Escolar Documentos
Profissional Documentos
Cultura Documentos
664-30 160 28
diegoalbertocruz2020@gmail.com
SUMMARY
Bilingual Sr . Engineer more than 12 years of experience on quality and manufacturing of electronics, IPC
std and electromechanical products. Experience on Medical Industry on scientific molding of pipette tips
and laboratory supplies. Experience on New Product Introduction,TPS, LEAN tools SPC,FMEA, 8D, Poka
Yoke, One Piece Flow, set up statistical metrics. Internal ISO-9000 Auditor, FDA CFR 820.75 And ISO
13485 certification. English spoken 90%
Process Engineer
● Issue sample request to build pipette tips and medical laboratories products using different resins polymers
under scientific injection molding polymers.
● Setting molding parameters and validations of new resins to lower cost.
● Implement Statistical Process Control,
Process engineer
● Responsible for Transfer Repair center of Circuit card assemblies as well as new build of
GPS satellite system
● Improve quality avoiding mistake with POKA yoke mistake proof during assembly.
● Issue procedures to meet ROHS (Pb free) and others hazards raw materials as well as
hazard scrap due European regulations on electronics products.
Product Engineer
● Implement Engineer change orders, ECOS, ECNs,
● Issue ECOs, DCRs, Update BOMS of cabinet and front cover of new TV models.
● Validate Injection Molding of front and back cover of TV under Scientific Standards as well FCC
requirements.
● Established Corrective and Preventive Action team,
EDUCATION
Electromechanical Engineer
Universidad Juarez Autonoma de Tabasco 1989-1994
CINVESTAV Instituto Politécnico Nacional, I.P.N , 1994-1998 Applied Physics Master Degree,
REFERENCES
Ing. Francisco Aviña -tel. 627-14-00, Ing. Alberto Fragoso, 627 -14-00
Ing Francisco Blancas- tel. 6 27 14 00
Ing. Alfonso Tirado- tel. 607-25-13