming
components are strictly inspected as per the norms of quality control and quality
checks are ensured at every stage of production to establish reliability, which enhance
customers' confidence and satisfaction.
Our main motto is: EXCELLENT QUALITY AT MINIMUM COST.
Since long, dire necessity has been felt for consistent and high quality products
especially at minimum cost in the Indian market. The objective of Unicom Solutions is
to establish leading position and trust in the market by:
Selecting key factors which influence the market needs.
Being initiative and responsive to market needs Bringing out new more and
more quality products at minimum cost.
By nurturing consistent organizational skills. Creating highly motivated
professionals & technically competent individuals to bring out excellence.
Above all, servicing whatever we sell.
----------------------------------------------------------------------------------------
----------------------------------------------------------------------------------------
.
Copyright © 2007@ Unicom Solutions Provider. All rights Reserved.
----------------------------------------------------------------------------------------
----------------------------------------------------------------------------------------
.
Copyright © 2007@ Unicom Solutions Provider. All rights Reserved.
----------------------------------------------------------------------------------------
----------------------------------------------------------------------------------------
.
Copyright © 2007@ Unicom Solutions Provider. All rights Reserved.
Service One
6 months Warrantee on Aqua Starter (Domestic), 6 months Guarantee on Aqua
Starter (Domestic)
For pumping water from underground reservoir to overhead tank by the help of
General pump of 1 H.P. Power.
Service Two
EXTENDED Warrantee on Aqua Starter (Commercial), EXTENDED Guarantee on
Aqua Starter (Commercial)
For pumping water from underground bore well to overhead tank or filter by
the help of Jet pump of 1 H.P. Power.
Exhibits latest Digital Technology with Electrolysis Proof system.
Prevents wastage of water & power, tank overflow, dry running of motor, wear
& tear of motor.
Fully Auto Control of Underground/ Overhead tank, so no manpower is required.
Levels of tanks are indicated by green LEDs.
Pump Motor is fully protected from Under/ Over Voltage Fluctuations.
Emergency "ON" facility to start Pump Motor at any water level of tank.
Aluminum extruded body for maximum heat dissipation and corrosion
resistance.
All electrical are enclosed for maximum safety.
Polyurethane powder coating for great protection and greater looks.
Bureau of Indian Standards applied for approval as per IS: 9079 and IS:
8472
Pumps available in Mini Monobloc, Centrifugal and Jet pump models.
Pumps suitable for 230V/50Hz power supply running at 2800 rpm.
Pumps carry a warranty for 6/12 months from the date of purchase against
manufacturing defects.
Instructions
This Product is intended to be professionally installed.
You are using this unit at your own risk and cost. Our liability during the
warranty period is restricted to the repair/replacement of this system unit only. Under
no circumstance can our company be held liable for any incidental or consequential
damages.
Unicom Solutions Provider's Introduces for the first time the most user friendly,
automatic water pump & tank level controller system, it not only saves on electricity
bills but also stops the wastage of clean water due to spillage through the overflow
pipeline of the overhead Sintex tank when it is full to brim.
The system starts the water pump when the water level in the overhead tank is
below the predetermined level and also stops the water pump as soon as the
overhead tank is full to avoid the overflow of water. It has also the dry pump alarm
system that sounds off when it detects that the pump is running but is not pumping up
water up to the overhead water tank.
----------------------------------------------------------------------------------------
----------------------------------------------------------------------------------------
.
Copyright © 2007@ Unicom Solutions Provider. All rights Reserved.
( A House of Unique Consumer's Commodity Solutions Provider)
----------------------------------------------------------------------------------------
.
Copyright © 2007@ Unicom Solutions Provider. All rights Reserved.
System Specifications
One 2P/4T Starter AUTO MODE / MANUAL MODE.
One Push to On Starter Emergency Pump On in Activator Mode.
One Push to Off Starter Emergency Pump Off in Activator Mode.
Alarm Conditions Dry Pump running Alarm.
Tank Level Indicator Panel, Seal leak
Optional
detection.
Technical Specifications
Supply Voltage 1 phase 50/60Hz, 220 - 240V AC,
Input Voltage 12v Dc to 14.5v Dc.
Relay Contact 10 Amps.
Operation Continuous
Output Voltage 3v to 12v.
Max. Current 16 A
Min. Current 7.5 A
Electrode Voltage AC 6.0V
Electrode Current <0.1 Ma
Probe cable Three wires does not be screened.
Max. Cable length 300 meters.
Protection grade IP54
Operating Temperature -20 C To 60 C (-5 F To 140 F)
Controller Type Electronic Circuit Board with IC Chip.
Thermal Coolant Sensor in Water-Proof/ no
Sensor Type
rusting.
Controller Weight 300 G (10 Oz) // 1.5 Kg. Approx.
23cm x 21cm x 5cm // 10-5"(H) X 8-5"(W)
Dimension
X 4-5"(D) approx.
Part No.
Description Price ($)
Product Features
Intelligent control, protect function, Activator-pump when lack water in upper cistern,
Activator stop operation when lack water in lower cistern and water full in upper
cistern, motor over-load protect, motor lack-phase protect and short-circuit protect
etc.
Use CPU boards for 3rd generation product, its feature is: precise, stable, long life, low
waste and easy to maintain.
Every three-phase unit has the function of stable pressure water supply and cistern
water supply control at the same time.
Widely used in family water supply, piping water supply, pipe pressure increase, pipe
stable pressure, decontamination, fire control etc and industrial use.
Descriptive Features
The unique solution for such problems is our product known as WATER PUMP
CONTROLLER - DUAL TANK LEVEL INDICATOR SYSTEM or Aqua Starter works as if,
when your overhead tank is empty Aqua Starter automatically switches on the Pump.
When the tank is full it switches off the pump.
Aqua Starter wills Automatically START the pump set as soon as the water
level falls below the predetermined level (usually 2/3rd tank) and shall Starter OFF the
pump set as soon as tank is full or water level in the lower tank is at below minimum
level.
Aqua Starter provides you the flexibility to decide for yourself the water levels
for operations of pump set in upper/lower tanks. Built in Indications for showing Full,
Low Levels in Upper Tank.
Aqua Starter is user-friendly and dual mode operation facilities, like AUTO /
MANUAL operation Starter for special operations like watering the plants from pump
set.
The Aqua Starter ensures no overflows or dry running of pump there by saves
electricity and water.
Low AC Voltage sensing circuit to avoid polarization of electrodes in water
(requires very rare cleaning of electrode ends). Provided with special stainless steel
conductive electrodes.
Aqua Starter protects your pump from power fluctuations. Aqua Starter cuts
off the motor during high or low voltage and automatically resets when normal voltage
resumes. In case of air lock or motor jamming.
Aqua Starter switches on the alarm system to alerts you with a melodious
buzzer, to help check the problem of DRY Running thereby prevent coil burn.
Aqua Starter consume very little energy, ideal for continuous operation and
therefore is and reliable.
Aqua Starter : Water Pump Controller & Dual Tank Level Indicator System (WPC-DTLI)
It is a simple electronic circuit based component. That gives indications,
regarding the level of water present, in the over-head water tank of a multi- storied
building that has water supply pipelines for the distribution of water for both
household and commercial use. This system gives the user, the benefit of knowing the
level of water in the water tank by the number of lighted LED lights or by the beeping
sounds of an alarm, which reminds the user, that the pump is running dry with no
water to pump up and to stop it, so as to save the pump from burning. This system not
only indicates the quantity of water present in the tank but also automatically starts
and stops, the water pump, when there is the need of filling the tank or when there is
chance of water overflowing from the tank. Thus this system when installed can save
the user from the trouble of going up-stairs to see the quantity of water present in the
tank directly or visually. But, that's not all; it saves the unnecessary wastage of clean
and life saving water being overflowed, due to timely stopping of the pump and also
user saves the amount of electricity bill that accumulates to a large sum of money, at
the end of the each month. So, this system reduces and saves electricity bill and
wastage of water, when installed, for both domestic and commercial uses in the urban
areas.
To provide automatic control to water pump. Starts the pump when level in the
overhead (destination) tank is LOW and switches it off when the tank is FULL. This is
suitable where the source of water is unlimited (like groundwater or in case of a tube-
well). Models to operate single-phase pumps directly or 3-phase pump through its
starter coil.
SELF-AUTO MODE
You start the pump, but often forget to Starter it off, resulting in OVERFLOW -
wastage of both electricity and water, in addition to messing up of surroundings, and
damaging walls and roof. TRIPPER switches off the pump automatically, when the tank
is full.
All systems are stand-alone, fully functional, and suitable for direct application.
Input voltage 220 V AC. We offer control systems for most liquids. To get your
quotation, please send in detailed requirement.
The unit may also have a level indicator to give the availability in each tank.
The level indicator can be placed at any suitable location near the pump room.
These combined with Level indication and Alarm provides comprehensive
control and protection in water supply and all its applications. Similarly these are
effective in ETPs and Sewage Treatment plants to operate the complete scheme based
on levels and other inputs from different sensors and monitors. Please contact us with
your requirements in details.
Large Applications
Most large buildings and Housing complexes have a requirement for storage
and handling of water. Where raw water is drawn from ground, there is a further
requirement of purification of water before supply. Further there is a requirement of
treatment of wastewater and it's handling and disposal. It implies managing
wastewater pumps through automation. Hotels, Restaurants, Dairies, Municipal
corporations and Industrial users It is important for consultants and architects to
design water supply and disposal in such a way as to ensure that the users never have
to worry about handling pumps and checking levels as a routine.
Where a number of buildings are supplied water from one set of pumps, a very
effective plan is through a ring-main, which supplies water to all the feeders. This type
of systems is operated based on levels. The system is configured to operate in such a
way that the pump will be switches ON when level in any ONE tank drops, but will be
switches OFF, when all the tanks are full.
All tanks are provided with normally open sensor probes. These are
independent of the water level controller and operate as Float /submersed type sensor
probes. Each tank has one level controller to prevent overflow. As each tank gets filled
up, it gives the signal to the pump to Starter off. Just below this overflow level (the
outlet pipe) of this tank, thereby preventing overflow. When the last tank fills up, the
pump switches off.
The unit may also have a level indicator to give the availability in primary tank.
For the level indication, system can be placed at any suitable location near the pump
room.
----------------------------------------------------------------------------------------
----------------------------------------------------------------------------------------
.
Copyright © 2007@ Unicom Solutions Provider. All rights Reserved.
Product Introduction
This full automatic pump controller (case) specially designed for automatic
water supply from reservoir or deep well. It helps the pump to automatically control
the motor & to start or stop according to the water level of the underground reservoir
or well and overhead water tower, which implements the pump to work safely and
reliably without care. Then, it will save electric energy and human power.
The controller has the protection functions of open-phase, overload, low-
voltage, short-circuit etc, which can effectively avoid the unexpected damage of the
motor.
On the panel of this controller, there are starting and stop button, full tank &
low tank indicator, system status indicator (there will be no water/Airlock/motor jam
indication, by alarm to alert the user). it has auto and manual operation change
Starter. The general operations and running condition of the pump can be
accomplished and monitored on the panel.
The power is 220-volt single-phase and its frequency is 50Hz.The fluctuation of
the power voltage can't overpass 10 percent of the rated voltage e.g. it should be
200V to 240V. Besides the power, what the single-phase controller (case) differs from
the three-phase one is that there is no comprehensive protector for motor inside.
There are packed and unpacked capacitors in the single-phase controller (case), then,
the clients can make a choose referring to the practical condition.
Features
Aqua Starter or Automatic Water Pump - Tank Level Controller System will
automatically START the pump set as soon as the water level falls below the
predetermined level (usually 2/3rd tank) and shall Starter OFF the pump set as soon as
tank is full or water level in the lower tank is at below minimum level.
Aqua Starter provides you the flexibility to decide for yourself the water levels
for operations of pump set in upper/lower tanks.
Built in Indications for showing Full, Empty Levels in Upper Tank and Lower
Tank Empty Indication.
MANUAL operation Starter for special operations like watering the plants or car
washing from pump set.
Aqua Starter ensures no overflows or dry running of pump there by saves
electricity and water.
Low AC Voltage sensing circuit to avoid polarization of electrodes in water
(requires very rare cleaning of electrode ends). Provided with special stainless steel
conductive electrodes.
Consume very little energy, ideal for continuous operation, and hygienic too.
Price
MODEL: Aqua Starter :( Domestic ) - Rs. 1850.00 /- only (US$ ) ,Commercial -
Rs. 4400.00 /- only (US$ ) for single-phase motors up to H.P. ratings. (Prices do not
include any wires required for interconnection).
Prices are all inclusive of taxes applicable, packing and courier charges within
India or by EMS Speed Post in other countries wherever service is available. For export
enquiries kindly contact by E-mail at: unicomsolutions@silchar.com. Please send
payments by D.D. in favour of Unicom Solutions Provider payable at Silchar. No
outstation Cheque or D.D. is accepted.
Warranty
Unicom Solutions Provider's Aqua Starter : ( Water Pump Controller & Dual
Tank Level Indicator System ) is provided with 6/12 months free service warranty
against any manufacturing defect. (Defective items should be sent with return postage
prepaid) along with copy of purchase to our Silchar Works or New Delhi or Bangalore
service center. We assure a quick and satisfactory after sale service to our all
customers.
Delivery
In case an order is placed on us we usually dispatch goods within one week by
suitable courier service or registered post parcel if courier service is not available,
after receipt of 100% payment by cash/bank draft along with written order. There
might be change in delivery time due to any circumstances and we shall not be
responsible for any consequences. Customers are also advised to suggest their
preferred courier or transport service.
Query
For any further queries or business correspondence, Please mail your query to
unicomsolutions@silchar.com or call us at our help line no : 9435688087,
9859983736.
Designatio
Name
n
Address Company
TeleFax
E-mail
No
Phone
Mobile
(Off)
Phone
Remarks
(Resi)
----------------------------------------------------------------------------------------
----------------------------------------------------------------------------------------
.
Copyright © 2007@ Unicom Solutions Provider. All rights Reserved.
Name
Permanent Address
Phone No
No of floors in building
Water container type ( ) - Sintex ( ) - Concrete ( ) - Others
No of water tank
Tank Capacity (in Ltrs)
No of Taps/ outlets
No of motor pump
Pump capacity (in hp)
Type of water pump ( ) - General pump ( ) - Jet pump ( )-
Submersible pump
Remarks (if any)
Declarations
I, ............................................................................................. of
address ............................................................................................. hereby
acknowledge the Introductory offer and want to buy the system for domestic /
commercial use at my home / office.
I will pay for all that, to get the system properly installed by your authorized
technician. And would like to get all the benefit of this system, from time to time.
I, solemnly declare that, I would like to avail the Trial Period Offer of Aqua
Starter, and like to test use the product for 15 (fifteen) days. After the trial period, I
would like to Fill-Up the Customer Feedback Form and give my suggestion for better
product and service. Thanking you.
Dated,
Place,
Signature of Consumer.
License Agreement
Unicom Solutions, Inc. licenses the accompanying hardware/software to you
only upon the condition that you accept all of the terms contained in this license
agreement. Please read the terms carefully before continuing installation, as selecting
"I Agree" below will indicate your assent to them. If you do not agree to these terms,
press the "CANCEL" button to exit the installation process. The product, which
accompanies this license ("Product") is the property of Unicom Solutions, Inc. and is
protected by copyright law.
The product is provided "as is", without warranty/guarantee of any kind, either
expressed or implied, regarding the operation of the product, including warranties of
merchantability or its fitness for use for any particular purpose. By installing the
product, you agree to accept all liability regarding its use or misuse. You will be
granted certain rights to use the Product upon acceptance of this license. Your rights
and obligations are as follows:
You May
Use one set of the Product on a single water pump & tank; you may also use
this product on a second tank, provided the Product will not be in use on more than
one water tank simultaneously.
Make the system checked by authorized company service personal only, every
three months for the purpose of backup better service and efficiency.
General
This License Agreement shall be governed by the laws of the State of Assam
without regard to principles of conflicts of laws and shall inure to the benefit of Unicom
Solutions, its successors and assigns. Any disputes relating hereto shall be adjudicated
in the state or federal courts in the State of Assam and you hereby consent to the
exclusive jurisdiction of said courts. If for any reason a court of competent jurisdiction
finds any provision of this License Agreement, or portion thereof, to be unenforceable,
that provision of the License Agreement shall be enforced to the maximum extent
permissible so as to affect the intent of the parties, and the remainder of this License
Agreement shall continue in full force and effect.
YOU ACKNOWLEDGE THAT YOU HAVE READ THIS AGREEMENT, UNDERSTAND IT, AND
AGREE TO BE BOUND BY ITS TERMS AND CONDITIONS. YOU FURTHER AGREE THAT
THIS IS THE COMPLETE AND EXCLUSIVE AGREEMENT BETWEEN THE PARTIES.
----------------------------------------------------------------------------------------
----------------------------------------------------------------------------------------
.
Copyright © 2007@ Unicom Solutions Provider. All rights Reserved.
( A House of Unique Consumer's Commodity Solutions Provider)
Home Product Service Details Order Feedback News
NEWS The Company Banner
The company is extending its Distributors & Dealers network all over the
North East, Interested persons are asked to read the underlined notes for reference &
enrollment as franchised members.
To,
......................................................................
.......................................................................
Subject : Proposal for authorized franchised dealership for our unique product namely
"Aqua Starter" under the banner of Unicom Solutions Provider.
Dear Sir/Madam,
With due honor and respect, I, on behalf of the Unicom Solutions Provider, wish
you, to become an authorized franchised dealership member and thereby avail all the
benefits of marketing and sales of our unique product namely Aqua Starter, this is
versatile water pump controller system, which will automatically start the pump set as
soon as the water level falls below the predetermined level (usually 2/3rd tank) in the
overhead water tank and shall Starter off the pump set as soon as tank is full, thereby
stopping the water pump before there is any overflow of excess water from the tank.
With the use of this accordingly, both precious water and costly electricity bills can be
saved or reduced. And that's not all, moreover, it protects the water pump from short-
circuit, power fluctuation & low voltage, & if the pump is running dry due to no water,
it sounds an alarm to alert you to Starter off the controller system (and hence the
motor pump) to avoid burn and power wastage. So, it can also be termed as Aqua
Starter, an ultimate & Universal Water Pump Protector or Water Pump Controller -
Dual Tank Level Indicator System (WPC - DTLI).
Unicom Solutions Provider is a leading consumer commodity, computers and
company solutions provider in entire northeast region. Since its emancipation from the
year 2005 with main center at Delhi & East Zone at Silchar. With sustained efforts
'Unicom Solutions Provider' was able to develop products for both class and common
consumer, at economical rates that could fulfill the needs of different categories of
people with different requirements.
Our clients and consumers have the luxury of choosing from economical range
to sophisticated, world class standard, products and; we ensure that our valued clients
and consumers select the best products and get the efficient after sales services for
themselves.
Apart from these, another venture 'Unicom Solutions Provider' has been
imparting various other business associates plans and policies for high income and job
orientations amongst the unemployed youths with skills or no skills in this competitive.
Therefore, we write to request you to be a part of Unicom Solutions Provider by
taking franchisee at a nominal rate.
Looking forward for your positive response and counting on your support.
Thanking you.
Dated
Place (Franchisee Manager.)
Enclosed: A copy of brochure with products and its features and other
official formalities.
Appendix
Acknowledgement
I, Partha Sarathi Nath on behalf of Unicom Solution Providers, thank all
those, who have helped me by their valued advices and suggestions for making this
project a success, but as you all know the proverb "Necessity is the mother of every
invention". So also there is a cause for this effective remedy. Let me quote a small
incident that urged me to think for a solution to such a small but great problems, that
not only makes us to pay hefty sum of money for electricity but still, we lose a great
deal of precious water every month, and that's not all, still we have to be alert to
Starter off the pump or else a lot of water will get overflowed, all due to, not timely
switching off the water pump in both domestic and commercial buildings.
It so happened, one day early in the morning, I woke up on hearing the
sound of the water motor pump running, that lifts water from the underground
reservoir to the over-head water tank. I quite in sleepy mood came out of my bed to
see who turned the water pump so early in the morning. To my utter disbelief, I found
that my mother was strolling impatiently on the balcony. I enquired what made, why
she turned on the pump so early in the morning, at this she replied that, she woke up
and went to bathroom to brush her teeth and wash her face. But to her utter dismay,
when she turned on the tap of the washbasin, she found that it was dry, to verify if
there is water in the tank, or it is empty, she turned on the other taps but the
condition was same as there was no water in the overhead Sintex tank. So it became
essential to turn on the water pump. So she was standing to shut off the pump when
the tank is full. Then I asked her why was strolling impatiently in the balcony, she told
me, that she has to urgently answer to the nature's call. So, she asked me to keep a
watch, to Starter off the water pump, when the overflowing, excess water will fall from
the overflow pipe of the overhead Sintex tank, as a sign of the water tank full. Saying
so, she went to bathroom, to answer to the call of the nature as her usual early
morning habit. After she went in side, I remained there, waiting with sleepy eyes, to go
to bed, after switching off the water pump. As time was passing by and me waiting for
the glimpse of the falling water, as it took time to fill the whole Sintex tank, filled up to
the brim with water. But as all knows that waiting is boring, and that too for switching
off the water pump, when the whole world is fast changing from manual to automatic,
like we use Inverter to give us electricity when there is load shading or power failure,
or like the washing machine that cleans our cloths automatically, or the dish cleaner
that cleans our used cups and plates, than an idea came to me, why not go to the
market to buy such a product to lessen the trouble of filling and controlling the water
tank, so also the pump. When I enquired into different electrical and electronic shops, I
found that, they don't have such a product to sell me that can help the people like us,
from the trouble of switching the water pump on or off. After my futile search, to get
some remedy for my need, I thought and decided that if, I can't get something to
mitigate my pain, than I should make such gadget to help my mother and other
people who need such sophisticated but useful home user gadget, from the trouble
that we face every day.
So, with that aim, my journey into this venture began, after much
observation and analysis, into the cause and need, for such a unique gadget and it's
necessity and effect on water users, made vigorous experiments and trials. At last
after much failure and tiresome Labour, the final but the perfect system was devised,
which was not only, user friendly, better in terms of service but is hygienic also and
that's not all because the most interesting fact is that, it's maintenance cost was nil.
Once installed, the user gets complete peace of mind from all the troubles of water
pump and tank related problems.
My honest, sincere thanks and warm regards to my friends & Well- Wishers,
without whose help and encouragement in every sphere, I could not have been able to
complete my project, and I thank all my other friends and well wishers, who helped
me, with there suggestions and encouragements, from the core of my heart.
-----------------------------------------------------------------------------------------
-
-----------------------------------------------------------------------------------------
-
.
Copyright © 2007@ Unicom Solutions Provider. All rights Reserved.